Yamaha Apex RX10PA 2011 Supplementary Service Manual page 29

GENERAL MAINTENANCE AND LUBRICATION CHART
ITEM
* Drive chain
* Drive chain oil
* Shift lever
* Brake and parking brake
Control cables
* Disc brake installation
* Extrovert drive sprocket
* Slide runners
* Skis and ski runners
* Steering system
* Steering bearings
Skis and front shock
*
absorbers
* Suspension component
* Drive track
Fittings and fasteners
* Battery
TIP
Brake system:
• After disassembling the master cylinder or caliper cylinder, always change the brake fluid.
Regularly check the brake fluid level and add fluid if necessary.
• Replace the oil seals of the master cylinder and caliper cylinder every two years.
• Replace the brake hose every four years, or if cracked or damaged.
REMARKS
• Check chain slack.
• Adjust if necessary.
• Check oil level.
• Change.
• Lubricate with specified grease.
• Adjust free play and/or replace pads if necessary.
• Change brake fluid.
• Make sure that operation is smooth.
• Lubricate if necessary.
• Check for slight free play.
• Lubricate shaft with specified grease as required.
• Check for wear and damage.
• Replace if necessary.
• Check for wear and damage.
• Replace if necessary.
• Check for wear and damage.
• Replace if necessary.
• Check toe-out.
• Adjust if necessary.
• Check bearing assemblies for looseness.
• Lubricate with specified grease.
• Lubricate with specified grease.
• Lubricate with specified grease.
• Check the deflection.
• Adjust if necessary.
• Make sure that all nuts, bolts and screws are properly tightened.
• Tighten if necessary.
• Check condition.
• Charge if necessary.
3-2
INSP
ADJ
INITIAL EVERY
1 month Seasonally
or 800 km or 4,000 km
(500 mi) (2,500 mi)
(40 hr) (200 hr)
Initial at 500 km (300 mi) and
every 800 km (500 mi)
thereafter.
See TIP following this chart.
Every 1,600 km (1,000 mi)
Initial at 500 km (300 mi) and
every 800 km (500 mi)
thereafter.