Table of Contents
Advertisement
Innovative Hearth Products
DRT4000 Direct Vent Gas Fireplace
TABLE OF CONTENTS
Safety and Your Fireplace ......................... Page
Packaging ................................................ Page
Introduction ............................................. Page
General Information ................................. Page
Requirements ....................................... Page
Cold Climate Insulation ............................ Page
Manufactured Home Requirements ......... Page
Location ................................................... Page
Vent Termination Clearances ................... Page
Appliance and Vent Clearances ................ Page 10
Pre-Installation Steps ............................... Page 11
Typical Installation Sequence .................. Page 11
Step 1. Framing ........................................ Page 11
Step 2. Routing Gas Line ......................... Page 13
Step 3. Vent Restrictor Installation........... Page 14
Step 4. Install The Venting System .......... Page 15
Vertical Termination Systems ................... Page 16
Horizontal Termination System ................ Page 21
Step 10. Remove/Install Glass Door ...... Page 32
Step 11. Burner Adjustments ................. Page 32
Step 13. Hood Installation ...................... Page 35
Finishing Requirements ........................... Page 35
Installation Accessories ........................... Page 36
Gas Conversion Kits ................................ Page 37
Important Safety Information ................... Page 39
Appliance Operation Notices ................... Page 41
General Information ................................. Page 41
Operation/Care of Your Appliance ............ Page 43
Gas Controls Access ................................ Page 43
Variable Flame Adjustment ....................... Page 44
Maintenance ............................................ Page 45
Install Volcanic Stone, Embers and Logs . Page 47
Burner Flame Appearance/Sooting and
Adjustments ......................................... Page 49
Wiring Diagrams ..................................... Page 51
Accessory Components ........................... Page 52
Maintenance Schedule ............................. Page 55
Lighting Instructions ................................ Page 56
Troubleshooting Guide ............................ Page 60
Replacement Parts List ........................... Page 62
Warranty ................................................. Page 65
Please read and understand these
instructions before beginning your
installation.
4
PACKAGING
2
The assembled vented gas fireplace heater is
4
packaged with:
4
1 - logs in a carton located within the firebox.
4
2 - one plastic bag of glowing embers in the
bottom compartment.
6
3 - literature package containing the Installa-
7
tion and Operation Manual (this manual),
7
Safety Flyer, Glass and Barrier Flyer and
7
Safety-in-Operation Warning Labels.
8
4 - one rear and one top vent restrictor are
provided with this fireplace. See Page 14
for installation instructions.
5 - one hood.
6 - front face assembly with barrier installed.
7 - 4" top stand off taped diagonally to the rear
of the fireplace.
INTRODUCTION
The Millivolt appliances have a millivolt gas
control valve with piezo ignition system. If any
optional accessories that will require electrical
power are to be installed, the electrical power
must be provided at the time of appliance instal-
lation. The Electronic appliances are designed to
operate on natural or propane gas. An electronic
intermittent pilot ignition system provides safe,
efficient operation. External electrical power is
required to operate these units.
These vented gas fireplace heaters are sealed
combustion, air-circulating gas fireplaces de-
signed for residential applications.
Approved Vent Components - These fireplaces
are designed, tested and listed for operation
and installation with the following vent com-
ponents only:
•
Secure Vent
Direct-Vent System Compo-
®
nents manufactured by IHP,
•
Secure Flex
Flexible Vent Components
®
manufactured by IHP and
•
Z-FLEX
Model GA Venting Systems listed
®
to UL1777 and ULCS635 manufactured by
Flexmaster Canada Limited.
Use only the correct size venting (4-1/2" inner
and 7-1/2" outer).
These approved vent system components are
labeled for identification. DO NOT use any
other manufacturer's vent components with
these appliances.
NOTE:
• If the barrier becomes dam-
aged, the barrier shall be re-
placed with the manufacturer's
barrier for this appliance.
• For use with barrier(s) Part
No(s). J7420 (40" Models) and
J7428 (45" Models).
NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
Installation and Operation Instructions
900357-00, 09/2015
GENERAL INFORMATION
WARNING
Young children should be care-
fully supervised when they are
in the same room as the appli-
ance. Toddlers, young children
and others may be susceptible
to accidental contact burns. A
physical barrier is recommended
if there are at-risk individuals in
the house. To restrict access to
a fireplace or stove, install an
adjustable safety gate to keep
toddlers, young children and
other at-risk individuals out of
the room and away from hot
surfaces.
AVERTISSEMENT
Les jeunes enfants devraient être
surveillés étroitement lorsqu'ils
se trouvent dans la même pièce
que l'appareil. Les tout petits,
les jeunes enfants ou les adultes
peuvent subir des brûlures s'ils
viennent en contact avec la sur-
face chaude. Il est recommandé
d'installer une barrière physique
si des personnes à risques habi-
tent la maison. Pour empêcher
l'accès à un foyer ou à un poêle,
installez une barrière de sécu-
rité; cette mesure empêchera les
tout petits, les jeunes enfants et
toute autre personne à risque
d'avoir accès à la pièce et aux
surfaces chaudes.
Children and adults should be alerted to the
hazards of high surface temperature and
should stay away to avoid burns or clothing
ignition.
Les enfants et les adultes devraient être infor-
més des dangers que posent les températures
de surface élevées et se tenir à distance afin
d'éviter des brûlures ou que leurs vêtements
ne s'enflamment.
DO NOT ATTEMPT TO ALTER OR MODIFY
THE CONSTRUCTION OF THE APPLIANCE OR
ITS COMPONENTS. ANY MODIFICATION OR
ALTERATION MAY VOID THE WARRANTY,
CERTIFICATION AND LISTINGS OF THIS UNIT.
Advertisement
Table of Contents
