Sign in today to find solutions:

Don't have an account? Sign up

Sony FT1H - SA 5.1-CH Home Theater Speaker Sys Service Manual

Service manual.

 
SERVICE MANUAL
Ver. 1.0 2006.04
• SA-FT1H is composed of following models.
COMPONENT MODEL NAME
FRONT/SURROUND SPEAKER
CENTER SPEAKER
SUBWOOFER
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL HARMONIC DISTORTION:
With 6 ohm loads, from 45 – 180 Hz; rated 120 watts per
channel minimum RMS power, with no more than 10% total
harmonic distortion from 250 milliwatts to rated output.
SS-MSPFT1 (front speakers)
Speaker system
2 way, magnetically
shielded
Speaker units
Woofer: 8 cm, cone type
Tweeter: 2.5 cm, balanced
dome type
Enclosure type
Bass reflex
Rated impedance
8 ohms
Power handling capacity
Maximum input power:
110 W
Sensitivity level
84 dB (1 W, 1 m)
Frequency range
140 Hz - 50,000 Hz
Dimensions (w/h/d)
Approx. 108 × 215 × 44 mm
with table top stand
Approx. 108 × 224 × 44 mm
(Diameter of base:
150 mm)
Mass
Approx. 0.5 kg
with table top stand
Approx. 0.6 kg
Sony Corporation
9-887-229-01
Home Audio Division
2006D04-1
Published by Sony Techno Create Corporation
© 2006.04
SS-CNPFT1/MSPFT1/SRPFT1
SA-WPFT1
SS-MSPFT1
SS-SRPFT1
SS-MSPFT1/SRPFT1
SS-CNPFT1
SA-WPFT1
SPECIFICATIONS
SS-SRPFT1 (surround speakers)
Speaker system
Speaker units
Enclosure type
Rated impedance
Power handling capacity
Maximum input power:
Sensitivity level
Frequency range
Dimensions (w/h/d)
Mass
HOME THEATRE SPEAKER SYSTEM
SA-FT1H/WPFT1/
Canadian Model
SS-CNPFT1
1 way, magnetically
shielded
Full range: 8 cm, cone type
Bass reflex
8 ohms
110 W
84 dB (1 W, 1 m)
140 Hz - 20,000 Hz
Approx. 108 × 215 × 44 mm
with table top stand
Approx. 108 × 224 × 44 mm
(Diameter of base:
153 mm)
Approx. 0.45 kg
with table top stand
Approx. 0.55 kg
US Model
– Continued on next page –

Summary of Contents

  • Page 1

    Approx. 108 × 224 × 44 mm (Diameter of base: 150 mm) Mass Approx. 0.5 kg with table top stand Approx. 0.6 kg HOME THEATRE SPEAKER SYSTEM Sony Corporation 9-887-229-01 Home Audio Division 2006D04-1 Published by Sony Techno Create Corporation © 2006.04...

  • Page 2

    LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.

  • Page 3: Table Of Contents

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 TABLE OF CONTENTS DISASSEMBLY 1-1. Back Panel Section ............5 1-2. AMP Section ..............5 1-3. Heat Sink Section ............6 1-4. Control/AC Board ............6 1-5. Main Board ..............7 DIAGRAMS 2-1. Block Diagram ..............9 2-2. Printed Wiring Boards –Main Section– ......10 2-3.

  • Page 4

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 SECTION 1 DISASSEMBLY • The equipment can be removed using the following procedure. 1-1. BACK PANEL SECTION (Page 5) 1-2. AMP SECTION (Page 5) 1-3. HEAT SINK SECTION 1-4. CONTROL/AC BOARD (Page 6) (Page 6) 1-5. MAIN BOARD (Page 7)

  • Page 5: Back Panel Section, Amp Section

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 Note: Follow the disassembly procedure in the numerical order given. 1-1. BACK PANEL SECTION 3 four screws (1) (3.5 × 16), tapping 6 CNP102 (4P) 2 three screws (+BVTP 3 × 8) 1 screw (+BVTP 3 × 8) 4 four screws (1) (3.5 ×...

  • Page 6: Heat Sink Section, Control/ac Board

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 1-3. HEAT SINK SECTION 4 heat sink section 3 three screws (+BVTT 4 × 8) 2 CNP711 (5P) 1 CNP701 (3P) 1-4. CONTROL/AC BOARD 4 three screws (+BVTP 3 × 8) 1 CNP103 (8P) 3 CNP904 (3P) 5 CONTROL/AC board 2 CNP902 (3P)

  • Page 7: Main Board

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 1-5. MAIN BOARD 4 MAIN board 2 three screws (+BVTP 3 × 8) 1 CNP401 (6P) 3 two screws (+BVTP 3 × 8)

  • Page 8

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 SECTION 2 DIAGRAMS • Circuit Boards Location LED board POWER AMP board VOL board CONTROL/AC board MAIN board Note on Schematic Diagrams: Note on Printed Wiring Boards: • X : parts extracted from the component side. • All capacitors are in µF unless otherwise noted. (p: pF) 50 WV or less are not indicated except for electrolytics •...

  • Page 9: Block Diagram

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 2-1. BLOCK DIAGRAM RV101 LEVEL IC101 (2/2) IC101 (1/2) IC102 (2/2) IC102 (1/2) IC103 (2/2) IC103 (1/2) LINE J101 BASS POWER BUFFER LINE IN BOOST PHASE SP101 Q701–707 Q708–711 SPEAKER S102 +7.8V PHASE NORMAL CURRENT S103 SOURCE BASS BOOST Q603 BASS BOOST REVERSE...

  • Page 10: Printed Wiring Boards –main Section

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 2-2. PRINTED WIRING BOARDS — MAIN SECTION — • Refer to page 8 for Circuit Boards Location. : Uses unleaded solder. • Semiconductor Location Ref. No. Location D301 D302 D303 D304 D502 D503 D504 D505 D701 I-10 D702 I-10 D703 G-12 D704...

  • Page 11: Printed Wiring Boards –control Section

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 2-3. PRINTED WIRING BOARDS — CONTROL SECTION — • Refer to page 8 for Circuit Boards Location. : Uses unleaded solder. C602 C607 CNP901 C605 C630 C102 POWER (11) LEVEL IN POWER SAVE PHASE BASS BOOST MAIN BOARD AUTO REVERSE NORMAAL CNP904...

  • Page 12: Schematic Diagram –main Section

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 2-4. SCHEMATIC DIAGRAM — MAIN SECTION — Q102 RV101 R113 IC103(2/2) C116 IC103(1/2) R126 R121 C124 R123 C120 C104 IC102(1/2) CN101 C117 R109 IC101(2/2) R120 C102 C112 S103 C127 D101 R101 C122 J101 R104 R105 R117 C108 C109 C111 R115 R130 R106...

  • Page 13: Subwoofer Front Section (sa-wpft1)

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 SECTION 3 EXPLODED VIEWS NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by mark 0 or dotted line with mark. number in the exploded views are not supplied. Example : 0 are critical for safety.

  • Page 14: Subwoofer Amp Section (sa-wpft1)

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 3-2. SUBWOOFER AMP SECTION (SA-WPFT1) not supplied not supplied (POWER AMP board) Q708 Q709 not supplied not supplied not supplied F901 not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-1159-930-A MAIN BOARD, COMPLETE 0 F901 1-533-418-12 FUSE, GLASS CYLINDRICAL (DIA.

  • Page 15: Center Speaker Section (ss-cnpft1)

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 3-3. CENTER SPEAKER SECTION (SS-CNPFT1) not supplied SP202 not supplied supplied with 103 SP203 supplied with 104 SP201 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-1173-217-A OVERALL ASSY 2-670-948-01 STAND 2-670-947-01 GRILLE SP201 1-825-913-11 SPEAKER (2.5cm) 1-780-294-11 SCREW TERMINAL (T205) SP202 1-826-370-11 LOUD SPEAKER (3X12cm)

  • Page 16

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 3-4. FRONT/SURROUND SPEAKER SECTION (SS-MSPFT1/SRPFT1) not supplied SP301 (SS-MSPFT1) SP401 (SS-SRPFT1) not supplied supplied with 155 supplied with 156 SP302 (SS-MSPFT1) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-1173-065-A OVERALL ASSY (SS-MSPFT1) 2-670-786-01 BASE A-1173-731-A OVERALL ASSY (SS-SRPFT1) 4-977-358-01 CUSHION 2-670-783-01 GRILLE...

  • Page 17: Electrical Parts List

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 SECTION 4 CONTROL/AC ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by mark 0 or dotted line with mark. the parts list may be different from the they are seldom required for routine service.

  • Page 18

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 CONTROL/AC MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R106 1-249-429-11 CARBON 1/4W LED BOARD R108 1-247-863-11 CARBON 1/4W ********** R109 1-249-429-11 CARBON 1/4W R110 1-247-831-11 CARBON 1/4W < CAPACITOR > R111 1-247-871-11 CARBON 1/4W C609 1-127-888-11 CERAMIC...

  • Page 19

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 MAIN POWER AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < DIODE > R709 1-247-863-11 CARBON 1/4W R710 1-249-407-11 CARBON 1/4W F D301 6-500-522-11 DIODE 10EDB40-TA2B5 R711 1-249-393-11 CARBON 1/4W F D302 6-500-522-11 DIODE 10EDB40-TA2B5 R712 1-247-871-11 CARBON 1/4W...

  • Page 20

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 Ref. No. Part No. Description Remark MISCELLANEOUS *************** 0 54 1-783-820-11 CORD, POWER 1-780-294-11 SCREW TERMINAL (T205) 1-780-295-11 SCREW TERMINAL (T110) 1-780-294-11 SCREW TERMINAL (T205) 1-780-295-11 SCREW TERMINAL (T110) 0 F901 1-533-418-12 FUSE, GLASS CYLINDRICAL (DIA. 5) (2.5A/125V) Q708 6-702-391-01 TRANSISTOR MP1620-OPY-MK Q709 6-702-390-01 TRANSISTOR MN2488-OPY-MK...

  • Page 21

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 MEMO...

  • Page 22

    SA-FT1H/WPFT1/SS-CNPFT1/MSPFT1/SRPFT1 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 2006.04...

Comments to this Manuals

Symbols: 0

Latest comments:

×

Select the desired size and copy embed code

Copy your embed code and put on your site: