Troubleshooting - Yamaha XT250X 2008 Service Manual

EAS27220

TROUBLESHOOTING

The battery is not being charged.
NOTE:
Before troubleshooting, remove the following part(s):
1.Seat
2.Rear side cover
3.Fuel tank
4.Carburetor assembly
1. Check the fuse.
Refer to
"CHECKING THE FUSE" on
.
page 7-37
OK↓
2. Check the battery.
Refer to
"CHECKING AND CHARG-
ING THE BATTERY" on page 7-37
OK↓
3. Check the stator coil.
Refer to
"CHECKING THE STATOR
.
COIL" on page 7-44
OK↓
4. Check the rectifier/regulator.
Refer to
"CHECKING THE RECTI-
FIER/REGULATOR" on page 7-45
OK↓
5. Check the entire charging system's
wiring.
Refer to
"CIRCUIT DIAGRAM" on page
.
7-11
OK↓
This circuit is OK.
All manuals and user guides at all-guides.com
NG→
NG→
.
NG→
NG→
.
NG→
7-13
CHARGING SYSTEM
Replace the fuse.
Clean the battery terminals.
G
Recharge or replace the battery.
G
Replace the stator assembly.
Replace the rectifier/regulator.
Properly connect or repair the charging
system's wiring.