Heat & Glo NorthStar-BK Installation Manual
Hide thumbs
Also See for NorthStar-BK:
- Owner's manual (73 pages) ,
- Installation manual (44 pages) ,
- Owner's manual (72 pages)
Table of Contents
Advertisement
Quick Links
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
NOTICE:
DO NOT discard this manual!
Model(s):
Tested an d
O-T L
L isted b y
C
OM N I - Test L ab oratories, I n c.
EPA CERTIFIED WOODBURNING
FIREPLACE
Installation an se vi e o t is
e o
e
Te
nolo ies e o
sionals o te
N I e ti e
o essional
Heat & Glo • NORTHSTAR • 480-2360 Installation Manual • Rev D • 05/30/13
All manuals and user guides at all-guides.com
Installation Manual
Installation and Fireplace Setup
P ortl an d
Oreg on U SA
U S
e la e s oul
uali e
e sonnel Hea t & Ho e
en s N I e ti e
o es-
ni ians su e vise
an
WARNING: If the information in these
instructions is not followed exactly, a fire
or explosion may result causing property
damage, personal injury, or death.
• DO NOT sto e o use asoline o ot e a -
a le va o s an li ui s in t e vi init o t is
o an ot e a
• DO NOT ove
a ant
•
o
l
it all ini u
usti les as s e i e
ause ouse
•
AR
e la e
• Ale t
il en an a ults to a a s o
High temperatures may ignite clothing or other flammable
materials.
•
ee
lot in
ate ials a a
e
Fire Risk.
o use it soli
Ot e uels
oisonous ases i e
lian e
e Ove
in
ill voi
lea an es to o -
ailu e to o
e
WARNING
HOT SURFACES!
Glass an ot e su a es a e ot u in
o e ation AND ool o n
Hot glass will cause burns.
• DO NOT tou
lass until it is oole
• N
R allo
il en to tou
•
ee
il en a a
S
R IS
il en in sa e oo
i
u nitu e
a e ies an ot e
WARNING
oo
uel onl
a ove
e an
ene ate
a on
ono i e
ou
l
a
lass
as
te
e atu es
a
a le
1
Advertisement
Table of Contents
Related Manuals for Heat & Glo NorthStar-BK
Summary of Contents for Heat & Glo NorthStar-BK
- Page 1 All manuals and user guides at all-guides.com Installation Manual Installation and Fireplace Setup INSTALLER: Leave this manual with party responsible for use and operation. OWNER: Retain this manual for future reference. NOTICE: DO NOT discard this manual! WARNING: If the information in these instructions is not followed exactly, a fire or explosion may result causing property damage, personal injury, or death.
-
Page 2: Table Of Contents
All manuals and user guides at all-guides.com Safety Alert Key: • DANGER! In i ates a a a ous situation i not avoi e ill esult in eat o se ious in u • WARNING! In i ates a a a ous situation i not avoi e esult in eat o se ious in u • CAUTION! In i ates a a a ous situation... - Page 3 All manuals and user guides at all-guides.com ATTENTION INSTALLER: Follow this Standard Work Checklist T is stan a e list is to e use t e installe in on u tion it not instea o t e inst u tions ontaine in this installation anual Customer: Date Installed:...
-
Page 4: Product Specific & Important Safety Information
All manuals and user guides at all-guides.com Product Specific & Important Safety Information A. Fireplace Certification B. Glass Specifications T is e la e is e ui it 5 e a i lass Re- T is e la e s ste as een teste an liste in a - la e lass onl it 5... - Page 5 All manuals and user guides at all-guides.com E. Electrical Codes This fireplace must be electrically wired and NOTICE: grounded in accordance with local codes or, in the absence of local codes, with National Electric Code ANSI/ NFPA 70-latest edition or the Canadian Electric Code CSA C22.1.
-
Page 6: Getting Started
All manuals and user guides at all-guides.com Getting Started A. Typical Fireplace System T e r m ina t io n C a p A d d it io na l l a t e r a l s u p p o r t f o r c h im ne y a b o v e r o o f ( o r e nc l o s e d in c h a s e ) if ne e d e d S t o r m C o l l a r... - Page 7 All manuals and user guides at all-guides.com B. Design and Installation Considerations NOTICE: In addition to these framing dimensions, also reference the following section: • Clearances (Section 3). NOTICE: Check building codes prior to installation. • Installation M ST o it lo al e ional state an NOTICE: national o es an...
- Page 8 All manuals and user guides at all-guides.com 2. Locating Fireplace & Chimney o ation o t e e la e an i ne ill a e t e o - an e • Install t e outsi e ai it it t e inta e a in evailin •...
- Page 9 All manuals and user guides at all-guides.com C. Tools and Supplies Needed E. Fireplace System Requirements e o e e innin t e installation e su e t e ollo in e la e s ste e ui e ents onsist o t e ollo - tools an uil in su lies a e availa le...
- Page 10 All manuals and user guides at all-guides.com Framing and Clearances ► A. Fireplace Dimensions 23- 1 /8 in. ( 5 8 7 m m ) 1 1 - 1 /8 in. ( 28 3 m m ) 3- 1 /2 in. ( 8 9 m m ) 1 in.
- Page 11 All manuals and user guides at all-guides.com B. Clearances WARNING! Risk of Fire! You must comply with all minimum air space clearances to combustibles as specified in Figure 3.2. DO NOT pack required air spaces with insulation or other materials. Framing or finishing material used on the front of, or in front of, the fireplace closer than the minimums listed must be constucted entirely of non-combustible materials (i.e., steel studs, concrete board, etc.). Failure to comply may cause fire. S t o r m C o l l a r R o o f F l a s h ing 2 in.
- Page 12 All manuals and user guides at all-guides.com 1. Minimum Clearances to Combustibles WITHIN ENCLOSURE AREA i e la e to a 1 in 25 i e la e to si e all 1 in 25 Du t oots to a in 0 in 0 To stan o s to ea e 0 in 0...
-
Page 13: Onst U T T E Ase
All manuals and user guides at all-guides.com R o u nd T e r m ina t io n C a p C. Construct the Chase S t o r m C o l l a r ase is a ve ti al o li e st u tu e uilt to en lose t e e la e an /o its vent s ste e ti al i ne s t at... -
Page 14: D A E T E I E La E
All manuals and user guides at all-guides.com D. Frame the Fireplace E. Secure and Level the Fireplace T is e la e e la e on eit e a o usti le o Hea t e tension esi n ust e ete NOTICE: non o usti le ontinuous at su a e... - Page 15 All manuals and user guides at all-guides.com F. Protective Metal Hearth Strips G. Facing Material WARNING! Risk of Fire! WARNING! Risk of Fire! Protective metal hearth strips MUST be installed on combustible surfaces. DO Follow these instructions exactly. Facing materials must be installed properly to prevent NOT cover metal strips with combustible materials.
- Page 16 All manuals and user guides at all-guides.com H. Outside Air Kit An outsi e ai ust e use ustion Hea t & Ho e Te nolo ies e o en s ou utili e t e s o test u t un to o ti i e t e e o an e o t e outsi e ai it T e outsi e ai inlet oo s oul e ositione in a...
- Page 17 All manuals and user guides at all-guides.com G a r a g e o r c o m b u s t ib l e A t t ic s p a c e l iq u id s s t o r a g e O u t l e t b l o c k e d b y s no w , l e a v e s , e t c .
- Page 18 All manuals and user guides at all-guides.com DUCT RUN REQUIREMENTS I. Heat Zone Kit (Optional) T e Heat- one a esso it onve s a MA IM M Du t Run 40- t 12 e la e t ou u t s to e ote lo ations in t e MINIM M Du t Run 36 in sa e oo...
- Page 19 All manuals and user guides at all-guides.com Installation • Re ove t e no out o late o t e to o t e e la e an is a it See i u e 3 14 • ut a 3 in ole in t e insulation oa as e t e i ensions s o n in i u e 3 14...
- Page 20 All manuals and user guides at all-guides.com NOTICE: Secure the duct so that clearance to the fire- 2 x 4 W a l l place outer wrap is maintained. Tape all seams with alumi- num tape 1-1/4 in. (32 mm) minimum width or as specified F a n H o u s ing by local codes.) •...
-
Page 21: Electrical Wiring
All manuals and user guides at all-guides.com Electrical Wiring NOTICE: The manual override switch, rheostat speed NOTICE: Wiring for fans must be done before framed control and cover plate are supplied. You will need to supply: enclosure is completed. If using a Heat Zone kit, it also must 14-3 wire with ground;... -
Page 22: Chimney And Termination Requirements
All manuals and user guides at all-guides.com Chimney and Termination Requirements A. Chimney Requirements NOTICE: You must provide support for the pipe during construction and check to be sure inadvertent loading has e ti al istan es a e easu e t e ase o t e not dislodged the chimney section from the fireplace or at e la e as s o n in i u e 5 1... - Page 23 All manuals and user guides at all-guides.com B. Offsets/Returns • se an o set/ etu n to ass ove ea o st u tions • An o set an etu n an e use as a sin le entit o se a ate i ne se tion s WARNING! Risk of Fire! DO NOT use offset/returns greater than 30°.
- Page 24 All manuals and user guides at all-guides.com C. Termination Requirements • Install a a a ove an liste o t is e la e s ste • o ate a e e it ill not e o e lu sno o ot e ate ials •...
-
Page 25: Chimney Installation
All manuals and user guides at all-guides.com Chimney Installation A. Typical Chimney System NOTICE: Chimney performance may vary. • Trees, buildings, roof lines and wind conditions affect performance. • Chimney height may need adjustment if smoking or overdraft occurs. T e r m ina t io n C a p C h im ne y m u s t e x t e nd b e y o nd c o m b u s t ib l e r o o f s t r u c t u r e M a int a in m inim u m... - Page 26 All manuals and user guides at all-guides.com B. Assemble Chimney Sections C. Install Chimney Air kit (CAK4A) se onl t ose o onents es i e in t is anual NOTICE: Chimney Air Kit, Part CAK4A is required when Su stitute o a a e i ne onents oul i...
- Page 27 All manuals and user guides at all-guides.com NOTES: • T e A 4A te ination a ust e a ini u o 4 t a ove t e oun an e t ee o e is • I t e A 4A is installe in a ase t e A 4A si e...
-
Page 28: Install Eilin I Esto S
All manuals and user guides at all-guides.com D. Secure Offset/Return R O O M A B O V E ( no n- ins u l a t e d c e il ing ) en o sets an etu ns a e oine to st ai t i e se - tions t e ust e lo e into osition it t e s e s... -
Page 29: Install Atti Insulation S Iel
All manuals and user guides at all-guides.com F. Install Attic Insulation Shield Bend remaining tabs WARNING! Risk of Fire! You MUST install an attic insu- to rest against pipe to lation shield when there is any possibility of insulation or prevent insulation B e nd inw a r d other combustible material coming into contact with the... -
Page 30: Tension
All manuals and user guides at all-guides.com G. Roof Penetration • Re e to i u e 6 10 • oo to ente o i ne • D ive a nail u t ou oo to ente o • Measu e to eit e si e o nail an t e 14-1/2 in 14-1/2 in 368 o enin... - Page 31 All manuals and user guides at all-guides.com I. Install Chase/Chase Top C H I M N E Y • ou M ST use a ase to in a ase installation F L A S H I N G ase to s a e availa le o ou Heat &...
- Page 32 All manuals and user guides at all-guides.com J. Termination Cap Requirements T e r m ina t io n • Install a a a ove an liste o t is e la e s ste C a p • o ate a e e it ill not e o e lu S l ip...
- Page 33 All manuals and user guides at all-guides.com P l a c e w a t e r p r o o f s e a l e r u nd e r e a c h f l a ng e o f t h e P l a c e w a t e r p r o o f R e m o v e 2 s c r e w s t e r m ina t io n c a p a nd o n...
- Page 34 All manuals and user guides at all-guides.com Finishing A. Template B Finish the Wall ► late o t e ont is inte on t e outsi e se a et o to el o a so t us to e ove an o t e s i ut out t e te late alon t e out-...
- Page 35 All manuals and user guides at all-guides.com C. Mantel and Wall Projections D. Finishing the Hearth Extension usti le antel e ositione no lo e t an 60 in 1524 t e ase o t e e la e WARNING! Risk of Fire! High temperatures, sparks, em- bers or other burning material falling from the fireplace Re e to Se tion 3 o e u e...
- Page 36 All manuals and user guides at all-guides.com • i e la e installe us on t e oo an ea t e tension aise to otto o as ia Non- o usti le oo in a ini u o 20 in 508 in ont o an 8 in 203 to eit e si e o t e uel o enin is e ui e...
- Page 37 All manuals and user guides at all-guides.com ► E. Non-Combustible Sealant Material • A te letin t e installation o non- o usti le ate ial in t e e ui e non- o usti le one an t e non- o usti le nis in ate ial ove t at e ove t e...
-
Page 38: Fireplace Setup
All manuals and user guides at all-guides.com Fireplace Setup A. Firebrick Placement e o o e la e is line ualit as e e tional insulatin o e ties Do not use a ate si uil a e on t e Do not o e ate t e e la e it out i s Ma e su e... - Page 39 All manuals and user guides at all-guides.com B. Baffle and Blanket Placement nsu e o e t a e an ote tion annel la e- ent e la e a e o onents i a a e o issin of i e o e a ic Blan et Baf le ote tion...
-
Page 40: Reference Materials
All manuals and user guides at all-guides.com Reference Materials A. Chimney Components T e ollo in a in s s o t e S -300 Se ies i ne an e la e o onents e sa el use it t is e la e 1 2 in. - Page 41 All manuals and user guides at all-guides.com 1 0 - 1 /2 in. I ns id e ( 267 m m ) D ia m e t e r 20 - 3/4 in. 8 in. ( 5 27 m m ) ( 20 3 m m ) O u t s id e 2 in.
- Page 42 All manuals and user guides at all-guides.com 22 1 /2 in. 66 in. ( 5 72 m m ) ( 1 676 m m ) 20 in. ( 5 0 8 m m ) 1 6 1 /2 in. ( 41 9 m m ) 1 /2 in.
- Page 43 All manuals and user guides at all-guides.com 1 3 1 /4 in. ( 337 m m ) 1 6 1 /4 in. ( 41 3 m m ) 26 1 /2 in. ( 673 m m ) 28 5 /8 in. ( 727 m m ) 1 8 in.
- Page 44 All manuals and user guides at all-guides.com B. Accessories MESH-HHT Firescreen Heat & Glo a an o Hea t & Ho e Te nolo ies 5 1 215t St eet a eville MN 55044 eatn lo o lease onta t ou Heat & Glo eale it an uestions o on e ns...