Installation; General; Rating Plate; Positioning And Setup - Garland CXBE12 Installation & Operation Manual

GARLAND ELECTRIC CLAMSHELL BROILER GRILL, CXBE12 MODEL

INSTALLATION

THIS PRODUCT IS NOT AUTHORIZED FOR HOME OR RESIDENTIAL USE. GARLAND WILL NOT PROVIDE
SERVICE, WARRANTY, MAINTENANCE, OR SUPPORT OF ANY KIND OTHER THAN IN COMMERCIAL
APPLICATIONS.

General

In the United States the installation must comply
with the latest edition of the National Electrical
Code ANSI/NFPA 70 – latest edition and/or local
Codes to assure safe and effi cient operation.
In Canada, the installation must comply with
local codes and CSA B149.1 and handling Code
–latest edition and the Canadian Electrical Code
C22.1 – latest edition.
In other countries installation must be carried out
by a factory authorized service representative
according to the relevant regulations, codes of
practice and the related requirements of the
country of destination.
Adequate clearance must be provided for
servicing and proper operation.
If you have any questions regarding the
installation of this unit, contact the Garland
Service Department at (855)-586-1542 or Garland
Regional Service Managers.

Rating Plate

Two (2) rating plates will be intalled on each unit,
and they can be found:
a. Inside the front panel under the electronic
touch control.
b. Outside the right side panel, lower left side.
If service or replacement parts
are needed, refer to the model
number (including prefi x &
suffi x letters/numbers) and
serial number on the rating
plate when in contact with the
factory or authorized service
agency. These numbers ensure
b
proper unit identifi cation, faster
a
and more accurate service.
Part #4532096 Rev 6 (25 Oct 2013)

Positioning and Setup

CAUTION
The unit is very heavy (500 Lbs) so some form of
mechanical assistance is recommended to lift
and position the broiler.
The unit is designed to be placed on a smooth
and level fl oor built to withstand the weight
of the fully laden appliance. To comply with
NSF Sanitation Standards the unit must stand
on casters for ease of mobility during cleaning
procedures.

Appliances Equipped with Casters

All broilers are shipped with casters intalled
in place, however some adjustment may be
required to level the unit. The front casters are
adjustable swivel casters with brakes. The rear
casters are fi xed. Garland recommends installing
restraining chains/cables from the fl oor/wall to
the rear of the unit. These restraints limit the
mobility of the appliance.
FRONT CASTER WITH BRAKE
INSTALLATION OPERATION MANUAL
Heavy load
Use of lifting aids
and proper lifting
technique required
REAR CASTER WITHOUT BRAKE
Page 9