Char-Broil Commercial Series Assembly, Use And Care Manual page 11

WARNING WARNING WARNING
WARNING WARNING
• Do not use grill until leak checked.
• If leak is detected at any time, STOP and call the Fire
Department.
• If you cannot stop a gas leak, immediately turn gas
off at gas source and call natural gas supplier or
your fire department!
Leak Testing Valves, Hoses and Regulator
1. Turn all grill control knobs to OFF.
2. Be sure regulator is tightly connected to LP tank.
3. Completely open LP tank valve by turning hand wheel counter
clockwise. If you hear a rushing sound, turn gas off
immediately. There is a major leak at the connection. Correct
before proceeding.
4. Brush soapy
solution onto
following
connections:
5. "If growing" bubbles appear, there is a leak. Close LP tank
valve immediately and retighten connections. If leaks
cannot be stopped "do not try to repair." Call for
replacement parts. Order new parts by giving the serial,
model number and name of items needed to the Grill Service
Center at
!1-800-241-7548 U.S. or 1-800-387-6057 CAN.
6. Always close LP tank valve after performing leak test by
turning hand wheel clockwise.
Safety Tips
When grill is not in use, turn off all control knobs and gas
source.
Never move grill while in operation or still hot.
When moving the grill push it forward, do not pull from
behind.
Use long-handled barbecue utensils to avoid burns and
splatters.
Do not remove grease receptacle or tray until grill has
completely cooled.
If you notice grease or other hot material dripping from grill
onto valve or regulator turn off gas supply at once. Determine
the cause, correct, clean and inspect valve and regulator
before continuing. Perform a leak test.
The regulator may make a humming or whistling noise
during operation. This will not affect safety or use of grill.
If you have a grill problem see the "Troubleshooting Section".
WARNING WARNING
WARNING WARNING WARNING
For Safe Use Of Your Grill:
• Do not let children operate or play near grill.
• Keep grill area clear and free from materials that burn.
• Do not block holes in bottom or back of grill.
• Check burner flames regularly.
• Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch, covered
patio, or under a surface that can catch fire.
• Use grill at least 3 ft. from any wall or surface. Maintain 10
ft. clearance to objects that can catch fire or sources of
ignition such as pilot lights on water heaters, live
electrical appliances, etc.
• Do not use charcoal, briquets or lava rock in this grill.
Apartment Dwellers:
•
Check with management to learn the requirements and
fire codes for using a Gas Grill in an apartment. If allowed
use outside on the ground floor with a three (3) foot
clearance from walls or rails. Do not use on or under
balconies made of wood.
• NEVER attempt to light burner with lid closed. A
buildup of non-ignited gas inside a closed grill is
hazardous.
463231603 • 11