Advertisement
Advertisement
Table of Contents
Related Manuals for Vulcan-Hart Econoline 160L77R
Summary of Contents for Vulcan-Hart Econoline 160L77R
- Page 1 SERVICE AND PARTS MANUAL FOR ECONOLINE SERIES GAS RESTAURANT RANGES MODELS: 36L77R, 36FL77R, 60L77R, 60FL77R, 160L77R, 260L77R V U L C A N - H A R T C O M P A N Y , P . O . B O X 6 9 6 , L O U I S V I L L E , K Y 4 0 2 0 1 - 0 6 9 6 , TEL. (502) 7 7 8 - 2 7 9 1 FORM 30753 (10-91)
-
Page 2: Important For Your Safety
ECONOLINE SERVICE AND PARTS IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL GAS EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. POST IN A PROMINENT LOCATION THE INSTRUCTIONS TO BE FOLLOWED IN THE EVENT THE SMELL OF GAS IS DETECTED. - Page 3 ECONOLINE SERVICE AND PARTS SERVICE AND PARTS MANUAL ECONOLINE SERIES GAS RESTAURANT RANGE - INDEX PLEASE KEEP THIS MANUAL FOR FUTURE REFERENCE Your Vulcan Econoline Range is produced with quality The manufacturer suggests that you thoroughly read workmanship and material. Proper installation, usage this entire manual and carefully follow all of the and maintenance of your range will result in many instructions provided.
-
Page 4: Lighting And Shutting Down Pilots
LIGHTING AND SHUTTING DOWN PILOTS BE VERY CAREFUL WHEN OPERATING, CLEANING OR SERVICING THE RANGE. NOTE: All adjustment procedures associated with pilot lighting must be performed by a qualified Vulcan-Hart installation or service person. CONTROLS (FIG. 1) Oven Pilot Thermostat Dial — allows operator to regulate oven 1. -
Page 5: Pilot Adjustments
ECONOLINE SERVICE AND PARTS Open Top Pilots PILOT ADJUSTMENTS 1. Remove all top section cover plates and griddles. Burner Adjustment 2. Turn main gas supply ON (all burner valve knobs The effiency of the range depends on a rather delicate should be in OFF position). - Page 6 ECONOLINE SERVICE AND PARTS Pilot Burner Adjustment (Grayson Safety Valve Shown) 2. Adjust pilot key to provide properly sized flame. 1. Remove pilot adjusting cap. 3. Replace pilot adjusting cap. Fig. 3 Fig. 4 – 6 –...
- Page 7 ECONOLINE SERVICE AND PARTS THERMOSTAT (BJWA) 2. After 5 minutes, turn dial clockwise to a point slightly beyond first mark on dial (shown by "X"). To Adjust By-Pass Flame (Minimum Burner Flame): 3. Remove dial and sleeve. When oven reaches the temperature at which the dial 4.
-
Page 8: Oven Control Recalibration
ECONOLINE SERVICE AND PARTS OVEN CONTROL RECALIBRATION To check oven temperature when recalibrating, use an NOTE: Do not recalibrate oven control until the by-pass appropriate test instrument or thermometer. flame has been adjusted. BJWA Recalibration The oven is a precision instrument. It is carefully cali- brated at the factory so that the dial settings match the 1. -
Page 9: Orifice Data
ECONOLINE SERVICE AND PARTS ORIFICE DATA OPEN TOP GRIDDLE BROILER OVEN GRIDDLE INPUT AT SEA LEVEL 15,000 15,000 10,000 35,000 PER BURNER (BTU'S) GAS TYPE NAT/PROP NAT/PROP NAT/PROP NAT/PROP SEA LEVEL 48/57 48/57 54/62 34/51 2000 FT. 2000 FT. 49/57 49/58 56/65 38/52... -
Page 10: Troubleshooting
ECONOLINE SERVICE AND PARTS TROUBLESHOOTING OVEN PROBLEM PROBABLE CAUSES Too much bottom heat. 1. Insufficient heat input. 2. Overactive flue. Uneven bake. 1. Too low temperture. 2. Improper operation. Side burning. 1. Improper bypass setting. 2. Fluctuating gas pressure. Too much top heat. 1. -
Page 11: Replacement Parts List
ALL SERVICE PERSONNEL WHEN SERVICING THE EQUIPMENT, USE ONLY CONTROLS ORIGINALLY SUPPIED ON THIS EQUIPMENT BY VULCAN-HART COMPANY. DO NOT SUBSTITUTE. SUBSTITUTION OF CONTROLS AS STATED ABOVE WILL AUTOMATICALLY VOID THIS WARRANTY AND THE CERTIFICATION ASSOCIATED WITH THIS EQUIPMENT. - Page 12 ECONOLINE SERVICE AND PARTS PART NO. ITEM NO. DESCRIPTION 36L77R 60L77R 160L77R 260L77R PILOT BRACKET 413302-1 413302-1 413302-1 413302-1 REAR BURNER ASSEMBLY (NAT) 409643-G7 409643-G7 409643-G7 409643-G7 REAR BURNER ASSEMBLY (PROPANE) 409643-G8 409643-G8 409643-G8 409643-G8 FRONT BURNER ASSEMBLY (NAT) 409644-G7 409644-G7 409644-G7 409644-G7...
- Page 13 ECONOLINE SERVICE AND PARTS PART NO. ITEM NO. DESCRIPTION 36L77R 60L77R 160L77R 260L77R BURNER VALVE HANDLE 413157-1 413157-1 LIGHTER VALVE 404193-2 404193-2 BROILER BURNER VALVE (NAT) 404076-F50 404076-F50 BROILER BURNER VALVE (PROPANE) 404076-F57 404076-F57 BURNER 411684-G1 411684-G1 SIDE CERAMICS 404146-1 404146-1 CENTER CERAMICS 404145-1...
- Page 14 ECONOLINE SERVICE AND PARTS PART NO. ITEM NO. DESCRIPTION 36L77R 60L77R 160L77R 260L77R BRICK SET 407065-G1 407065-G1 407065-G1 PILOT VALVE (NS) 404193-2 404193-2 404193-2 THERMO. BULB - SHIELD (NS) 411655-2 411655-2 411655-2 THERMO. BULB - INSULATION (NS) 411656-1 411656-1 411656-1 THERMO.
- Page 15 ECONOLINE SERVICE AND PARTS ITEM NO. DESCRIPTION PARTS NO. 36L77R 60L77R 160L77R 260L77R RIGHT DOOR POST HANDLE 413416-1 LEFT DOOR POST HANDLE 413416-2 BELL CRANK PIN RS32-89 BELL CRANK 403956-1 COTTER PIN 413201-1 TURNBUCKLE & HOOKS 417865-1 OVEN DOOR SPRING 404053-1 OVEN DOOR SPRING (NS) 413342-1...
- Page 16 ECONOLINE SERVICE AND PARTS PART NO. ITEM NO. DESCRIPTION 36L77R 60L77R 160L77R 260L77R PILOT (NATURAL) 412787-1 412787-1 412787-1 412787-1 PILOT (PROPANE) 412787-2 412787-2 412787-2 412787-2 THERMOCOUPLE T46 412788-1 412788-1 412788-1 412788-1 SECONDARY AIR PIN 413165-3 413165-3 413165-3 413165-3 OVEN BURNER ASSEMBLY 413225-G1 413225-G1 413225-G1...
- Page 17 ECONOLINE SERVICE AND PARTS PART NO. ITEM NO. DESCRIPTION 36L77R 60L77R 160L77R 260L77R BELL CRANK 403956-1 403956-1 403956-1 403956-1 TURNBUCKLE & HOOKS 417865-1 417865-1 417865-1 417865-1 OVEN DOOR SPRING 404053-1 404053-1 404053-1 404053-1 SAFETY VALVE 405569-2 405569-2 405569-2 405569-2 NOZZLE (OVEN BURNER) 404079-F 404079-F 404079-F...
- Page 18 ECONOLINE SERVICE AND PARTS PART NO. ITEM NO. DESCRIPTION 36L77R 60L77R 160L77R 260L77R SPLASHER BACK ASSEMBLY 413223-G1 413223-G3 413223-G3 413223-G5 SPLASHER BACK ASSEMBLY (SS) 413223-G2 413223-G4 413223-G4 413223-G6 SHELF ASSEMBLY 411841-G3 411841-G1 411841-G1 411841-G1 SHELF ASSEMBLY (SS) 411841-G4 411841-G2 411841-G2 411841-G2 LOWER PANEL ASSEMBLY (SS) 413172-G2...
- Page 19 THIS PAGE INTENTIONALLY LEFT BLANK...
- Page 20 THIS PAGE INTENTIONALLY LEFT BLANK...