Maintenance And Troubleshooting - NordicTrack Audiostrider Cx650 Elliptical User Manual

MAINTENANCE AND TROUBLESHOOTING

Inspect and tighten all parts of the elliptical exerciser
regularly. Replace any worn parts immediately.
To clean the elliptical exerciser, use a damp cloth and
a small amount of mild soap. IMPORTANT: To avoid
damage to the console, keep liquids away from
the console and keep the console out of direct
sunlight.
CONSOLE TROUBLESHOOTING
If the console displays become dim, the batteries
should be replaced; most console problems are the
result of low batteries. See assembly step 9 on page 9
for replacement instructions. If the handgrip pulse sen-
sor does not function properly, see step 5 on page 17.
HOW TO ELIMINATE RUBBING OF THE DISCS
If the Discs (12) rub against the Side Shields (14, 15)
during use, make sure that the Leveling Foot (40) is
installed in the Frame (1). If the Leveling Foot is
installed, loosen the two indicated M8 x 25mm Bolt
Sets (88) and the two M4 x 16mm Round Head
Screws (78) in each side of the elliptical exerciser.
88
14, 15
12
Adjust the position of the Side Shields (14, 15) until the
Discs (12) no longer rub against them, and then tighten
the M8 x 25mm Bolt Sets (88) and the M4 x 16mm
Round Head Screws (78).
HOW TO ADJUST THE BELT
If the pedals slip while you are pedaling, even while
the resistance is adjusted to the highest setting, the
belt may need to be adjusted.
1
40
78
21
1. See assembly step 12 on page 11 and remove the
left pedal arm and the left link arm.
2. See EXPLODED DRAWING B on page 27 and
remove the four M4 x 16mm Blunt Screws (81)
and the left Disc Cover (13).
3. Next, remove
the four M8 x
25mm Button
Screws (87)
from the center
of the left
Crank Arm
(55). Then,
gently remove
the left Disc
(12) from the
elliptical exer-
ciser.
4. Next, tighten the M8 x 25mm Bolt (105) until the
Belt (74) is tight.
5. Reverse steps 3 to 1 and reassemble the elliptical
exerciser.
HOW TO LEVEL THE ELLIPTICAL EXERCISER
If the elliptical exerciser rocks slightly on your floor
during use, see HOW TO LEVEL THE ELLIPTICAL
EXERCISER on page 12.
12
87
87
74
105
55