Testing The Installation; Gasoline Fuel System - Generac Power Systems 004702-0, 004703-0, 004704-0, 004705-0, 004706-0, 004707-0 Owner's Manual

HOT AIR
EXHAUST
TAILPIPE
516.2
526.2
TYP.
NOTE: ALL AIR INTAKES AND EXHAUST OUTLETS MUST BE KEPT CLEAR OF ANY
OBSTRUCTIONS. ALL OPEN AREA IS REQUIRED FOR COOLING.

6.3.2 TESTING THE INSTALLATION

Generac recommends testing the installation to be
sure adequate cooling airflow is available to the unit
before placing the unit into service. If the unit shows
signs of overheating, you will need to enlarge the air
openings. Never place a unit into service until
absolutely certain that cooling and ventilation is ade-
quate.
You must test the installation, especially if you
bring in air from below the generator set.
6.4

GASOLINE FUEL SYSTEM

DANGER
Gasoline is highly flammable, and its vapors are
explosive. Comply with all codes, standards and
regulations pertaining to gasoline fuel systems
used in recreational vehicle generators.
Properly install and maintain the fuel system
and keep it entirely free of leaks. Gasoline
vapors must not enter the vehicle interior.
26 Generac ® Power Systems, Inc.
Section 6 – Installation
QUIETPACT 55, 65, and 75 Recreational Vehicle Generators
Figure 6.8 — Compartment Floor Cutout
25.4
45˚
5
226.5
NOTE:
821.2
469
195.8
344.6
305.9
70.8
3/8"-16 WELDNUTS
(8 PLACES)
545
FRONT
574.7
834.9
The installation of a gasoline fuel system (Figure
6.14) for a recreational vehicle generator set must
comply with applicable codes, standards and regula-
tions. The entire fuel system must be completely free
of leaks. There must be no possibility of gasoline
vapors entering the vehicle interior.
Figure 6.14 – Generator Fuel System
VIEW FROM TOP
233.2
4
YP.
AIR INTAKE
536.2
FUEL INLET
90
126.2
57
Fuel Line
564.1
Fuel Pump
(Behind Access
Cover)
Fuel Filter
(Side of Unit)