Stihl HTA 135 Instruction Manual
  1. Manuals
  2. Brands
  3. Stihl Manuals
  4. Trimmer
  5. HTA 135
  6. Instruction manual

Stihl HTA 135 Instruction Manual

Hide thumbs Also See for HTA 135:
Table of Contents

Advertisement

Quick Links

Download this manual
STIHL HTA 135
Instruction Manual

Advertisement

Table of Contents
loading

Related Manuals for Stihl HTA 135

Summary of Contents for Stihl HTA 135

  • Page 1 STIHL HTA 135 Instruction Manual...

  • Page 3: Table Of Contents

    Checking Pole Pruner and Battery....21 3.1 STIHL HTA 135 Pole Pruner and Battery ... . 3 10.1 Checking the Chain Sprocket .

  • Page 4: Introduction

    STIHL expressly commit themselves to a sustainable and 19.4 STIHL AP battery ........31 responsible handling of natural resources.

  • Page 5: Symbols Used With Warnings In The Text

    3 Overview – Safety notices and precautions for STIHL AP battery 3 Overview – User manual for STIHL AL 101, 300, 500 chargers – Safety information for STIHL batteries and products with built-in battery: www.stihl.com/safety-data-sheets STIHL HTA 135 Pole Pruner and Battery...

  • Page 6: Icons

    English 3 Overview 2 Shaft 17 Battery compartment The shaft connects all components. The battery compartment holds the battery. 3 Clamp nut 18 Cover Serves to adjust the length of shaft. The cover is the placeholder for a Smart Connector 2 A. 4 Chain sprocket 19 Control handle The chain sprocket drives the saw chain.

  • Page 7: Safety Precautions

    English 4 Safety Precautions This icon shows the direction of rotation of the Read, understand and keep the User Manual. saw chain. Rotate in this direction to increase the saw chain tension Wear safety glasses, hearing protection and a 1 LED lights up red. The battery is too warm or hard hat.

  • Page 8: Intended Use

    ► If you pass the pole pruner or battery on to another Intended Use person: Always give them the instruction manual. The STIHL HTA 135 pole pruner is used to delimb tall trees ► Make sure the user meets the following requirements: or prune the branches of tall trees.

  • Page 9: Work Area And Surroundings

    English 4 Safety Precautions ► Wear close-fitting safety glasses. Suitable ► Wear sturdy, closed-toed footwear with safety glasses are tested in accordance with high-grip soles. EN 166 or national regulations and available commercially with the corresponding marking. ￭ Noise is generated during operation. Noise can damage your hearing.

  • Page 10: Safe Condition

    – The guide bar and saw chain are properly mounted. ► Do not throw the battery into a fire. – The saw chain is properly tensioned. – Only original STIHL accessories designed for this pole ► Use and store the battery at temperatures pruner model are fitted.
  • Page 11 ► Never insert objects in the openings of the pole pruner. ► Replace worn or damaged labels. WARNING ► If you have any doubts, be sure to consult a STIHL ￭ If components do not comply with safety requirements, dealer.

  • Page 12: Working

    This may result in serious injury to people and damage to property. Working ► Stop working, remove the battery and consult a STIHL servicing dealer. 4.7.1 Sawing ￭ Vibrations may occur while using the pole pruner.
  • Page 13 English 4 Safety Precautions ￭ If the moving saw chain hits a hard object, sparks may ► Maintain a clearance of 15 meters from live occur. Sparks can cause fires in a flammable cables. environment. Persons may be seriously or fatally injured and property may be damaged.

  • Page 14: Reactive Forces

    English 4 Safety Precautions Reactive Forces ► Use the working techniques described in this instruction manual. 4.8.1 Kickback ► Do not cut with the upper quadrant of the bar nose. ► Always cut with a properly sharpened and tensioned saw chain. ►...

  • Page 15: Transporting

    English 4 Safety Precautions 4.8.3 Pushback ► Remove the battery. ► Fit the chain scabbard so that it completely covers the guide bar. ► Secure the pole pruner with lashing straps or a net to prevent it from turning over and moving. 4.9.2 Battery WARNING...

  • Page 16: Cleaning, Maintenance And Repair

    ► If the pole pruner or the battery require servicing or ￭ The battery is not protected against all ambient repairs: Contact your STIHL dealer for assistance. conditions. The battery may be damaged if it is exposed to certain ambient conditions.

  • Page 17: Preparing Pole Pruner For Operation

    – Pole Pruner, @ 4.6.1. ► Recharge the battery fully as described in the instruction manual for the STIHL AL 101, 300, 500 chargers. – Guide bar, @ 4.6.2. – Saw chain, @ 4.6.3. Displaying State of Charge –...

  • Page 18: Assembling The Pole Pruner

    English 7 Assembling the Pole Pruner 7 Assembling the Pole Pruner Assembling the Pole Pruner ► Switch off the pole pruner and remove the battery. ► If you cannot push the transmission (3) onto the shaft (2) up to mark b: ►...

  • Page 19: Attaching The Clip

    English 7 Assembling the Pole Pruner ► Remove the protective cap (11). ► Press clip (1) together and place on the handle hose (2). ► Turn the shaft (2) and press it in the direction of the control It is not necessary to remove the clip again. handle (12) until the distance c = 2 cm.

  • Page 20: Mounting And Removing The Bar And Chain

    English 7 Assembling the Pole Pruner Mounting and Removing the Bar and Chain 7.4.1 Mounting the Guide Bar and Saw Chain The guide bar and saw chain combinations that can be used with the chain sprocket are listed in the specifications, @ 20.1.

  • Page 21: Tensioning The Saw Chain

    English 7 Assembling the Pole Pruner Filling Up with Saw Chain Oil 7.4.2 Removing the Guide Bar and Saw Chain The saw chain oil lubricates and cools the rotating chain. ► Switch off the pole pruner and remove the battery. ►...

  • Page 22: Removing And Fitting The Battery

    ► Now try again to close the oil tank. ► If the oil tank still cannot be closed properly: Do not use your pole pruner and contact a STIHL dealer for assistance. The pole pruner is not in a safe condition.

  • Page 23: Switching Pole Pruning On And Off

    ► Push the release slide (2) in the direction of the loop handle with your thumb and hold it there. LED is lit. ► Use a STIHL gauge to check the wear marks on the chain sprocket. ► Press the trigger (3) with your index finger and keep depressed.

  • Page 24: Checking The Saw Chain

    – The measured guide bar groove depth is less than assistance. specified minimum depth, @ 19.3. ► Use a STIHL filing gauge to check that the filing angle is – The guide bar groove is pinched or splayed. 30° on all cutters. The STIHL filing gauge must match the ►...

  • Page 25: Checking Chain Lubrication

    ► Release the trigger. The saw chain stops running after about 1 second. ► If the saw chain continues to run after about 1 second: Remove the battery and contact your STIHL dealer for assistance. The pole pruner has a malfunction.

  • Page 26: Fitting And Adjusting The Shoulder Strap

    English 11 Using the Pole Pruner 11.4 Holding and Controlling the Pole Pruner ► Press clip (1) together and move on the handle hose (2), ensuring that the following conditions are met: ► Connect the carrying ring (2) to the carabiner (1). –...

  • Page 27: Limbing

    English 12 After Finishing Work 11.5 Limbing Cutting thick branches Cross-cut ► Perform a relieving cut (2) at cutting point (2) at a distance a = 20 cm from the final cross cut (1). ► Position the stop (1) against the branch. ►...

  • Page 28: Transporting

    The battery is classified as UN 3480 (lithium ion ► Switch off the pole pruner and remove the battery. batteries) and has been tested pursuant to UN Manual Tests ► Clean the pole pruner with a damp cloth or STIHL resin and Criteria Part III, Subsection 38.3. solvent.

  • Page 29: Cleaning The Guide Bar And Saw Chain

    16.2 Deburring the Guide Bar A burr can build up on the outer edge of the guide bar. ► Remove burr with a flat file or a STIHL guide bar dressing tool. ► If you have any queries: Contact your STIHL servicing dealer.

  • Page 30: Repairing

    ► Wear work gloves made of durable material. ► File down the depth gauges with a flat file so that they are level with the STIHL filing gauge and parallel to the service mark. The STIHL filing gauge must match the chain pitch.

  • Page 31: Troubleshooting

    There is an electrical fault. ► Remove battery and reinsert it. ► Switch on the pole pruner. Runtime of pole The battery is not fully ► Fully charge battery as described in the User pruner is too short. charged. Manual for chargers STIHL AL 101, 300, 500. 0458-698-0121-A...
  • Page 32 Insufficient saw chain oil in Fill up with saw chain oil. the oil tank. The chain lubrication Do not use your pole pruner and contact your STIHL system is supplying servicing dealer for assistance. insufficient saw chain oil. The saw chain is over- Tension the saw chain as specified.

  • Page 33: Specifications

    K-value (uncertainty) for sound pressure levels is 2 dB(A). K-value for sound power levels is 2 dB(A). The K-value for vibration levels is 2 m/s². 19.1 STIHL HTA 135 pole pruner STIHL recommends wearing ear defenders. – Permitted batteries: – Sound pressure level L measured according to –...

  • Page 34: Reach

    English 19 Specifications 19.6 REACH REACH is an EC regulation and stands for the Registration, Evaluation, Authorisation and Restriction of Chemical substances. For information on compliance with the REACH regulation see www.stihl.com/reach. 0458-698-0121-A...

  • Page 35: Bar And Chain Combinations

    English 20 Bar and Chain Combinations 20 Bar and Chain Combinations 20.1 STIHL HTA 135 pole pruner Pitch Drive link Length Guide bar Number of Number of drive Saw chain gauge/groove teeth, sprocket links width nose 25 cm Rollomatic E / Light 04...

  • Page 36: Combinations Of Carrying Systems

    The pole pruner may only be used in combination with a carrying system. Approved combinations are listed in this User Manual: Shoulder strap Full harness STIHL AR battery together with the support cushion Battery belt with strap and attached “AP belt bag with connecting cable” together with the support cushion Battery belt with attached “AP belt bag with...

  • Page 37: Spare Parts And Accessories

    STIHL accessories. 2011/65/EU, 2006/42/EC, and 2014/30/EU and has been developed and manufactured in compliance with the STIHL recommends the use of original STIHL spare parts following standards in the versions valid on the date of and accessories.

  • Page 38: General Power Tool Safety Warnings

    The safety precautions and warnings on avoiding an electric shock given under “Electrical Safety” do not apply to STIHL c) Keep electric power tools away from rain or moisture. cordless products.

  • Page 39: Electric Power Tool Use And Care

    English 25 General Power Tool Safety Warnings c) Prevent unintentional starting. Check that the electric d) Unused electric power tools must be stored out of the power tool is switched off before you connect it to the reach of children. Do not let anyone use the electric power mains, pick it up or carry it.

  • Page 40: Service

    English 25 General Power Tool Safety Warnings d) Under abusive conditions, liquid may be ejected from the battery; avoid contact. If contact accidentally occurs, flush with water. If liquid contacts eyes, additionally seek medical help. Liquid ejected from the battery may cause irritation or burns.
  • Page 41 English 25 General Power Tool Safety Warnings 0458-698-0121-A...
  • Page 42 English 25 General Power Tool Safety Warnings 0458-698-0121-A...
  • Page 44 0458-698-0121-A englisch www.stihl.com *04586980121A* 0458-698-0121-A...

Table of Contents