Page 1
Æ ISLA Food Counters IM-FR-Refrigerated Counters IM-FH-Hot Counters IM-FS-Soup Counters Installation & Operation Manual Shipped with Technical Data Sheets P/N P/N 3034423_C MANUAL-I/O ISLA COUNTER CASES January 2022...
Page 2
The information contained in this document is the property of Hussmann Corporation and shall not be used in whole or in part without written permission. This manual was written in accordance with originally prescribed equipment that is subject to change.
Check your shipment for any possible shortages of material. If a shortage should exist and is found to be the responsibility of Hussmann, notify Hussmann. If such a shortage involves the carrier, notify the carrier immediately, and request an inspection. Hussmann will acknowledge shortages within ten days from receipt of equipment.
Moving Dolly —¦— August 31, 2018 This warning does not mean that Hussmann products will cause cancer or reproductive harm, or is in violation of any product-safety standards or requirements. As clarified by the California State REVISION HISTORY government, Proposition 65 can be considered more of a ‘right to know’...
PN_3034423_C Cut and Plan Views DESCRIPTION OF CASE HUSSMANN - ISLA HOT SOUP SELF-SERVICE FOOD COUNTERS (CHINO) PLAN PHOTO SECTION ELECTRICAL DATA: LIGHTING: T5 WITH ELECTRONIC BALLASTS 120V INPUT VOLTAGE T5 CANOPY L.E.D. CANOPY T5 TOTAL L.E.D. TOTAL CONVENIENCE HEAT LAMPS...
Page 8
Cut and Plan Views (Continued) DESCRIPTION OF CASE HUSSMANN - ISLA HOT WELL SELF-SERVICE FOOD COUNTERS (CHINO) PLAN PHOTO SECTION ELECTRICAL DATA: LIGHTING: T5 WITH ELECTRONIC BALLASTS 120V INPUT VOLTAGE CANOPY TOTAL CONVENIENCE LEDGE LIGHTS CASE CASE LIGHTS LIGHTS OUTLETS...
Page 9
WELLS WELLS TYPE COIL (MIN.) ONLY VOLTS AMPS OUTLETS AMPS WATTS AMPS WATTS AMPS WATTS OFF TIME OFF TIME OFF TIME OFF TIME OFF TIME OFF TIME OFF TIME ISLA FOOD COUNTERS OPTIONS/NOTES: HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
All cases were leveled and joined prior to shipment to insure the closest possible fit when cases are joined in the field. When joining, use a carpenters level and shim PN_3034423_C U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Refrigerant lines should be sized as shown on the refrigeration legend furnished by the store. install P-TRAPS (oil traps) at the base of all suction line vertical risers. PN_3034423_C U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Page 13
T- S TAT Location refrigeration stub. A Sporlan balanced port expansion T-STATS are located within the electrical raceway. valve model is furnished as standard equipment, unless otherwise specified by customer. ISLA FOOD COUNTERS HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
It should be wired to a dedicated circuit. Ballast Location Ballasts are located within the access panel. PN_3034423_C U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Therefore, it must be the user’s responsibility to establish the correct control settings to maintain the food at the safest, tastiest and saleable condition. ISLA FOOD COUNTERS HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Page 16
Turn the fill valve to open position. • Close the drain valve. To drain the well: • Turn the fill valve to the closed position. • Open the drain valve. PN_3034423_C U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Page 17
Adjust overhead heater as necessary. Shutting down: • Turn “ON” switch off. • Close fill valve. • Open drain valve. • Once the water is drained, close the drain valve. ISLA FOOD COUNTERS HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Do not run hot wells without any water! EXTERIOR ONLY • DO NOT USE A CHLORANITED CLEANER ON ANY SURFACE • DO NOT USE ABRASIVES OR STEEL WOOL SCOURING PADS (these will mar the finish) PN_3034423_C U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Page 19
Case Cleaning maximize life of the product. Hussmann cases were not Long life and satisfactory performance of any equipment designed to “heat up” or “cool down” product - but rather are dependent upon the care given to it.
Complies with FDA USDA Number handy. This information is on a plate & OSHA Regulations located on the case itself. for replacement call: 1-800-395-9229 Turn switch off then on after replacing bulb PN_3034423_C U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Due to the Custom nature of these cases, the wiring diagrams and loads are appended to each guide. f or additional copies, please contact the factory. Have the unit serial number available. ISLA FOOD COUNTERS HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
There are glass gaps on See glass adjustment section. the side of the case. Glass is not completely Close glass correctly. shut. continued on next page... PN_3034423_C U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Page 23
Case should be serviced by a qualified service technician. Lamp socket needs to be replaced. Lamp needs to be See Maintenance Section. replaced. Case should be serviced by a qualified service technician. Light Switch needs to replaced. ISLA FOOD COUNTERS HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Page 24
Case should be serviced by a qualified service technician. Lamp socket needs to be replaced. Lamp needs to be See Maintenance Section. replaced. Case should be serviced by a qualified service technician. Light Switch needs to replaced. PN_3034423_C U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Please note them below for future reference. (909) 628-8942 FAX MODEL: (909) 590-4910 (800) 395-9229 SERIAL NUMBER: Hussmann Corporation 12999 St. Charles Rock Road HATCO SERIAL No: Bridgeton, MO 63044-2483 (800) 922-1919 www.hussmann.com PN_3034423_C U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...