Spark Plug; Drive Chain; Suspension; Cleaning The Vehicle - Yerf-Dog Retriever 4x2 Owner's Manual

SPARK PLUG

A fouled (black deposit on the spark plug electrodes) and/or improper gap size may result in spark
plug misfire. The proper gap for the electrode is .024 – .028 inch (0.6 – 0.7 mm). The standard type
of spark plug is NGK C7HSA or NGK CR7HSA (FFA part number 04801).

DRIVE CHAIN

After periods of extended operation, the drive
chain will stretch and loosen. The normal chain
slack should be 1/8". Check the drive chain and
adjust if necessary before each use. Keep the
drive chain properly lubricated.
The slack can be adjusted by the chain adjuster.
(Figure 18) Loosen the top roller bolt and adjust
the slack to the proper setting. After adjusting the
chain, don't forget to tighten the nuts.

SUSPENSION

FRONT SUSPENSION
The front right and left side suspension can be
adjusted to various pre-load positions so they can
be matched to load and driving conditions.
Always be sure to adjust both front left and front
right shock absorbers to the same position. Failure
to do so could result in severe injury or death.
The front right and left side suspension can be
adjusted to various pre-load positions so they can
be matched to load and driving conditions.
Retriever VEHICLE CLEANING
Keeping your Retriever vehicle clean will not only improve its appearance but it can also extend the
life of various components. With a few precautions, your Retriever vehicle can be cleaned much like
an automobile.
Washing
Do not use a high-pressure type car wash system. Many expensive repair bills can result from the
damage caused by the high-pressure wash to wheel bearings, transmission seals, body panels, brakes
and warning labels.
The best and safest way to clean your Retriever vehicle is with a garden hose and a pail of mild soap
and water (NOTE: Do not use ammonia based products). Use a professional type washing mitten,
cleaning the upper body first and the lower parts last. Rinse with water frequently and dry with a
chamois to prevent water spots. NOTE: If warning labels are damaged, contact your Servicing Center
for replacement.
Waxing
Your Retriever vehicle can be waxed with any non-abrasive paste wax. Avoid the use of harsh cleaners
since they can scratch the body finish.
Page 30
Manual# 06367
www.yerf-dog.com
For questions in USA, 888-926-6554
Figure 18 Chain Adjuster
Figure 19 Front Suspension Adjuster Ring
Yerf-Dog Retriever CUV Owners Manual
Model# 34851 • Revision C - 2/05