5.5 hp 17 inch tine width rear tine with counter rotating tines (37 pages)
Summary of Contents for Craftsman 536.292523
Page 1
Aspas de 10 pulg. Modelo 536.292523 PRECAUCI6N: Antes de usar este producto, lea este manual y siga todas las reglas de seguridad e instrucciones de operaci6n. Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A. www.sears.com/craftsman F-021300C Made in China...
Page 2
ON CRAFTSMAN CULTIVATOR For one year from the date of purchase, when this Craftsman Cultivator is maintained, lubri- cated, and tuned up according to the operating and maintenance instructions in the owner's manual, Sears will repair, free of charge, any defect in material or workmanship.
Page 3
IMPORTANT Safe Operation Practices for Cultivator WARNING: Look for this symbol to point out important safety precautions. It means: "Attention! Become Alert! Your Safety Is Involved." • Never store fuel or cultivator with fuel in the tank inside a building where fumes may tal starting when setting-up, ARNING: To prevent acciden-...
Page 4
IMPORTANT • Take all possible precautions when leaving and keep the wire away from the plug to the cultivator unattended. Stop the engine, prevent accidental starting. Thoroughly spect the cultivator for any damage, and • Do not overload the cultivator capacity by repair the damage before restarting and attempting to till too deep at too fast a rate.
Page 5
IMPORTANT INTERNATIONAL SYMBOLS IMPORTANT: Many of the following symbols are located on your unit or on literature sup- plied with the product. Before you operate the unit, learn and understand the purpose for each symbol. Control And Operating Symbols Slow Fast Fuel Half Choke...
Page 6
ASSEMBLY ASSEMBLY PARTS PACKED SEPARATELY IN CARTON 1 - Owner's Manual (not shown) 1 - 5.2 oz. 2-cycle 1 - 5.2 oz. 2-cycle glasses or eye shields while as- WARNING: Always wear safety sembling the cultivator. Figure 1 shows the cultivator completely as- sembled.
Page 7
ASSEMBLY v" CHECKLIST For the best performance and satisfaction from this quality product, please review the following checklist before you operate the cultivator: All assembly instructions have been completed. Check carton. Make sure no loose parts remain in the carton. All fasteners have been properly tight- ened.
Page 8
OPERATION KNOW YOUR CULTIVATOR READ THE OWNER'S MANUAL AND ALL SAFETY RULES BEFORE YOU OPERATE the cultivator. To familiarize yourself with the location of the controls, compare the illustrations with _our cultivator. Save this manual for future reference. Recoil Starter Handle ON / OFF Switch Throttle Control...
Page 9
OPERATION HOW TO USE THE CULTIVATOR How To Stop The Cultivator 1. Release the throttle control to stop the tines. Depth Stake Move the ON/OFF switch, on the engine, to the OFF position. Clevis Pin How To Set The Depth Use the depth stake to control the tilling depth and the forward speed.
Page 10
OPERATION BEFORE STARTING THE ENGINE IMPORTANT: Do not use outboard mo- How To Prepare The Engine tor oil or multi-viscosity oils,such as ARNING: Always use a safety 10W-30 or 10W-40. fuel container. Do not smoke when adding the fuel mixture to Install the fuel cap onto the gasoline con- the engine.
Page 11
OPERATION HOW TO START THE ENGINE Before you start the engine, make sure that Pull the starter handle with rapid, full arm you have read and understand all the in- strokes until the engine starts. structions on the preceding pages. When the engine starts, move the choke lever to the HALF CHOKE position.
Page 12
OPERATION CULTIVATING TIPS If the cultivator stops forward motion and Tilling is digging in, turning over and breaking up packed soil before planting. tries to dig deeper than necessary, move the handles from side to side to start for- Loose unpacked soil helps root growth. ward motion.
Page 13
MAINTENANCE CUSTOMER RESPONSIBILITIES SERVICERECORDS After Fillin datesas you Every Every Before First Before completeregular Each Before Each SERVICE service. Hours Hours Hours Storage Season DATES Lubricate Tine Shaft Check Spark Plug Clean Cylinder Exhaust Ports PRODUCT SPECIFICATIONS GENERAL RECOMMENDATIONS Model No.: 536.292523 The warranty on this cultivator does not cov- er items that have been subjected to opera-...
Page 14
MAINTENANCE LUBRICATION Every 25 hours and/or at the beginning of if it is damaged (see the Repair Parts each season, make sure the gear box is section in this manual). filled with lubricant (see Figure 6). Tubes of Clean and lubricate the fine shaft with a gear lubricant are available from most auto- few drops of oil.
Page 15
MAINTENANCE SPARK PLUG Before installing the spark plug, coat the threads lightly with oil for easy re- moval. Tighten the spark plug to a torque Check the spark plug every 25 hours. Re- of 15 foot-pounds. place the spark plug if the electrodes are pitted or burned or if the porcelain is cracked.
Page 16
SERVICE AND ADJUSTMENT HOW TO REMOVE AND INSTALL THE TINES Tine Installation References to the right or left side of the cul- tivator are from the viewpoint of the opera- Clean and lubricate the tine shaft with a tor's position behind the unit. few drops of oil.
Page 17
SERVICE AND ADJUSTMENT HOW TO ADJUST THE CARBURETOR A dirty air cleaner will cause the engine to Turn the mixture adjusting screw clock- run improperly or to smoke excessively. Be- wise until it is halfway between the first fore adjusting the carburetor, make sure the position and the second position.
Page 18
SERVICE AND ADJUSTMENT STORAGE • Cover the cultivator with a suitable pro- tective cover that does not retain mois- tivator indoors with fuel in the WARNING: Never store the cul- fuel tank. Never store in an en- ture. Do not use plastic. closed, poorly ventilated area where IMPORTANT: Never cover the cultivator fumes could reach an open flame, a...
Page 19
TROUBLE SHOOTING CHART TROUBLE CAUSE CORRECTION Stale fuel mixture Drain fuel tank. Fill with fresh Engine difficult to start fuel mixture. Too much oil in fuel mixture Check fuel mixture chart and mix fresh fuel. Dirt in fuel tank or out of fuel Clean fuel tank.
Page 25
CRAFTSMAN 143.002072 REPAIR PARTS 275 * F-021300C...
Page 26
CRAFTSMAN 143.002072 REPAIR PARTS PART PART DESCRIPTION DESCRIPTION RPM High 5000 to 5400 650849 Flywheel Nut RPM Low 1700 to 3000 611056 Solid State Ignition (Incl. 101) 250303 Cylinder (Incl. 119, 184, Spark Plug Cover 187 & 187A) 610118 650888...
Page 27
CRAFTSMAN 143.002072 REPAIR PARTS 450253 Air Cleaner Cover 410280 Fuel Cap 650867 Screw, 10-24 x 1/2" 570659 Blower Housing Plug 610650B Toggle Switch 350435 Blower Housing Base 370C 550239 Choke Decal 650850 Screw, 8-32 x 1-9/16" 650939 Stud 370D 35977...
Page 28
CRAFTSMAN 143.002072 REPAIR PARTS F-021300C...
Page 29
CRAFTSMAN 143.002072 REPAIR PARTS PART DESCRIPTION 640231 Carburetor (Incl. 184 of Engine Parts List) 640232 Throttle Shaft & Lever Ass'y. 640233 Throttle Return Spring 640234 Dust Seal Retainer 640236 Spacer 640237 Dust Seal Washer 640238 Dust Seal 640239 Throttle Shutter 640235 Screw, Throttle Shutter &...
Page 30
CRAFTSMAN 143.002072 REPAIR PARTS PART DESCRIPTION 590690 Rewind Starter & Housing Ass'y. 650987 Retainer Screw, 10-24 x 1-3/8" 650985 Pawl Screw, 12-24 x 11/64" 650147 Washer 590691 Pawl Spring 590692 Pawl 590693 Pulley 590562 Rewind Spring 590639 Starter Rope (#4 rope, 71" long)
Page 31
DE UN AI_IO PARA LA CULTIVADORA CRAFTSMAN Esta cultivadora Craftsman esta garantizada por un aho a partir de la fecha de compra, siem- prey cuando se le haya dado mantenimiento, lubricado y aflnado de acuerdo con las instruc- clones de operaci6n y mantenimiento que aparecen en el manual del usuario, Sears repara- ra, sin costo alguno, cualquier defecto en el material y/o mano de obra de la unidad.
Page 32
IMPORTANTE Prdcticas para la operacibn segura de la cultivadora. de precaucibn para su seguridad. Este simbolo quiere decir: "iAtencibn! ADVERTENCIA: Busque este simbolo que le indicard puntos importantes iEst_ alerta! Preste atencibn a su seguridad". dado. Nunca I0 Ilene en un espacio cerra- do.
Page 33
IMPORTANTE • Nunca permita que haya personas cerca • Mantenga la cultivadora en condiciones de de la cultivadora en marcha, funcionamiento seguras. Revise con regu- laridad todos los sujetadores para mante- • Mantenga alejados a nifios y mascotas du- nerlos debidamente apretados.
Page 34
IMPORTANTE SJMBOLOS INTERNACIONALES IMPORTANTE: La mayoria de los simbolos siguientes se encuentran en la unidad o en la informacibn que viene con el producto. Antes de usar la unidad, familiaricese con el signifi- cado de cada uno de los simbolos. Simbolos de control y funcionamiento Combustible Aceite...
Page 35
MONTAJE MONTAJE MATERIALES INCLUIDOS EN LA CAJA 1 - Manual del usuario (no aparece en la figura) 1 - Aceite de 2 tiempos 5,2 onzas. 1- Botella de aceite, 2 tiempos 5,2 onzas gafas de seguridad durante el ADVERTENCIA: Siempre use montaje de la cultivadora.
Page 36
MONTAJE v" LISTA DE COMPROBACI6N Para obtener un rendimiento 6ptimo y la ma- yor satisfacci6n de este producto de alta ca- lidad, favor de revisar la siguiente lista de comprobaci6n antes de hacer funcionar su cultivadora: Se han completado todas las instruc- ciones de montaje, Se ha revisado la caja de envio para asegurar que no quede en 6sta ningu-...
Page 37
OPERACION CONOZCA SU CULTIVADORA ANTES DE HACER FUNCIONAR LA CULTIVADORA, LEA EL MANUAL DEL USUARIO Y TODA LA INFORMACI6N SOBRE SEGURIDAD. Para familiarizarse con la ubicaci6n de los controles, compare las siguientes ilustraciones con su cultivadora. Guarde este manual para referencias futuras.
Page 38
OPERACION C6MO USAR LA CULTIVADORA Cbmo detener la cultivadora 1. Suelte el control del acelerador para de- tener la rotaci6n de los dientes. Barra de Mueva el interruptor de ENCENDIDO / APAGADO (ON/OFF), ubicado en el mo- tor, a la posici6n APAGADO (OFF).
Page 39
OPERACION ANTES DE HACER ARRANCAR EL MOTOR Cbmo preparar el motor ASada al contenedor de gasolina 5,3 on- zas de aceite para motor de dos tiempos asegurandose que el aceite est6 limpio y recipiente de seguridad para el ADVERTENCIA: Use siempre un que sea de buena calidad.
Page 40
OPERACION C6MO ARRANCAR EL MOTOR Antes de arrancar el motor, aseg_rese de Una vez que el motor arranque, mueva el control de cebado a la posici6n de haber leido y entendido todas las instruccio- nes de las paginas anteriores. CEBADO MEDIO (HALF CHOKE). Cuando el motor est6 corriendo de ma- 1.
Page 41
OPERACION CONSEJOS PARA CULTIVAR Arar es cavar, revolver y aflojar la tierra mas rapido y que cave a menor profun- didad. compactada antes de cultivar. La tierra suelta facilita el crecimiento de las ra[- Si la cultivadora deja de avanzar y trata ces.
Page 42
MANTENIMIENTO RESPONSABILIDADES DEL USUARIO REGISTRO DE Despu_s Antes SERVIClO Antes de las FECHAS Anotelasfechas primeras Cada Cada Antes cada medidaque complete cada 2 horas tempo- SERVI- cadaservicio, de uso horas horas guardar rada Lubricar el eje de los dientes Revisar la bujia Limpiar los puertos de salida del cilindro ESPECIFICACIONES D ELPRODUCTO...
Page 43
MANTENIMIENTO LUBRICACI6N Revise la arandela de fieltro (vea la Figura 6). Si la arandela de fleltro esta Despu6s de cada 25 horas de uso y/o a prin- daSada, reemplacela (consulte la sec- cipios de cada temporada, aseg6rese de ci6n sobre piezas de repuesto en este que la caja de engranajes contenga lubrican- manual).
Page 44
MANTENIMIENTO BUJIA Antes de instalar la bujia, aplique una capa ligera de aceite a la parte roscada para facilitar su remoci6n. Apriete la bu- Revise la bujia despu6s de cada 25 horas de uso. Debe reemplazar la bujia si los elec- jia hasta Iograr un par de apriete de 15 trodos se encuentran daSados o quemados, libras-pie.
Page 45
SERVICIO Y AJUSTES C6MO DESMONTAR E INSTALAR LOS DIENTES Instalacibn de los dientes Cuando se indica el lado izquierdo o dere- cho de la cultivadora en este manual, siem- Limpie y lubrique el eje de los dientes pre se refiere al punto de vista del operador con unas gotas de aceite.
Page 46
SERVICIO Y AJUSTES C6MO AJUSTAR EL CARBURADOR Un filtro de aire tapado impedira el buen fun- Gire el tornillo de ajuste de la mezcla ha- cionamiento del motor o provocara la gene- cia la derecha hasta que se encuentre raci6n excesiva de humo. Aseg6rese de que entre las dos posiciones anotadas.
Page 47
SERVICIO Y AJUSTES ALMACENAMIENTO • Proteja la cultivadora con una cubierta la cultivadora con combustible apropiada que no retenga humedad. No ADVERTENCIA: Nunca guarde use cubiertas de plastico. en el tanque en un recinto ce- rrado. Nunca la guarde en un _rea cerra- IMPORTANTE: Nunca cubra la cultivadora da y con poca ventilacibn,...
Page 48
TABLA DE LOCALIZACION DE AVERiAS PROBLEMA CAUSA SOLUCI6N El motor arranca con Combustible viejo Vacie el tanque de combustible. LI6nelo con dificultad combustible fresco. Demasiado aceite en la Revise la tabla de mezcla de mezcla de combustible combustible y mezcle mas combustible fresco.
Page 52
For repair of major brand appliances in your own home... no matter who made it, no matter who sold it! 1-800-4-MY-HOM Es"IAnyt.m_ day o, night (1-800-469-4663) www,sears.corn To bring in products such as vacuums, lawn equipment and electronics for repair, call for the location of your nearest Sears Parts &...