Table of Contents
Advertisement
Quick Links
PLEASE READ THIS MANUAL
BEFORE INSTALLING AND
USING APPLIANCE.
IMPORTANT: Read all instruc-
tions and warnings carefully be-
fore starting installation. Failure
to follow these instructions may
result in a possible fire hazard
and will void the warranty.
WARNING: If the information in this
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury or loss of life.
FOR YOUR SAFETY
Installation and service must be
performed by a qualified installer,
service agency, or the gas supplier.
Do not store or use gasoline or
f i r e - p a r t s . c o m
other flammable vapors and liquids
in the vicinity of this or any other
appliance.
FOR YOUR SAFETY
If you smell gas:
1. Do not touch electrical switches.
2. Do not try to light any appliance.
3. Do not use the phone in your
building.
4. Immediately call your gas sup-
plier from a neighbor's phone.
5. Follow your gas supplier's in-
structions.
6. If you cannot reach your gas sup-
plier, call the fire department.
This is an unvented gas-fired
heater. It uses air (oxygen) from the
room in which it is installed. Provi-
sions for adequate combustion and
ventilation air must be provided.
Unvented
Freestanding
Model
FSUV20
FSUV30
Installation and Homeowners
Operating Instructions
CFM Specialty Home Products
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777
www.majesticproducts.com • www.vermontcastings.com
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
10001784 10/05 Rev. 3
Advertisement
Table of Contents
Related Manuals for Majestic FSUV20
Summary of Contents for Majestic FSUV20
- Page 1 Do not store or use gasoline or f i r e - p a r t s . c o m other flammable vapors and liquids FSUV20 in the vicinity of this or any other appliance. FOR YOUR SAFETY...
-
Page 2: Table Of Contents
FSUV20/30 Vent Free Gas Heater Table of Contents PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING APPLIANCE. Thank you and congratulations on your purchase of a CFM Specialty Home Products fireplace. IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible fire hazard and will void the warranty. -
Page 3: Installation & Operating Instructions
FSUV20/30 Vent Free Gas Heater Installation & Operating Instructions Design-certified to ANSI Z21.11.2a 2003. Gas-Fired Room FOR SAFE INSTALLATION AND OPERATION OF YOUR Heaters — Vol. II, Unvented Room Heaters. VENT-FREE ROOM HEATER PLEASE NOTE THE FOL- LOWING: This gas room heater should be installed by a qualified installer in accordance with local building codes and with cur- 1. -
Page 4: Fireplace Dimensions
FSUV20/30 Vent Free Gas Heater Freestanding Fireplace Dimensions f i r e - p a r t s . c o m Fig. 1 Stove dimensions. Ref. FSHUV20 FSHUV30 0651 25³⁄₁₆" (640 mm) 27¹⁵⁄₁₆" (710 mm) FSHUV20/30 specs 14³⁄₄" (375 mm) 14³⁄₄"... -
Page 5: Safety Devices
FSUV20/30 Vent Free Gas Heater Safety Devices Gas Supply Pressures Adequate combustion and ventilation air must be pro- This heater must be isolated from the gas supply piping vided. The flow of combustion and ventilation air MUST system by closing its individual manual shut-off valve during any pressure equal to or less than 1/2 psig (3.45... -
Page 6: Run Gas Line
FSUV20/30 Vent Free Gas Heater Installation Run Gas Line ON/OFF Switch Screw If gas piping from the source to the heater location has Assembly (through existing not been accomplished, install the required pipe. Con- hole) sult local plumbing code to assure proper pipe size. -
Page 7: Operating Instructions
FSUV20/30 Vent Free Gas Heater Operating Instructions Window Frame Removal Ember Material Placement Separate the ember material into small pieces (roughly Refer to Figure 6. 1/2" diameter) and place (keep 1/2" space between 1. Shut off gas. (See Lighting Instructions) ember pieces) onto the grille in front of the front burner. -
Page 8: Flame Characteristics
FSUV20/30 Vent Free Gas Heater FSUV20 LG439 FSUV30 f i r e - p a r t s . c o m ����� ������� ���� ���� LG274 Fig. 7 Correct log placement. Turn counterclockwise Turn clockwise to decrease to increase... -
Page 9: Lighting And Operating Instructions
FSUV20/30 Vent Free Gas Heater Lighting and Operating Instructions FOR YOUR SAFETY READ BEFORE LIGHTING WARNING:If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This heater has a pilot which must be lit •... -
Page 10: Troubleshooting
FSUV20/30 Vent Free Gas Heater Troubleshooting START CHECK • Supply Line Hooked up Gas Supply On • Shutoff Valve Open • Lockout has engaged. Wait 60 seconds and try again. • Piezo not tight enough for good ground. Pilot Lights with •... -
Page 11: Maintenance
FSUV20/30 Vent Free Gas Heater Maintenance Keep the control compartment, logs and burner area To obtain proper operation, it is imperative that the pilot surrounding the logs clean by vacuuming or brushing at and burner's flame characteristics are steady, not lifting least twice a year. - Page 12 FSUV20/30 Vent Free Gas Heater FSUV30 FSUV20 14a,b ��� f i r e - p a r t s . c o m 11a,b CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice.
-
Page 13: Replacement Parts
FSUV20/30 Vent Free Gas Heater FSUV20/30 (continued) Ref. Description FSUV20 FSUV30 Speed Control Knob 51882 51882 Pilot Tubing w/Fitting 10000150 10000150 11a. Pilot Assy. - Natural 55464 55464 11b. Pilot Assy. - Propane 55465 55465 Ignitor Piezzo 20000062 20000062 Cable Ignitor... -
Page 14: Fan Kits
FSUV20/30 Vent Free Gas Heater Accessories Optional Fan Kit FK24 Stud WHEN INSTALLED, THE HEATER MUST BE ELECTRICALLY GROUNDED IN ACCOR- DANCE WITH LOCAL CODES OR, IN THE ABSENCE OF LOCAL CODES IWTH THE Thermal Sensor NATIONAL ANSI/NFPA NO. 70. -
Page 15: Warranty
FSUV20/30 Vent Free Gas Heater PRODUCT COVERED BY THIS WARRANTY All Vermont Castings gas stoves, gas inserts, and gas fireplaces, and all Majestic or Northern Flame brand gas fireplaces equipped with an Insta-Flame Ceramic Burner, or standard steel tube burner. - Page 16 f i r e - p a r t s . c o m CFM Specialty Home Products 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www.majesticproducts.com • www.vermontcastings.com...