Table of Contents
Advertisement
ENGINE OIL
The proper amount and grade of
engine oil will have a great impact
on the life of the engine. Checking
the oil daily and changing the oil as
listed in the maintenance schedule
is the most important maintenance
procedure there is for theengine.
CHECKING THE
ENGINE OIL
1. Make sure the Go Kart is on level
ground
2. Check engine oil level by remov-
ing and looking at the oil plug/
dipstick (1). Oil should be close to
the top of the serrated portion ofthe
dipstick.
3. If engine oil is low, add oil until
oil is at the top of the serrated por-
tion of the dipstick. Use the correct
grade of oil as listed in thismanual.
Do not over or
under fill engine with oil, this could
damage the engine.
CHANGING THE
ENGINE OIL
1. Make sure engine is warm be-
fore attempting to drain the oil. A
warm engine will help the oil drain
quicker.
2. Remove the oil fill plug (1)
3. Remove the drain bolt (2)located
on the back bottom of the engine.
4. Allow the oil to drain in an appro-
priate container.Note:Dispose of oil
at an oil reclaim facility.
5. Install the drain plug and fill
with the appropriate type of oil as
listed in this manual. This GoKart
requires 63qt. (.6L) of engineoil.
MAINTENANCE
6. Re- install fill cap, Start engine
and allow to run for a few minutes,
Re-check oil level and fill
accordingly.
New and used oil can be haz-
ardous
Children and pets can be
harmed by swallowing new or
used oil. Continuous contact
with used engine oil has been
found to cause skin cancer in
laboratory animals
Always keep new or used oil
away from children and pets.
2
26
WARNING
!
1
Correct Oil
Level
Advertisement
Table of Contents
