Rules For Safe Operation - Troy-Bilt TB45E Operator's Manual

PLEASE READ - SAVE THESE
INSTRUCTIONS
When using an electrical appliance, basic precautions
should always be followed to assure maximum safety and
optimum performance. Read this manual before assem-
bling and operating this appliance. Failure to comply with
instructions may result in electrical shock, burns, fire, or
personal injury.
WARNING
TO REDUCE THE RISK OF ELECTRIC
SHOCK, BURNS, FIRE OR PERSONAL
INJURY:
FOLLOW ALL SAFETY INSTRUCTIONS listed in
1.
this manual before/during operation of this trimmer.
TO REDUCE THE RISK OF ELECTRIC SHOCK this
2.
equipment has a polarized plug (one blade is wider
than the other). This plug will fit in a polarized exten-
sion cord only one way. If the plug does not fit fully in
the extension cord, reverse the plug. Do not change
the plug in any way.
3. INSPECT UNIT FOR DAMAGE to the housing or
plug. Keep all fasteners tight. Do not use if the trigger
does not turn the unit off properly. Never use unit if
cord or plug has been damaged, the motor or unit
itself is not working as it should or has been dropped,
damaged, left outdoors or dropped in water. Never
operate with any air opening blocked. Keep air open-
ings free of debris that may reduce air flow. Replace
damaged parts that are chipped, cracked or damaged
in any way. Keep cutter knife sharp.
4. DOUBLE INSULATED to help protect against
electric shock. Double insulation construction
consists of 2 separate "layers" of electric insulation.
Appliances built with this insulation system are not
intended to be grounded. As a result, the extension
cord used with your unit can be plugged into any con-
ventional 120 volt electrical outlet. Normal safety pre-
cautions must be observed when operating an electri-
cal appliance. The double insulation system is only for
added protection against injury resulting from a possi-
ble internal electrical insulation failure.
5. EXTENSION CORD - Use only with an extension cord
intended for outdoor use. Match wire gauge to the
cord length. See table below. A 2-wire cord without a
ground connection may be used since this appliance
is double insulated. If in doubt of proper wire size, use
the next heavier gauge. Please note that the smaller
the gauge number, the heavier the cord.

RULES FOR SAFE OPERATION

MINIMUM WIRE GAUGE RECOMMENDATIONS
EXTENSION CORD
VOLTS
120
*American Wire Gauge
(1). When using the appliance, an extension cord of ade-
quate size must be used for safety and to prevent loss
of power and overheating.
(2). The extension cord must be specifically intended for
outdoor use and marked "SJ" or "SJT" and with the
suffix "WA". In Canada, the extension cord must be
marked "SFTW".
(3). Inspect extension power cord for loose or exposed
wires and damaged insulation. If damaged, replace
before using appliance.
DO NOT ABUSE CORD - Never carry appliance by
cord or pull cord to disconnect from outlet. Keep cord
clear of operator and obstacles at all times. Do not
expose cord to heated surfaces, oil or water. Do not
pull cord around sharp edges, corners or close door
on cord.
NO SERVICEABLE PARTS INSIDE - Your dou-
6.
ble insulated appliance has no serviceable parts
inside. Do not attempt to repair it yourself. For service
information, contact the Troy Bilt Product Service
Department listed on the back cover of this User
Manual.
7. RISK OF EYE INJURY - Always wear goggles or
other suitable eye protection when operating your
trimmer. Edging increases the risk of injury caused by
flying debris. Always keep bystanders at a safe dis-
tance.
KEEP HANDS AND FEET AWAY from rotating line.
8.
Do not operate without debris shield attached.
DRESS PROPERLY - Always wear long pants, shoes
9.
and gloves. Do not wear loose clothing, jewelry, short
pants, sandals or go barefoot.
10. KEEP AREA CLEAR - Keep everyone, especially
children and pets away from the area of operation 50
feet (15m). Turn off unit immediately if you are
approached. Never allow children to operate the appli-
ance, to be used as a toy, or to run unattended at any
time.
11. AVOID A DANGEROUS ENVIRONMENT - Do not
use in the presence of flammable liquids or gases,
smoking or burning materials to avoid creating a fire
or explosion. Never operate the trimmer in wet or
damp conditions or around swimming pools, hot tub,
etc. Do not use in rain. Do not handle plug, cord or
appliance with wet hands.
4
WIRE SIZE
LENGTH REQUIRED
25 feet / 7.5m 18 A.W.G.*
50 feet / 15m 16 A.W.G.*
100 feet / 30m 16 A.W.G.*
Table 1