Related Manuals for Curtis TCC1
Summary of Contents for Curtis TCC1
- Page 1 USER GUIDE Liquid Concentrate Iced Tea/Coffee Dispensers READ AND SAVE THESE INSTRUCTIONS NOTICE TO INSTALLER: Please leave this booklet with the machine.
-
Page 2: Table Of Contents
..........................II28 .....................II29 ............................OI43 ..............................CI25 ..............................................................................................................Contact Information Wilbur Curtis Co., Inc. 6913 Acco Street | Montebello, CA 90640 US Phone: 323-837-2300 | Toll Free: 800-421-6150 Email: csrassistance@wilburcurtis.com | Web: www.wilburcurtis.com . - 4:00 . PT Email: techsupport@wilburcurtis.com... -
Page 3: Fs60
20 - 90 psi 1.0 gpm 24.63” 9.38” 17.88” 21.0 lbs 6.2 cu ft 46.0 lbs 20 - 90 psi 1.0 gpm 28.13” 14.25” 13.88” 22.0 lbs 6.2 cu ft 47.0 lbs 20 - 90 psi 1.0 gpm TCC1[C]/2/3, KEY FEATURES/SPECS/SYSTEM REQUIREMENTS 030218NC... -
Page 4: Is2
INSTRUCTIONS could result in personal injury or void the warranty. • This appliance is designed for commercial use. Any service other than cleaning and preventive maintenance should be performed by an authorized Wilbur Curtis service technician. • serviceable parts inside. - Page 5 IMPORTANT SAFEGUARDS CE Requirements • This appliance must be installed in locations where it can be overseen by trained personnel. • • • • This appliance must not be cleaned by water jet. • instruction concerning use of the appliance in a safe way and if they understand the hazards involved. •...
-
Page 6: Ii28
INSTALLATION INSTRUCTIONS II28 WARNING: NOTICE: SPECIFICATIONS IMPORTANT: Installation Instructions Installation Requirements • • SPECIFICATIONS... -
Page 7: Ii29
INSTALLATION INSTRUCTIONS II29 Installation Leveling Position the unit on a level counter top capable of supporting its operating weight. See the SPECIFICATIONS section. Style varies Back of unit Connect the Water Supply style varies Valve knob Make sure that the water supply valve on the back of in OFF position the unit is in the OFF position. -
Page 8: Oi43
WARNING - DO NOT refrigerate unused tea overnight for later consumption. Never hold dispensed tea for more than eight hours at room temperature. Discard any unused tea after eight hours. NOTICE - Curtis strongly recommends that the water supply valve, behind the unit, be turned off during non-business hours. - Page 9 OPERATING INSTRUCTIONS OI43 Changing/Attaching the Liquid Concentrate Bag (continued) Place the new tea/coffee On units equipped with a On units with a QCD concentrate bag on the Scholle type connector, connector, place the QCD counter next to the TCC place the connector over the next to the spout, then dispenser.
- Page 10 OPERATING INSTRUCTIONS OI43 Mixing Valve Adjustment of the drink, the mixing valve changes the water to concentrate ratio. This valve is very sensitive. Only slight rotation of the mixing rod is needed to change the ratio (1/16th to 1/8th of a turn). The factory setting is approximately 7:1 ratio, which will result in a 5 to 8 percent brix when sweet tea concentrate is used.
- Page 11 OPERATING INSTRUCTIONS OI43 Setting the Pressure Regulator NOTICE - Do not exceed 25 psi (static). Equipment failure or leakage will result. IMPORTANT - is properly set, then adjust the taste/brix level using the Mixing Valve Adjustment instructions. The purpose of the regulator is to provide uniform water pressure, so that the mixing valve can produce a stable and uniform blend of concentrate and water, and also to protect the hydraulics of the dispensing unit from excessive line pressure.
- Page 12 CLEANING INSTRUCTIONS CI25 NOTICE - Do not use cleaning liquids, compounds or powders containing chlorine (bleach) or corrosives. USE OF THESE PRODUCTS WILL VOID THE WARRANTY. Do not immerse the unit in water or any other liquid. Daily Cleaning Prepare a mild cleaning solution of dish washing detergent and warm water. Wipe any spills, dust or debris from the exterior surfaces, with a damp cloth.
-
Page 13: Ci25
CLEANING INSTRUCTIONS CI25 Weekly Cleaning and Sanitizing (cont.) with clean hot water (no cleaning solution) and open the faucet and dispense at least one gallon of the Hot rinse hot water or until all the cleaning solution has been water replace the cap. - Page 14 CLEANING INSTRUCTIONS CI25 Cleaning The Strainer - Monthly or As Needed Turn off the water supply valve on the back of the unit. Open one of the dispensing faucets to relieve pressure in the tubing system. Valve Tilt the dispenser on its side. housing Locate the strainer cap, located on the bottom of the water supply valve.
- Page 15 12.88 in [1.9 cm] [22.5 cm] [32.7 cm] TCC2 24.63 in [62.5 cm] 17.88 in [45.4 cm] 8.38 in [21.0 cm] 9.38 in [23.8 cm] 0.75 in 8.88 in 12.88 in [1.9 cm] [22.5 cm] [32.7 cm] TCC1[C]/2/3, ROUGH-IN DRAWING 022217NC...
- Page 16 ROUGH-IN DRAWINGS RD62 TCC3 9.38 in 14.25 in [23.8 cm] [36.6 cm] 28.13 in 13.88 in [71.4 cm] [35.2 cm] 8.50 in [21.6 cm] 0.75 in 8.88 in [22.5 cm] [1.9 cm] TCC1[C]/2/3, ROUGH-IN DRAWING 030218NC...
- Page 17 WC-5683-101 (OPTIONAL) WC-38471 1,3,4 LABEL, FRONT TCO ICED TEA GENERIC LABEL, FRONT TCOC ICED COFFEE WC-38472 2 GENERIC 1 TCC1, 2 TCC1C, 3 TCC2, 4 TCC3 Recommended Parts to Stock ITEM # PART # DESCRIPTION LID, SOLID/BREW-THRU (OPTIONAL USES) WC-5683 TCO’S...
- Page 18 ILLUSTRATED PARTS/RECOMMENDED PARTS IP108 TCC1[C] Mixing/Dispensing System - Exploded View TCC1[C]/2/3, ILLUSTRATED PARTS/RECOMMENDED PARTS 030218NC...
- Page 19 ILLUSTRATED PARTS/RECOMMENDED PARTS IP108 TCC2 Mixing/Dispensing System - Exploded View TCC1[C]/2/3, ILLUSTRATED PARTS/RECOMMENDED PARTS 030218NC...
- Page 20 ILLUSTRATED PARTS/RECOMMENDED PARTS IP108 TCC3 Mixing/Dispensing System - Exploded View TCC1[C]/2/3, ILLUSTRATED PARTS/RECOMMENDED PARTS 030218NC...
- Page 21 COFFEE WC-2219 3,4 Y- FITTING, BARBED 1/4X1/4X1/4 WHITE TUBING, .25” ID X .50” OD BRAIDED SILICONE 60 WC-53113 DUROMETER 1 TCC1, 2 TCC1C 3 TCC2 4 TCC3 * OPTIONAL Recommended Parts to Stock ITEM # PART # DESCRIPTION ITEM #...
- Page 22 TROUBLESHOOTING GUIDE TG33 Troubleshooting Guidelines Nothing Comes Out of the Faucet both Only Water Flows from the Faucet, Not Tea/Coffee Tea/Coffee is Weak See Mixing Valve Adjustment in the OPERATING INSTRUCTIONS Tea/Coffee Coming from the Faucet is Foamy or Bubbly Faucet Drips Constantly CLEANING INSTRUCTIONS...
- Page 23 Return Merchandise Authorization (RMA): All returned equipment must be properly re-packaged in the original carton and received by Curtis within 45 days following the issuance of a RMA. NO UNITS OR PARTS WILL BE ACCEPTED WITHOUT A RETURN MERCHANDISE AUTHORIZATION (RMA).