Checking The Coolant Level; Checking The Cooling System - Yamaha YZFR1Y(C) 2009 Service Manual

Pressure gauge
90890-03153
YU-03153
Oil pressure adapter H
90890-03139
5. Measure:
• Engine oil pressure
(at the following conditions)
Oil pressure
240.0 kPa/5000 r/min (2.40 kgf/
cm²/5000 r/min, 34.8 psi/5000
r/min)
Oil temperature
75.0–85.0 °C (167.0–185.0 °F)
Out of specification → Adjust.
Engine oil pressure Possible causes
Below specification
Above specification
6. Install:
• Main gallery bolt
Main gallery bolt
8 Nm (0.8 m·kgf, 5.8 ft·lbf)
EAS21110

CHECKING THE COOLANT LEVEL

1. Stand the vehicle on a level surface.
TIP
• Place the vehicle on a suitable stand.
• Make sure the vehicle is upright.
• Faulty oil pump
• Clogged oil filter
• Leaking oil passage
• Broken or damaged
oil seal
• Leaking oil passage
• Faulty oil filter
• Oil viscosity too
high
3-29
PERIODIC MAINTENANCE
2. Check:
• Coolant level
The coolant level should be between the
maximum level mark "a" and minimum
level mark "b".
Below the minimum level mark → Add the
recommended coolant to the proper level.
ECA13470
• Adding water instead of coolant lowers
the antifreeze content of the coolant. If
water is used instead of coolant check,
and if necessary, correct the antifreeze
concentration of the coolant.
• Use only distilled water. However, if dis-
tilled water is not available, soft water
may be used.
3. Start the engine, warm it up for several
minutes, and then turn it off.
4. Check:
• Coolant level
TIP
Before checking the coolant level, wait a few
minutes until it settles.
EAS21120

CHECKING THE COOLING SYSTEM

1. Remove:
• Side cowlings
• Lower cowlings
Refer to "GENERAL CHASSIS" on page
4-1.
2. Check:
• Radiator "1"
• Radiator inlet hose "2"
• Radiator outlet hose "3"
• Oil cooler inlet hose "4"
• Oil cooler outlet hose "5"
• Oil cooler "6"
• Water jacket joint "7"
• Water jacket joint hose "8"