Table of Contents
Advertisement
Congratulations on your choice of a Vermont Castings Dauntless FlexBurn
$PHULFDQ FUDIWVPDQVKLS VHULRXVO\ :H DVVXUH \RX WKDW \RXU FDVWLURQ 9HUPRQW &DVWLQJV VWRYH KDV EHHQ PDGH ZLWK WKH XWPRVW
care and will provide you with many years of service.
$V \RX EHFRPH DFTXDLQWHG ZLWK \RXU QHZ VWRYH \RX ZLOO ¿QG WKDW LWV DSSHDUDQFH LV PDWFKHG E\ LWV IXQFWLRQDOLW\ GXH WR FDVW
iron's unique ability to absorb and radiate heat.
$OVR 9HUPRQW &DVWLQJV SURGXFWV DUH DPRQJ WKH FOHDQHVWEXUQLQJ ZRRG VWRYHV DYDLODEOH WRGD\ +RZHYHU FOHDQ EXUQLQJ
depends on both the manufacturer and the operator. Please read this manual carefully to understand how to properly operate
and maintain your stove.
At Vermont Castings, we are committed to your satisfaction as a customer. That is why we maintain an exclusive network of
WKH ¿QHVW GHDOHUV LQ WKH LQGXVWU\ 2XU GHDOHUV DUH FKRVHQ IRU WKHLU H[SHUWLVH DQG GHGLFDWLRQ WR FXVWRPHU VHUYLFH )HHO IUHH WR
contact your Authorized Vermont Castings Dealer anytime you have a particular question about your stove or its performance.
This manual contains valuable instructions on the operation of your Vermont Castings Dauntless FlexBurn
also contains useful information on maintenance. Please read the manual thoroughly and keep it as a reference.
This heater meets the U.S. Environmental Protection
Agency's emission limits for wood heaters sold on or after
May 15, 2020.
Please read this entire manual before you install and use
your new stove. Failure to follow instructions may result in
property damage, bodily injury, or even death.
Tested and Listed by Omni-Test Laboratories Inc.
Report #/Rapport #
0061WS104E, 0061WS104S
Tested to / Testé à:
ASTM E2515, ASTM E3053, UL 1482-2011 (R2015), ULC-S627-00,
CAN/CSA B415.1.
Install and use only in accordance with manufacturer's installation and operation
LQVWUXFWLRQV &RQWDFW ORFDO EXLOGLQJ RU ¿UH RI¿FLDOV DERXW UHVWULFWLRQV DQG LQVWDOODWLRQ
inspection in your area. Install only with legs provided in accordance with installation
instructions.
WARNING: 5LVN RI ÀDPH DQG VPRNH VSLOODJH 'R QRW REVWUXFW WKH VSDFH EHQHDWK WKH
heater.
Fuel: Use with solid wood fuel only. Do not burn other fuels.
%XLOG D ¿UH GLUHFWO\ RQ KHDUWK RQO\ 'R QRW HOHYDWH ¿UH .HHS GRRUV IXOO\ FORVHG RU IXOO\
open while operating.
Chimney: Use a minimum 6" diameter factory built high temperature (H.T.) chimney
which is listed to UL-103-1985 (2100°F) or 8" X 8" nominal or larger approved masonry
FKLPQH\ ZLWK ÀXH OLQHU
'R QRW FRQQHFW WKLV XQLW WR D FKLPQH\ ÀXH VHUYLQJ DQRWKHU DSSOLDQFH
Inspect and Clean Chimney Frequently – Under Certain Conditions of Use, Creosote
Buildup May Occur Rapidly.
Chimney Connector: Use a minimum 6" diameter 24 gauge chimney connector. Install
chimney connector at least 18" from ceiling. Refer to local building codes and Vermont
Castings Install Manual for precautions for passing a chimney or chimney connector
through a combustible wall or ceiling.
Floor Protection U.S.: 8VH D 7\SH 7KHUPDO 5 RU JUHDWHU RU D QRQFRPEXVWLEOH ÀRRU
protector such as 1/4" non-asbestos mineral board or equivalent or 24 gauge sheet metal. The
ÀRRU SURWHFWRU LV UHTXLUHG XQGHU WKH VWRYH DQG PXVW H[WHQG ´ IURP WKH IURQW ´ IURP WKH VLGHV
DQG UHDU OW PXVW H[WHQG XQGHU WKH FKLPQH\ FRQQHFWRU DQG ´ WR HLWKHU VLGH 7KH ÀRRU SURWHFWRU
may be covered with a noncombustible decorative material if desired.
Floor Protection Canada: :KHQ LQVWDOOHG RQ D FRPEXVWLEOH ÀRRU D QRQFRPEXVWLEOH ÀRRU
SURWHFWRU LV UHTXLUHG XQGHU WKH KHDWHU 7KH ÀRRU SURWHFWRU PXVW H[WHQG PP LQ WR WKH
front and 203 mm (8 in.) to the sides and rear.
Optional Components: )DQ .LW 3DUW 1R 9 +] )/$
Replace glass only with Vermont Castings 5mm ceramic glass.
Do not remove or cover this label. Catalytic Combustor Part No. 8346-006
CAUTION: %XUQLQJ RI PDWHULDOV RWKHU WKDQ WKH VSHFL¿HG IXHOV PD\ PDNH WKH &DWDO\VW LQ
the combustor inactive. The combustor is fragile, handle carefully. The durability of the
FDWDO\WLF GHYLFH KDV QRW EHHQ HYDOXDWHG DV SDUW RI WKH FHUWL¿FDWLRQ
Danger, Risk of electrical shock. Disconnect power before servicing unit.
US ENVIRONMENTAL PROTECTION AGENCY
&HUWL¿HG WR FRPSO\ ZLWK SDUWLFXODWH HPLVVLRQV VWDQGDUGV XVLQJ FRUG
wood at 1.1 g/hr (without catalyst) and 1.2 g/hr (catalytic). This wood
heater contains a catalytic combustor which needs periodic inspection and
replacement for proper operation. Consult the Owner's Manual for further
information. It is against Federal Regulations to operate this wood heater in
a manner inconsistent with operating instructions in the Owner's Manual.
Made in U.S.A. of US and imported parts. / Fabriqué aux États-Unis-
d'Amérique par des pièces d'origine américaine et pièces importées.
CAUTION:
AND CLOTHING AWAY- CONTACT MAY CAUSE SKIN BURNS- SEE NAMEPLATE
AND INSTRUCTIONS. KEEP FURNISHINGS AND OTHER COMBUSTIBLE
MATERIALS A CONSIDERABLE DISTANCE AWAY FROM THE APPLIANCE.
ATTENTION:
GARDEZ LES ENFANTS ET LES VÊTEMENTS ÉLOIGNÉS- TOUT CONTACT PEUT ENTRAÎNER
DES BRÛLURES DE LA PEAU. RÉFÉREZ-VOUS À LA PLAQUE SIGNALÉTIQUE ET AU MODE
D'EMPLOI. GARDEZ LE MOBILIER ET LES AUTRES MATÉRIAUX COMBUSTIBLES BIEN À
L'ÉCART DE L'APPAREIL.
2
MODEL / MODÈLE: "Dauntless FlexBurn Catalytic / Non-Catalytic"
LISTED SOLID FUEL ROOM HEATER
HOMOLOGUE POELE A COMBUSTIBLE SOLIDES
SUITABLE FOR MOBILE-HOME INSTALLATION – USA ONLY
Combustion air cannot be obstructed.
Damper must be open before opening doors.
'R QRW RYHU¿UH *ORZLQJ SDUWV LQGLFDWH RYHU¿ULQJ
The space heater must be installed with the legs provided, attached as shown in the
installation instructions.
,QVWDOOHU FRQIRUPpPHQW DX[ LQVWUXFWLRQV GX IDEULFDQW &RQWDFWHU OHV DXWRULWpV ORFDWHV SRXU
connaître les restrictions et inspections nécessaires. N'installer que les pattes qui sont
incluses, en conformité avec les instructions du fabricant.
Ne pas obstruer l'espace sous le poele.
Attention: 5LVTXH GH ÀDPPHV HW GH IXPpH VSLODJH 1H SDV REVWUXHU O¶HVSDFH VRXV OH
chauffe-eau.
Le registre doit être ouvert avant d'ouvrir les portes.
,QVSHFWH] HW QHWWR\H] OD FKHPLQpH IUpTXHPPHQW 'DQV FHUWDLQHV FRQGLWLRQV G¶XWLOLVDWLRQ
l'accumulation de créosote peut se produire rapidement.
Combustible: N'utiliser que du bois comme combustible. Ne pas utiliser d'autres types
de combustible. Inspecter et nettoyer la cheminée fréquemment - Sous certainesusages,
l'accumulation de créosote peu se produire rapidement. Garder les portes toutes fermées
ou toutes ouvertes durant l'opération.
Faire le feu directement sur la grille prévue à cet effet. Laisser les portes du poêle soit
complètement ouverts ou complètement fermées lors de l'utilisation. Ne pasraccorder le
conduit de cheminée du poêle à une cheminée servant à d'autres appareils. N'utiliser que
les vitres de céramique Vermont Castings en cas de remplacement de celles-ci.
Protection de plancher Canada: Lorsqu'il est installé sur un plancher de combustible, un
protecteur de plancher non combustible est requis sous le chauffe-eau. Le protecteur de
plancher doit s'étendre sur 460 mm (18 po) vers l'avant et 200 mm (8 po) vers les côtés et
l'arrière.
$FFHVVRULHV GLVSRQLEOHV DX &DQDGD .LW GH YHQWLODWHXU QXPpUR GH SLqFH
Catalyseur pièce no. 8346-006
Replacer uniquement qu'avec une glace 5mm Vermont Castings.
Attention: %UXOHU GHV PDWLqUHV DXWUHV TXH FHOOHV VSpFL¿pHV SRXUUDLW UHQGUH OH FDUDO\VHXU
inactif.
Attention: Le catalyseur est fragile, manipulaer avec soin.
Minimum Clearances to combustible Construction /
Minimum De Degagement Jusqu'a la construction combustible
The clearances shown belolw are for use with single wall connector pipe
B
D
C
A
A = Unit to Sidewall
B = Unit to Backwall
C = Chimney Connector to Sidewall
D = Chimney Connector to Backwall 15"
E = Unit to Adjacent Wall
F = Sides (Floor Protection)
G = Front to Glass (Floor Protection) 16"
H = Rear (Floor Protection)
I = Top of Stove to Ceiling
J = Chimney Connector to Ceiling
HOT WHILE IN OPERATION- DO NOT TOUCH- KEEP CHILDREN
CHAUD LORS DU FONCTIONNEMENT- NE TOUCHEZ PAS L'APPAREIL-
Date of Manufacture / Date de fabrication:
2021 2022 2023 JAN FEB MAR APR MAY JUN JUL AUG SEP OCT NOV DEC
Manufactured by / Fabriqué par: Hearth and Home Technologies 352 Mountain House Road, Halifax PA 17032
Vermont Castings • Dauntless FlexBurn Owner's Manual_R17 • 2020 - ___ • 09/23
Note: Cast iron is an artisan crafted material, which is
PDGH WKH VDPH ZD\ WRGD\ DV QHDUO\ \HDUV DJR
'XH WR WKH LQWULQVLF SULPLWLYH QDWXUH RI WKH FDVWLQJ
process, part to part variation is normal and adds to the
character of a hand built cast iron appliance
Serial No.
HF
N
o
de série:
BARCODE LABEL
BARCODE LABEL
J
H
E
I
Appliance to
F
F
Ceiling Clearance
E
G
Minimum Floor
Protection
14"
A = Entre le mur lateral et l'appareil
357 mm
14"
B = Entre le mur arriereet l'appareil
357 mm
23.5"
C = Entre le tuyau et le mur lateral
597 mm
D = Entre le tuyau et le mur arriere
381 mm
15"
E = Entre le mur adjacent et l'appareil
381 mm
6"
F = Côtes (la protection de plancher)
152 mm
G = Devant, par rapport au verr
457 mm
6"
H = Arrière (la protection de plancher)
152 mm
57.5"
I =
du haut du poêle au plafond
1461 mm
18"
J =
raccord de cheminée au plafond
457 mm
3-90-586190_R2
®
Wood Stove. At Vermont Castings we take
Serial No.
Model Name
7HVW /DE
5HSRUW 1R
Mfg. Date
®
:RRG 6WRYH ,W
3-90-586000C
Advertisement
Table of Contents
