ELECTRICAL HAZARD • Battery can fall out and injure a child if vehicle tips over. Always use battery clamp. • PREVENT FIRE - Do not bypass a Power Wheels - Use only a Power Wheels - Never modify the electrical system. Alterations could cause a fire resulting in serious injury and could also ruin the electrical system.
• If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather than return this product to the store. • Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded.
Page 5
Parts Key Assembly Microphone 6 Volt Charger 25 amp Fuse - 1* Radio Dial Shifter 6 Volt Battery Steering Wheel Cap Gas Cap Assembly Traction Band - 4 Radio Knob - 2 Not Shown: Label Sheet *For your convenience, an extra 25 amp fuse has been included. #8 x 1"...
Note: Some parts shown are assembled on both sides of the vehicle. Vehicle Body Steering Column Grille Sport Bar Sport Bar Cover Set Taillight Lens - 2 Taillight Housing - 2 Headlight Lens - 2 Steering Wheel Cap Spark Plug Wires Traction Band - 4 Type H 6 Volt Charger Gas Cap Assembly...
ELECTRICAL HAZARD WARNING • Battery can fall out and injure a child if vehicle tips over. Always use battery clamp. • PREVENT FIRE - Do not bypass a Power Wheels It is a safety device. - Use only a Power Wheels - Never modify the electrical system.
Page 8
25 Amp Fuse GOOD FUSE "BLOWN" FUSE • If you are charging the battery for the first time, insert a 25 amp fuse into the battery. Note: The top of the fuse will not be flush with the top of the battery when properly installed.
WARNING Children can be harmed by small parts, sharp edges and sharp points in the vehi- cle’s unassembled state, or by electrical items. Care should be taken in unpacking and assembly of the vehicle. Children should not handle parts, including the battery, or help in assembly of the vehicle.
Page 10
Steering Wheel • Fit the steering wheel cap into the center of the steering wheel with the screw holes aligned. • Insert two #8 x 1" screws through the holes in the steering wheel cap and into the steering wheel. •...
Page 11
Microphone Plastic • Bend the plastic tip at the end of the microphone cord to form a “T”. • Insert the plastic tip into the small hole in the left side of the vehicle body. Pull gently on the cord to make sure it is secure.
Page 12
Grille • Lift the hood. • Fit the tabs at the bottom of the grille into the slots in the vehicle body. • Press near the top of the grille to snap it into the vehicle body. • Lower the hood. Grille •...
Page 13
Seat Hole • With the sport bar positioned to angle towards the rear of the vehicle, fit the ends of the sport bar into the holes in the vehicle body on either side of the seat. • Press firmly on each side of the sport bar to fit it into the vehicle body.
Page 14
Ridge Wheel Bottom View • Turn the vehicle on its side. • Fit a traction band around a wheel. • Slide a slotted screwdriver under the traction band to push the traction band onto the ridge in the center of the wheel.
Proper label application will help to keep the labels looking their best! Keep the following guidelines in mind when applying labels: • Wash your hands before applying the labels. • Before applying the labels, wipe the surface of the vehicle with a clean, dry cloth to remove any dust or oils. •...
Battery Installation and Battery Clamp IMPORTANT! Use only a Power Wheels tery with a Power Wheels 25 Amp fuse installed. Use ® of any other battery or fuse will damage your vehicle. Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels ®...
Care If a battery leak develops, avoid contact with the leaking acid and place the damaged battery in a plastic bag. See information below for proper disposal. If acid comes in contact with skin or eyes, flush with cool water for at least 15 minutes and call a physician. If acid is internally ingested, give water, milk of magnesia or egg whites immediately.
RIDING HAZARD WARNING Prevent Injuries and Deaths • Direct Adult Supervision Required • Keep Children Within Safe Riding Areas These areas must be: - away from swimming pools and other bodies of water to prevent drownings - generally level to prevent tipovers - away from steps, driveways, roads and alleys.
How to Operate Your Vehicle To Drive • Push the top button (FWD) on the FORWARD/REVERSE switch to drive forward • Press down on the foot pedal forward at a maximum of 2 • Help your child practice steering to learn how far and how quickly to turn the steering wheel when driving forward.
Problems and Solutions Guide IMPORTANT! If you experience a problem with your vehicle, first check the Problems and Solutions Guide below. If you still experience a problem, please contact Power Wheels toll-free at 1-800-348-0751 between 8 AM and 6 PM (EST) Monday through Friday. Or, contact your local Power Wheels Authorized Service Center list beginning on page 25.
Page 21
Problems and Solutions Guide Problem Vehicle was running but Loose wire or loose connectors suddenly stopped Wrong type or improperly installed fuse Blown fuse Vehicle is overloaded Driving conditions are too stressful Short run time Undercharged battery Overcharged battery Battery is old and will not accept full charge Wrong type or improperly installed fuse Driving conditions are too stressful...
Page 22
Problems and Solutions Guide Problem Vehicle runs sluggishly Undercharged battery Battery needs charging Wrong type or improperly installed fuse Battery is old and will not accept full charge Vehicle is overloaded Driving conditions are too stressful Sometimes the vehicle doesn’t Loose wire or loose connectors run but other times it does Motor or electrical switch damage...
Page 23
Problems and Solutions Guide Problem Vehicle constantly blows fuses Wrong type of fuse used Child is switching between FORWARD and REVERSE without stopping. Loud clacking or grinding Broken gears noise from a motor-gearbox Charger gets warm during use It is normal for some chargers to get warm during use and is not reason for concern.
Bumper-to-Bumper* Limited Warranty *One year limited warranty from the date of purchase on the Power Wheels limited warranty on 6 volt battery. For the original purchaser, this one year limited warranty covers the Power Wheels Wheels ® ) against defects in materials and work-manship. The six month limited warranty applies only to the 6 volt battery included by Power Wheels ®...
We are continually expanding our Authorized Service Center Network. Please check this listing for the Authorized Service Center nearest you. If there is not one in your area, please call Power Wheels ® Consumer Relations at 1-800-348-0751. ALABAMA BIRMINGHAM - Frigid Service & Sales, 701 Graymont Ave.
Page 26
SPRING HILL - National Floor Care, 5588 Commercial Way, 34606, (352) 686-6711, (800) 245-1946 ST. PETERSBURG - Keystone Electric, 4604 Central Avenue, 33711, (813) 321-1124 STUART - Appliance Doctors, 3166 S.E. Dixie Highway, 34997, (561) 287-6437 SUNRISE - Muller Appliance Service, 2116 North University Drive, 33322, (954) 749-5460 VERO BEACH - Hoppe’s Authorized Vacuum and Appliance, 1872 Commerce Avenue, 32960,...
Page 28
MONTICELLO - Wayne’s Small Engine, 79 St. John Street, 12701, (914) 796-1851 OCEANSIDE - Turnpike Appliance Service, 3495A Lawson Boulevard , 11572, (516) 486-5700 POUGHKEEPSIE - S & S Appliance Sales & Service, 390 Violet Avenue, 12601, (914) 452-6122 RICHMOND HILL - Lockdoctor Locksmiths, 104-37 Atlantic Ave., 11418 (718) 441-6242 ROCHESTER - Benfante Appliance Service, 1286 Mt.
Page 29
WINNER - Nelson’s Electronics Inc., 422 West 2nd Street P.O. Box 369, 57580, (605) 842-1611, (888) 842-1699 TENNESSEE CHATTANOOGA - Consumer Service Company, 2607 E. 47th Street, 37407, (423) 867-8629 DANDRIDGE- Save More Sales, 1291 W Hwy 25-70, 37725, (865) 397-1255 KNOXVILLE - Appliance &...
Page 32
Over 400 Authorized Service Centers Fisher-Price and Power Wheels by Fisher-Price are U.S. trademarks of Mattel, Inc. Fisher-Price, Inc., a subsidiary of Mattel, Inc., East Aurora, New York 14052 U.S.A. Printed in the U.S.A. If you are missing parts or need assistance, Power Wheels 8 AM - 6 PM EST, Monday through Friday.