Related Manuals for Holman Q3-95ARB
Summary of Contents for Holman Q3-95ARB
- Page 1 ® CONVEYOR TOASTER MODEL Q3-95ARB Installation and Operation Instructions 2M-Z10141 Rev. C 6/9/2007 9H-Q3-95ARB...
-
Page 2: Safety Symbol
SAFETY SYMBOL These symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. RETAIN THIS MANUAL FOR FUTURE REFERENCE NOTICE Using any part other than genuine Star factory supplied parts relieves the manufacturer of all liability. -
Page 3: Specifications
SPECIFICATIONS Q3-95ARB-V02 Rating/Connection: 4200 Watts (700W elements), 20.5 Amps at 208V NEMA 6-30P plus with six foot oil-resistant cord Electrical Supply: 208VAC, single phase Approximate Weight: Installed - 60 Lbs (27.22 kg) Shipping - 68 Lbs (30.84 kg) Dimensions: Width: 18.5"... -
Page 4: General Information
General Information This equipment is designed and sold for commercial use only by personnel trained and experienced in its operation and is not sold for consumer use in and around the home nor for use directly by the general public in food service locations. CAUTION Before using your new equipment, read and understand all the instructions &... -
Page 5: Assembly And Installation
ASSEMBLY AND INSTALLATION The unit was shipped fully assembled and ready to plug into a standard outlet specifi ed for its voltage and amp draw. If improper electrical supply is determined, contact a qualifi ed electrician prior to using the unit. Removal and replacement of the power cord and plug voids the warranty. - Page 6 Toasting Procedures This toaster is equipped with a swinging heat shutter at the toaster entrance. This shutter will move out of the way as the product passes under it. 1) Turn the power saver to FULL POWER. 2) Allow warm up time of 5 to 10 minutes. 3) Place a product on the conveyor belt.
- Page 7 CLEANING Preventive maintenance for your Holman toaster consists of the following recommended cleaning procedures. To keep your toaster in top operating condition, these steps should be performed daily or weekly as indicated. 1. Wipe exterior surface of unit, using mild detergent and water.
-
Page 8: Troubleshooting Guide
The front edge of the enclosure will slide beneath the toaster front. D. Heat Limit Switch (Reset) Your Holman conveyor toaster is equipped with an automatically activated heat limit switch that interrupts the heater tube connections if the ambient temperature in the control box exceeds 190°F (88°C). -
Page 9: Maintenance Procedures
Maintenance Procedures A. Replacing the Heater Tubes 1) DISCONNECT UNIT FROM POWER SOURCE. 2) Remove the enclosure. 3) Remove heater tube wire from terminal block connection, keeping top and bottom wires separate. 4) Lift heater tube retainers by loosening retaining screws and sliding the retainer plate up. Hand tighten the plate to hold it up so the heater tubes will slide out freely. - Page 10 Visit our Website at: www.star-mfg.com Email: service@star-mfg.com THOROUGHLY INSPECT YOUR UNIT ON ARRIVAL This unit has been tested for proper operation before leaving our plant to insure delivery of your unit in perfect condition. However, there are instances in which the unit may be damaged in transit. In the event you discover any type of damage to your product upon receipt, you must immediately contact the transportation company who delivered the item to you and initiate your claim with same.
-
Page 13: Parts List
PARTS LIST June 19, 2007, Rev. C Q3-95ARB Conveyor Toaster Number Part Number Description Number Unit 2M-Z10370 LABEL - TOASTER WARNING HH-101371 ENCLOSURE, HH-402470 PANEL, BACK, 2U-200561 MOTOR, FAN 2E-200566 SWITCH, HIGH LIMIT RESET 2U-200509 MOTOR, DRIVE, FAN BLADE NOT INCLUDED... -
Page 14: Left Side
CORD RESET/HIGH LIMIT POWER SAVER ® MODEL: QCS-3-1300 208/220/240V w/FUSE Q3-95ARB 208/240 w/FUSE STAR MANUFACTURING INTERNATIONAL INC. THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. SK2255 Rev - 06/8/2007 NO REPRODUCTION OR DISCLOSURE OF ITS CONTENTS IS PERMITTED. - Page 16 STAR MANUFACTURING 10 Sunnen Drive, St. Louis, MO 63143 U.S.A. (800) 807-9054 (314) 781-2777 Parts & Service (800) 807-9054 www.star-mfg.com...