1. Manuals
  2. Brands
  3. Quadra-Fire Manuals
  4. Wood stove
  5. YOSEMITE-MBK
  6. Owner's manual

Quadra-Fire YOSEMITE-MBK Owner's Manual

Yosemite series non-catalytic, front/side load, wood heater installation and operation
Hide thumbs Also See for YOSEMITE-MBK:
Table of Contents

Advertisement

Quick Links

Download this manual See also: Owner's Manual, Operation & Installation Manual
•
If the information in these
instructions is not followed
exactly, a fire may result causing
property damage, personal injury,
or death.
• Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
• Do not overfire - If heater or chimney
connector glows, you are overfiring.
Overfiring will void your warranty.
• Comply with all minimum clearances to
combustibles as specified. Failure to comply
may cause house fire.
Installation and service of this appliance should
be performed by qualified personnel. Hearth &
Home Technologies recommends NFI certified
professionals, or technicians supervised by an
NFI certified professional.
www.quadrafire.com
Non-Catalytic, Front/Side Load, Wood Heater
Installation and Operation
DO NOT DISCARD THIS MANUAL
• Read, understand and
Important operating
a n d m a i n t e n a n c e
instructions included.
WARNING
Yosemite
Owner's Manual
Models:
YOSEMITE-MBK
YOSEMITE-PMH
CAUTION
follow these instructions
for safe installation and
operation.
Hot glass will cause burns.
•
Do not touch glass until it is cooled
•
NEVER allow children to touch glass
•
Keep children away
•
CAREFULLY SUPERVISE children in same room
as fireplace.
•
Alert children and adults to hazards of high
temperatures.
High temperatures may ignite clothing or other
flammable materials.
•
Keep clothing, furniture, draperies and other
flammable materials away.
7004-187H
R
Tested and
Listed by
C
OMNI-Test Laboratories, Inc.
• Leave this manual with
party responsible for
use and operation.
WARNING
HOT SURFACES!
Glass and other surfaces are
hot during operation AND
cool down.
WARNING
Fire Risk.
For use with solid wood fuel only.
Other fuels may overfire and generate
poisonous gases (i.e. carbon monoxide).
O-T L
Portland
Oregon USA
US
June 23, 2011

Advertisement

Table of Contents
loading

Related Manuals for Quadra-Fire YOSEMITE-MBK

Summary of Contents for Quadra-Fire YOSEMITE-MBK

  • Page 1 Owner’s Manual Installation and Operation O-T L Tested and Portland Oregon USA Listed by Models: OMNI-Test Laboratories, Inc. YOSEMITE-MBK YOSEMITE-PMH CAUTION DO NOT DISCARD THIS MANUAL • Read, understand and • • Leave this manual with Important operating follow these instructions...

  • Page 2: Table Of Contents

    & Home Technologies welcomes you to our tradition of unit is meticulously fabricated and gold and nickel surfaces are excellence! In choosing a Quadra-Fire appliance, you have our hand-finished for lasting beauty and enjoyment. Our pledge to assurance of commitment to quality, durability, and performance.

  • Page 3: Section 1: Listing And Code Approvals

    TION DUCT OR SYSTEM. May allow flue gases to enter the house. Fire Risk. Quadra-Fire is a registered trademark of Hearth & Home NOTE: Hearth & Home Technologies, manufacturer of • Do not operate appliance before reading and Technologies.

  • Page 4: Negative Pressure

    Yosemite Wood Stove Yosemite Wood Stove D. Flue Draft Considerations F. Tools And Supplies Needed C. Negative Pressure To minimize the affects of negative air pressure the follow- Location of the appliance and chimney will affect perfor- Before beginning the installation be sure that the following ing must be considered: Draft is the pressure difference needed to vent appliances mance.

  • Page 5: Typical Stove System

    Yosemite Wood Stove Yosemite Wood Stove H. Typical Stove Systems Spark Arrestor Cap Dimensions and Clearances Stove system with masonry chimney Fireclay Flue Liner Concrete Cap With Air Space consists of: Figure 8.1 • Stove NOTE: Flue Collar size is 6 inch Rafter A.

  • Page 6: Clearances To Combustibles

    Yosemite Wood Stove Yosemite Wood Stove B. Clearances To Combustibles (UL And ULC) Installation Considerations Non-fuel Max Mantel Depth door side 10" (254mm) In Canada, similar floor protection must be provided 18 A. Hearth Protection Requirements inches (457mm) in front and 8 inches (203mm) from the Ceiling Ceiling FLOOR PROTECTION: Floor protector must be non-...

  • Page 7: C. Horizontal Flue Heat Shield

    Yosemite Wood Stove Yosemite Wood Stove A. Hearth Protection Requirements (Cont'd) B. Reversible Flue Collar SIDE FUEL DOOR LOCKED SHUT - CORNER Tools Required: Phillips head screwdriver; 3/8" and 7/16" wrench The flue collar is reversible for either a top or rear venting installation.

  • Page 8: Leg Leveling System

    Yosemite Wood Stove Yosemite Wood Stove F. Outside Air Kit Installation D. Leg Leveling System Instructions To Unlock Side Fuel Door ncluded in Kit: 2 cable ties; oustide air termination cap; 1. Thread Allen bolts through nuts until flush. Figure 14.1. 1.

  • Page 9: Chimney Requirements

    Yosemite Wood Stove Yosemite Wood Stove Thimble Site constructed for masonry chimney installation: Chimney Requirements Components ceiling 13.5” below ceiling to top • A minimum length of 12 inches [305mm] (longer for thicker of opening A. Venting Components Wall B. Chimney Systems or top of opening is a min.of walls) of solid insulated factory-built chimney length con- 4.5”...
  • Page 10 Yosemite Wood Stove Yosemite Wood Stove C. Installing Chimney Components Masonry Chimney Liner Masonry Chimney Liner (Cont'd) Min. Chimney Clearance to Wall Spacer and Chimney Connector Min. Clearance For optimal performance, masonry chimneys used to vent Combustibles - 2 inch (51mm) 2 inch (51mm) Single wall connector or stove pipe.

  • Page 11: Section 6: Mobile Home

    • Trees, buildings, roof lines and wind conditions affect • performance. You must use a Quadra-Fire Outside Air Kit Part Must have an approved and Listed cap Spark Arrestor • Chimney height may need adjustment if smoking or 831-1780 for installation in a mobile home.

  • Page 12: Section 7: Appliance Set-Up

    Yosemite Wood Stove Yosemite Wood Stove Appliance Set-Up Operating Instructions B. Adjusting The Blower Speed Control B. Wood Selection and Storage A. Door Handle Assemblies A. Over-Firing Your Appliance *If Necessary 1. Install washer on door handle shaft. WARNING 2. Slide door handle through door. WARNING *The blower speed control for this unit is adjusted at the 3.

  • Page 13: Burning Process

    Control. For more air push control IN, for less air pull control water instead of heating your home, and when the flammable gases have been mostly burned and In order to improve the situation, we at Quadra-Fire have OUT. See Figure 25.1. •...

  • Page 14: Heat Output Settings

    Yosemite Wood Stove Yosemite Wood Stove H. Building A Fire F. Heat Output Settings I. Optional Blower Operating Instructions WARNING For maximum operating efficiency with the lowest Before lighting your first fire make certain that the emissions, follow these operating procedures: 1. Initial (cold) start-up: Leave blower off until your stove baffle and blanket are correctly positioned. They Fire Risk.

  • Page 15: Clear Space

    Yosemite Wood Stove Yosemite Wood Stove M. Correct Baffle & Blanket Placement K. Clear Space INCORRECT POSITIONS • Do NOT place combustible objects within 4 ft (1.2 m) of the front of fireplace. Figure 28.1. WARNING WARNING Fire Risk Firebox damage due to improper baffle place- Fire Risk.

  • Page 16: Maintaining & Servicing Appliance

    Yosemite Wood Stove Yosemite Wood Stove 3. Disposal of Ashes 5. Glass Cleaning Maintaining & Servicing Your Appliance • Frequency: As desired • Frequency: When ash is within 1-3/4 in. (44mm) of firebox • By: Homeowner 2. Ash Removal System (ARS) Operating and Cleaning •...

  • Page 17: Appliance Inspection - Routine

    Frequency: After ash removal Replace the door on the appliance. • By: Homeowner Quadra-Fire stoves are equipped with ceramic super Replace the firebrick if they become crumbly and/or if there is Baffle Board heat-resistant glass, which can only be broken by impact a 1/4 inch (6.35mm) gap between the bricks after adjustment.

  • Page 18: Quick Reference Maintenance Guide

    Yosemite Wood Stove F. Quick Reference Maintenance Guide Start the first inspection after the first 2 months of use, or if performance changes, and adjust your schedule Troubleshooting Guide accordingly. Maintenance is required for safe operation CAUTION! Allow the appliance to completely cool and must be performed to maintain your warranty.

  • Page 19: Service Parts & Accessories

    Ending Manufacturing Date: Active Non-Catalytic, Front/Side Load, Wood Stove Ending Manufacturing Date: Active YOSEMITE-MBK (7-03 to Active), YOSEMITE-PCR (8-03 to 11-06), YOSEMITE-PGR (8-03 to 2-05), IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement YOSEMITE-PMB (8-03 to 2-05), YOSEMITE-PMH (8-03 to Active) parts for your appliance please provide model number and serial number.
  • Page 20 YOSEMITE YOSEMITE Service Parts Service Parts Beginning Manufacturing Date: July 2003 Beginning Manufacturing Date: July 2003 Ending Manufacturing Date: Active Ending Manufacturing Date: Active #19 Brick Set Post SN #1750842 #18 Brick Set Pre SN #1750842 IMPORTANT: THIS IS DATED INFORMATION. When requesting service or Stocked replacement parts for your appliance please provide model number and serial number.

  • Page 21: Service & Maintenance Log

    Yosemite Wood Stove YOSEMITE Service Parts C. Service And Maintenance Log Beginning Manufacturing Date: July 2003 Ending Manufacturing Date: Active Date of Service Performed By Description of Service IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed Stocked in this manual may be ordered from an authorized dealer.
  • Page 22 Yosemite Wood Stove Yosemite Wood Stove Page 42 7004-187H June 23, 2011 June 23, 2011 7004-187H Page 43...

  • Page 23: Contact Information

    Hearth & Home Technologies 1445 North Highway Colville, WA 99114 Division of HNI INDUSTRIES Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer, log onto www.quadrafire.com CAUTION DO NOT DISCARD THIS MANUAL •...

This manual is also suitable for:

Yosemite-pmh

Table of Contents