Co2175F/2175Rf/Co2175Dwr - U-Line 2115R Service Manual

CO2175F/2175RF/CO2175DWR

COMPRESSOR/COIL SPECIFICATIONS
DANGER DANGER
Electrocution can cause death or serious injury. Burns from hot
or cold surfaces can cause serious injury. Take precautions when
servicing this unit.
• Disconnect the power source.
• Do not stand in standing water when working around
electrical appliances.
• Make sure the surfaces you touch are not hot or frozen.
• Do not touch a bare circuit board unless you are
wearing an anti-static wriststrap that is grounded to an
electrical ground or grounded water pipe.
• Handle circuit boards carefully and avoid touching
components.
To measure the start winding resistance, measure across the C and S
pins.
To measure the run winding resistance, measure across the C and R
pins.
Also check S to R and you should get the sum of the run and start
windings.
To ensure the windings are not shorted, check the S and R to ground
OVERLOAD PROTECTOR
STARTING RELAY
RELAY COVER
Figure 29. CO2175F/2175RF/CO2175DWR
C
S R
CAPACITOR
ULIN_0368_A
Section 3 - Service and Repair
Voltage
Frequency
LRA
FLA
Start Winding
Run Winding
Capacitor
WARNING
Do not cycle ice maker by hand. This will cause damage
to the ice maker.
Part
Ice Maker Heater-110V
Ice Maker Heater-220V
Mullion Heater
Pan Heater
Bypass coil
120V water valve
220V water valve
ICE MAKER LIMIT SWITCH
Figure 30. Ice Maker Limit Switch-Normally Closed
EMU45HSC EMY70HER
5408 70081
115.0 115-127
60.0 60.0
6.5 26.5
1.5 2.7
5.6 8.1
6.7 3.2
15uF N/A
Resistance
80
320
1600
6350
300
335
1900
3.00
28.12
ULIN-0351_A
3-45