Page 1
C E R T I F I E D ® ® grill, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707. In Canada call ANSI Z21.58a-1998 / CGA 1.6a-M98 OUTDOOR COOKING GAS APPLIANCES 1-800-387-6161.
• NEVER place more than 15 pounds on a side table or a side burner. • NEVER use charcoal briquettes or lighter fluid in a gas grill. (Fig. 6) • Grill is hot when in use; to avoid burns, DO NOT touch any hot grill •...
General Safety Information (cont.) General Installation • Installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1 (USA), CAN/CGA-B149.1, Natural Gas Installation Code or CAN/CGA-B149.2, Propane Installation Code (Canada). To check local codes, see your local L.P.
L.P. gas is heavier than air and tends to collect in low areas. It is important that there are no leaking connections on your gas grill that could cause a fire or explosion (see “LEAK TESTING”, Pg. 12).
Do not use another hose and regulator assembly other than the one supplied with the grill or a Coleman replacement pressure regulator assembly. The pressure regulator and hose assembly provided is factory set at an outlet pressure of 11 inches water column (1/2 psi).
Transporting the Cylinder WARNING Handle a full cylinder with care. Gas is under high pressure. DANGER • NEVER store a spare L.P. gas supply cylinder under the grill body or inside grill enclosure or in the vicinity of any heat producing appliance. (Fig. 12) •...
Assembly/Set up Remove components from package. Burner Heat Tent Grease Grates Rotisserie Motor Blister Pack HVR Assembly Warming Rack Ignition Side Burner Grease Tray Rotisserie Brackets Rotisserie Spit Back Panel Middle Divider Right Leg Panel Left Leg Panel Top Panel Bottom Panel Left Side Burner Table Right Door...
Page 8
Assembly/Set up (cont.) STEP 1 BOTTOM & SIDE PANELS Install three screws from the top and three Hex nuts from below as shown for each side panel. Tighten screws. Panel with hole must be installed as shown. STEP 2 CASTERS Carefully turn over assembly.
Page 9
Assembly/Set up (cont.) STEP 6 INSTALLING IGNITION BOX Install the Ignition Box to the left front leg (on the inside surface) with two self-tapping screws. Two holes are provided for location. 2 Required STEP 7 RIGHT SIDE TABLE Remove preinstalled screws from Right Supports. Install Right Side Table.
Page 10
Assembly/Set up (cont.) STEP 9 BURNER ASSEMBLY The cardboard packing below the burners cannot be easily removed. It will burn away during the first use. STEP 10 HOSE ROUTING Route Burner Valve at end of Hose through hole in cart end. Insert Orifice Tube into burner, then rotate valve until valve stem goes through hole in side...
Page 11
Assembly/Set up (cont.) STEP 14 BURNER TRIVET Open Left Side Burner Lid and place Trivet on Burner. STEP 15 TOOL HOLDERS 4 Required Tool Hook STEP 16 LOWER DOOR MAGNETS 2 Required Lower Door Magnets Lower Shelf STEP 17 UPPER DOOR MAGNETS 2 Required Install Upper Door Magnets on Top Shelf as shown.
Assembly/Set up (cont.) STEP 20 ROTISSERIE (cont.) Install Rotisserie Motor & Rotisserie Spit as shown. Make sure Rotisserie Motor is placed on the right side of the grill. NOTE: The Rotisserie Motor will appear to be upside down when installed correctly.
2. Wash off soapy solutions with cold water and towel dry. 3. Stop a leak by tightening the loose joint, or by replacing the faulty part with a replacement part recommended by Coleman. DO NOT attempt to repair the cylinder valve if it should become damaged;...
Lighting Instructions (cont.) LEFT SIDE BURNER KNOB Control Knobs for Main Cooking Area Lighting Main Burners 1. Turn on any or all burner gas control knobs. (Fig. 19) 2. Press the Igniter switch until the flame ignites. 3. If the flame doesn’t immediately light, turn off control knob and wait five minutes for gas to clear.
Shutting Off the Grill (cont.) 1. Turn all burner control knob(s) to off. 2. After burner flame goes out, turn off fuel supply. For an L.P. cylinder, turn the L.P. cylinder knob in a clockwise direction until it stops. CAUTION Be certain the gas is shut off at the L.P.
L.P. cylinder, cylinder valve, regulator, gas supply hose, burner valve(s) and burner(s). 5. If any of the above mentioned components are damaged, seek replacement from Coleman before operating the grill again. Locate your nearest service center by calling 1-800-835-3278.
Moving and Storage CAUTION A collision with the grill, as with any metal object, could cause injury. Use care when moving a portable gas grill. Moving the grill: • Move grill slowly. DO NOT run with or pull the grill behind you;...
Replacement Parts List Item Part No. 9947-2321 Left Side Burner Table, Stainless 9947-6561 Cast Brass Side Burner 9947-1471 Side Burner Control Knob 9947-3271 Side Burner Electrode (Not Shown) 9947-1271 3 Black Control Knobs 9947-1591 3 Bezels 9947-2071 Right Side Table, Stainless 9947-5261 Hardware Kit - Cart (Not Shown) 9947-5281...
Keep the original sales receipt. Proof of purchase is required to obtain warranty performance. Coleman dealers, service centers, or retail stores selling Coleman products do not have the right to alter, modify or any way change the terms and conditions of this warranty.