Char-Broil COMMERCIAL Series Quick Start Manual page 11

4. Brush soapy
solution onto
following
connections:
5. "If growing" bubbles appear,
there is a leak. Close LP tank
valve immediately and retighten
connections. If leaks cannot be
stopped "do not try to repair."
Call for replacement parts. Order new parts by giving the
serial, model number and name of items needed to the Grill
Service Center at 1­800­241­7548 U.S. or 1­800­387­6057
CAN.
6. Always close LP tank valve after performing leak test by
turning hand wheel clockwise.
Safety Tips
Before opening LP tank valve, check the coupling nut for
tightness.
When grill is not in use, turn off all control knobs and LP tank
valve.
Never move grill while in operation or still hot.
When moving the grill push it forward, do not pull from
behind.
Use long­handled barbecue utensils to avoid burns and
splatters.
Do not remove grease receptacle or tray until grill has
completely cooled.
If you notice grease or other hot material dripping from grill
onto valve, hose or regulator turn off gas supply at once.
Determine the cause, correct, clean and inspect valve, hose
and regulator before continuing. Perform a leak test.
The regulator may make a humming or whistling noise
during operation. This will not affect safety or use of grill.
If you have a grill problem see the "Troubleshooting
Section".
WARNING WARNING
WARNING WARNING WARNING
For Safe Use Of Your Grill:
• Do not let children operate or play near grill.
• Keep grill area clear and free from materials that burn.
• Do not block holes in bottom or back of grill.
• Check burner flames regularly.
• Use grill only in well­ventilated space. NEVER use in
enclosed space such as carport, garage, porch, covered
patio, or under a surface that can catch fire.
• Use grill at least 3 ft. from any wall or surface. Maintain 10 ft.
clearance to objects that can catch fire or sources of ignition
such as pilot lights on water heaters, live electrical appliances,
etc.
• Do not use charcoal, briquets or lava rock in this grill.
Apartment Dwellers:
•
Check with management to learn the requirements and fire
codes for using an LP Gas Grill in an apartment com­
plex. If allowed use outside on the ground floor with a
three (3) foot clearance from walls or rails. Do not use on
or under balconies made of wood.
• NEVER attempt to light burner with lid closed. A
buildup of non­ignited gas inside a closed grill is
hazardous.
• Never operate grill with LP tank out of correct position.
• Always close LP tank valve and remove coupling nut
before moving LP tank from specified operating
position.
CA CA
CAUTION CA CA
• Putting out grease fires by closing the lid is not
possible. Grills are well ventilated for safety reasons.
• Do not use water on a grease fire. Personal injury may
result. If a grease fire develops turn knobs and LP tank
off.
• Do not leave grill unattended while preheating or
burning off on high. If grill has not been regularly
cleaned a grease fire can occur that may damage the
product.
UTION UTION
UTION UTION
466231103 • 11