Section 10 − Parts List; Recommended Spare Parts - Miller Wildcat 200 Owner's Manual

Trouble
Battery Discharges between uses.
Engine idles but does not come up to
weld speed.
Unstable or sluggish engine speeds.
Engine does not return to idle speed.
During operation in near freezing tem-
peratures, engine starts and goes to idle
speed but stalls after a few minutes.
During operation in severe cold weather,
engine starts and goes to idle speed but
stalls after a few minutes.

10-1. Recommended Spare Parts

Dia.
Mkgs.
. . . . . . . . . . . . . . . . . . . . 237857
. . . . . . . VOLT REG . 241434
. . . . . . . . . . . . . . . . . . . . 240585
. . . . . . . . . . . . . . . . . . . . 240597
. . . . . . . . . . . . . . . . . . . . 241408
. . . . . . . . . . . . . . . . . . . . 240598
.
A complete Parts List is available on-line at www.MillerWelds.com.
Clean battery, terminals, and posts with baking soda and water solution; rinse with clear water.
Periodically recharge battery (approximately every 3 months).
Replace battery.
Check voltage regulator and connections according to engine manual.
Have Factory Authorized Service Agent check hour meter/idle module, and current transformer CT1.
Readjust throttle linkage if necessary. Check throttle solenoid TS1 for smooth operation.
Check oil level. Oil level should not exceed Full mark on dipstick. Fuel pump will operate erratically if
crankcase is overfilled.
Tune-up engine according to engine manual.
Remove weld and generator power loads.
Check throttle linkage for smooth, non-binding operation.
Have Factory Authorized Service Agent check hour meter/idle module, current transformer CT1, Engine
Control switch S1, and throttle solenoid TS1.
Treat fuel with isopropyl alcohol de-icer product.
Place Engine Control switch in the Run position until the unit has been in operation and under load for
a period of time.
Install engine manufacturer's kit for cold weather operation.
SECTION 10 − PARTS LIST
Part
No.
Recommended Spare Parts
. . Filter, Fuel In−line .250 (Subaru/Robin)
. . Regulator, Voltage (Subaru EX40)
. . Tune−up & Filter Kit, (Subaru/Robin) (Includes)
. . . . Air Filter Element
. . . . Filter, Fuel w/Clamps
. . . . Spark Plug
.
A complete Parts List is available at www.MillerWelds.com
Remedy
Description
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
OM-237 711 Page 39
Quantity
1
1
1
1
1
2