Heat & Glo NorthStar-BK Installation Manual page 19

Installation
• Re ove t e no out o
e la e an is a it See i u e 3 14
• ut a 3 in 6 ole in t e insulation oa
t e i ensions s o n in i u e 3 14
3- 1 3/ 1 6 in.
(9 7 mm)
3- 1 / 8 in. (7 9 mm)
C L
Figure 3.14
• Dete ine t e ne essa
Ta le 3 1 an ut as e ui e
Table 3.1
Run Length
20 - 40 ft (6-12 m)
*A minimum of 2 in. (51 mm) pipe must be used to
cover the raw insulation to prevent it from blowing
out through the return air grille.
10 - 20 ft (3 - 6 m)
3 - 10 ft (1 - 3 m)
**
Use full 16 in. (406 mm) as supplied
NOTE: It is important the pipe length be adhered to
or it will affect the performance of your fireplace.
• On t e ountin late
Sli e t e ta s ove t e outsi e o t e sta te
it ou s eet etal s e s in lu e in astene s
a a e i u e 3 15
Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev D • 05/30/13
All manuals and user guides at all-guides.com
ove late o t e to o t e
as e
A d a p t e r
M o u nt ing
P l a t e
S t a r t e r P ip e
K no c k o u t
len t o sta te i e o
Cut Pipe
2 in. (51 mm)*
8 in. (203 mm)
No cut needed**
an en t e ta s o n a
i e Se u e
Figure 3.15
• Sli e t e sta te
oles in t e late to t e oles in t e
• la e t e a a te on t e
sin ou s eet etal s e s in lu e in t e it se u e
t e a a te an
se u in to t e
to t e to o t e
lea a e
• Dete ine t e lo ation o t e ai
ousin asse
346 ole et een a in
o oo oists T e
ounte to t e a
i u e 3 16
t e
NOTICE: The fan and electrical connections must be
accessible for servicing per local code requirements.
NOTICE: If the fan housing is installed in a 2 x 4 wall,
the front of the housing will protrude approximately 1/4
in. (6 mm) from the finished wall.
• Atta enou
ou installation to t e an ousin
90° elbows is recommended. Se u el t ist lo
- ent to t e a a te
Also s e
ousin See i u e 3 1
o no eate t an 4 t 1
WARNING! Risk of Fire!
clearances specified.
•
A minimum 1 in. (13 mm) air clearance must be
maintained at the back and 1 in. (25mm) to the sides
of the fireplace assembly.
i e into t e e la e
e la e
ountin late linin u
ountin late into
e la e ta e o n t e a a te e
e la e it alu inu ta e to
e iste an
l ut a -5/8 in 13-5/8 in 143
e e s
a ets an e otate 180 an
si e o t e 2 4 i ne essa
6 in 152 - ent as e ui e
A maximum of (4)
t e - ent to t e outlet o on t e an
Su o t u t at inte vals
as e ui e
Comply with all minimum
at in t e
oles
e la e A te
es
event
an
all stu s
See
o
t e
lo al o e
1