Related Manuals for Cornelius D45
Summary of Contents for Cornelius D45
-
Page 1: Installation Manual
ICE DISPENSER D45 and D90 Installation Manual Publication Number: 91561 Revision Date: January 23, 2012 Revision: C Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs. -
Page 2: Contact Information
Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal... -
Page 3: Table Of Contents
Safety Instructions..............2 Read and Follow ALL Safety Instructions . -
Page 4: Safety Instructions
Only trained and certified electrical, plumbing and refrigeration technicians should service this unit. ALL WIRING AND PLUMBING MUST CONFORM TO NATIONAL AND LOCAL CODES. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE. © 1992-2011, IMI Cornelius Inc. Ice Dispenser D45 and D90 Installation Manual AFETY NSTRUCTIONS Recognize Safety Alerts... -
Page 5: Safety Precautions
When installing the unit in or on a counter top, the counter must be able to support a weight in excess of 115 lbs for D45 and 200 lbs for D90 to insure adequate support for the unit. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE. -
Page 6: Ice Dispenser Safety Precautions
If bagged ice is used, it must be carefully and completely broken into small, cube-sized pieces before filling into the dispenser hopper. © 1992-2011, IMI Cornelius Inc. Ice Dispenser D45 and D90 Installation Manual RECAUTIONS - 4 -... -
Page 7: Description
Ice Dispenser D45 and D90 Installation Manual ESCRIPTION The D45 or D90 ice dispensers solve your ice and beverage service needs in a sanitary, space saving, economical way. Designed to be manually filled with ice from any remote ice-making source, these dispensers will dispense cubes (up to 1-1/4”... -
Page 8: Installation Instructions
7. Clean the inside of the ice chute and ice chute cover with a mild detergent solution and rinse thoroughly to remove all traces of detergent. 8. Sanitize as described in Step 5. 9. Reverse steps above to reassemble ice chute. © 1992-2011, IMI Cornelius Inc. Ice Dispenser D45 and D90 Installation Manual - 6 - Publication Number: 91561... -
Page 9: Operating Instructions
Ice Dispenser D45 and D90 Installation Manual OPERATING INSTRUCTIONS Fill the hopper with ice and replace the lid. Pushing the dispenser lever will cause ice to flow from the ice chute. Ice flow will continue until the lever is released. If ice does not dispense, see the TROUBLESHOOTING GUIDE to find the cause. -
Page 10: Maintenance
2. Observe whether the gate is operating. After checking the above, refer to the TROUBLESHOOTING GUIDE for possible problem causes and corrective action. © 1992-2011, IMI Cornelius Inc. Ice Dispenser D45 and D90 Installation Manual MAINTENANCE - 8 - Publication Number: 91561... -
Page 11: Troubleshooting Guide
Ice Dispenser D45 and D90 Installation Manual TROUBLESHOOTING GUIDE Should your unit fail to operate properly, check that there is power to the unit and that the hopper contains ice. If the unit still does not dispense, check the following chart under the appropriate symptoms to aid in locating the defect. -
Page 12: Mounting Templates
Ice Dispenser D45 and D90 Installation Manual OUNTING EMPLATES Figure 1. © 1992-2011, IMI Cornelius Inc. - 10 - Publication Number: 91561... -
Page 13: Wiring Diagram
Ice Dispenser D45 and D90 Installation Manual IRING IAGRAM Figure 2. Publication Number: 91561 - 11 - © 1992-2011, IMI Cornelius Inc. -
Page 14: Solenoid Assembly-Exploded View And Parts List
21592 70433 51088 70438 NOTE: * Parts Supplied with rebuilding kit. # 31551 solenoid Supplied with items 20 & 21. © 1992-2011, IMI Cornelius Inc. Ice Dispenser D45 and D90 Installation Manual XPLODED IEW AND ARTS Figure 3. Qty. Name... -
Page 15: Dispensing Levers And Switches
Ice Dispenser D45 and D90 Installation Manual ISPENSING EVERS AND WITCHES CUP ACTIVATED PUSH LEVER Figure 4. Publication Number: 91561 - 13 - © 1992-2011, IMI Cornelius Inc. -
Page 16: Parts List
Wiring Diagram Front Label Capacitor Solenoid Assembly (see page 7) Rebuilding Kit (see page 7) © 1992-2011, IMI Cornelius Inc. Ice Dispenser D45 and D90 Installation Manual PARTS LIST Description Part No. D45 - 14 - Part No. D90 21491... - Page 17 Ice Dispenser D45 and D90 Installation Manual Publication Number: 91561 - 15 - © 1992-2011, IMI Cornelius Inc.
- Page 19 IMI Cornelius Inc. www.cornelius.com...