Table Of Contents - Heatilator CRAVE4836-C Installation Manual

Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Note: The term "recommend" or "recommended" does not indicate a requirement. It is a best practice suggested by
Hearth & Home Technologies®.
 Installation Standard Work Checklist . . . . . . . . . . . . . . . . . . . . 3
1 Product Specific and Important Safety Information
A. Appliance Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. Glass Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
C. BTU Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 4
E. Non-Combustible Materials Specification. . . . . . . . . . . . . . 5
F. Combustible Materials Specification . . . . . . . . . . . . . . . . . 5
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
H. California . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
I. Requirements for the Commonwealth of Massachusetts . . 6
2 Getting Started
A. Design and Installation Considerations . . . . . . . . . . . . . . . 7
B. Good Faith Wall Surface . . . . . . . . . . . . . . . . . . . . . . . . . . 8
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . 10
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . 10
3 Framing and Clearances
A. Appliance/Decorative Barrier Front Dimension Diagrams 11
B. Appliance Location and Clearances to Combustibles . . . 18

C. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 28
D. Floor Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

E. Vinyl Flooring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
4 Termination Location and Vent Information
A. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
B. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 30
C. Vent Terminal Clearances . . . . . . . . . . . . . . . . . . . . . . . . 32
D. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
E. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
5 Vent Clearances and Vent Framing
A. Vent Clearances to Combustibles . . . . . . . . . . . . . . . . . . 42
B. Wall Penetration Framing/Firestops . . . . . . . . . . . . . . . . . 43
C. Ceiling Firestop/Floor Penetration Framing . . . . . . . . . . . 44
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 44
6 Appliance Preparation
A. Top Standoff Preparation . . . . . . . . . . . . . . . . . . . . . . . . . 45
B. Prepare For Heat Management . . . . . . . . . . . . . . . . . . . . 46
C. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 47
D. Installing Non-Combustible Facing Material . . . . . . . . . . 48
2 Heatilator • CRAVE4836-C/ST-C, CRAVE6048-C/ST-C, CRAVE7260-C/ST-C, CRAVE8472-C/ST-C Installation Manual • 2601-980 Rev. N • 11/21

Table of Contents

7 Venting
A. Assemble Vent Sections (DVP Pipe Only) . . . . . . . . . . . 49
B. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 51
C. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 51
D. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 52
E. Vertical Termination Requirements . . . . . . . . . . . . . . . . . . 53
F. Horizontal Termination Requirements . . . . . . . . . . . . . . . 54
8 Electrical Information
A. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
B. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
9 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
C. Gas Service Access . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
D. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
E. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 62
F. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
10 Finishing
A. Facing Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
B. Drywall Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
C. Decorative Barrier Fronts . . . . . . . . . . . . . . . . . . . . . . . . . 68
D. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 73
11 Appliance Setup
A. Fixed Glass Assembly Removal and Replacement . . . . . 76
B. Remove the Shipping Materials/Install Bottom
Glass Shield . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
C. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
D. Install Glass Refractory (Optional) . . . . . . . . . . . . . . . . . . 77
E. Install Media . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
F. Install Log Set (Optional) . . . . . . . . . . . . . . . . . . . . . . . . . 77
G. IntelliFire Touch
H. Install Decorative Barrier Front. . . . . . . . . . . . . . . . . . . . . 77
12 Reference Materials
A. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 78
B. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
 = Contains updated information.
Control System Setup . . . . . . . . . . . . . . 77
®
