Consumer Assembly And Installation; Steering Column Assembly - Yerf-Dog Retriever 4x2 Owner's Manual

CONSUMER ASSEMBLY AND INSTALLATION

Please carefully follow the following YERF-DOG CUV Retriever assembly instructions.
If you prefer, we can arrange for an independent,local service center to assemble your Retriever for
you at a minimal assembly cost.
Precise manufacturing, assembly and quality care has prepared this Retriever vehicle for use. Before
operator use can begin, the following assembly and installation sections in this manual require your
careful attention to correctly complete the assembly of this Retriever vehicle for years of safe and
properly performing operation.
NOTE: While assembling and installing the components
in each of the following sections, do not tighten
the bolts or nuts until all components of the section
are assembled.
Approximate assembly time for the following assembly and
installation sections are:
• Steering Wheel assembly . . . . . . . . . . . .
• Front Bumper attachment . . . . . . . . . . . .
• Brush Guard assembly and attachment . . . . . 20 minutes
• Seat Belt attachment . . . . . . . . . . . . . .
• Lumbar Seat Pad assembly and attachment . .
• Cargo Bed assembly and attachment . . . . . .
Please feel free to contact us should any questions arise during or after the assembly process.
By phone: (toll free)
1-888-926-6554
Monday - Friday,
8am - 12pm, 1pm - 5pm CST

STEERING COLUMN ASSEMBLY

STEERING COLUMN HARDWARE
06887 (2) 3/8"x1" Bolts
06889 (2) 3/8" Washers
06888 (2) 3/8" Nuts
For shipping purposes, the steering column is
disconnected from the dash mount and folded down
during shipping.
To reconnect the steering column, lift it up and align
the mounting tab on the steering column (rotate
around shaft if necessary) with the grove in the
steering column mount located in the dash panel.
Insert into grove and align bottom hole, insert Bolts
(#30), Washers (#31) and nuts (#32) into both top
and bottom holes and tighten.
Yerf-Dog Retriever CUV Owners Manual
Model# 34851 • Revision C - 2/05
SOME ASSEMBLY REQUIRED
By Email:
customerservice@yerf-dog.com
Replies provided Monday - Friday,
8am - 12pm, 1pm - 5pm CST
www.yerf-dog.com
For questions in USA, 888-926-6554
Verify proper tire pressure.
Prior to running this vehicle, it is
important that you verify the proper
tire pressure. Both front and rear tires
for this vehicle should not exceed 5
PSI. Failure to run without the proper
tire pressure could result in serious
injury or death.
5 minutes
8 minutes
15 minutes
15 minutes
1 hour
By U.S. Mail:
Flexible Flyer Wheel Goods
100 Tubb Ave.
West Point, MS 39773
The steering column
hardware is located
in the seatbelt
hardware bag.
mounting
tab
steering
column
mount
Page 31
Manual# 06367