Bosch Evolution HDS7052U Conversion Manual page 10

Conversion
Test Broil Burner
Test Ignition
Test Flame
Adjust Broil Flame (if
necessary)
Test Bake Burner
Test Ignition
Test Flame
Adjust Bake Flame (if
necessary)
English 8
Set cooking mode to Hi Broil. The burner will ignite after 30-75 seconds.
Verify that flame characteristics are as shown in "Checking Flame Characteristics"
on page 7. If flame characteristics are not consistent with those in the graphic
above, adjust the flame as describerd below. Otherwise, continue to "Test Bake
Burner" .
Adjust the air shutter to alter the flame characteristice. The air shutter is located
on the back end of the broil burner.
1. Loosen screw and turn shutter. Close the shutter if the flame is lifting or blow-
ing or not carrying over; Open the shutter if it is too yellow. (See Figure 8).
Tighten screw.
More Open:
Less Yellow Flame
More Closed:
Less Blue Flame
More Carryover
Less Lifting or Blowing
Set the oven to bake at 350° F. After 30-75 seconds, the burner will ignite. The
burner will stay lit until the 350° F is reached and then shut off. From this point
forward, the burner will cycle on and off to maintain the temperature.
Verify that flame characteristics are as shown in "Checking Flame Characteristics"
on page 7. If flame characteristics are not consistent with those in the graphic
above, adjust flame as described below.
Adjust the air shutter to alter the flame characteristice. The oven burner air shutter
is located to the left of the oven regulator. Reach it through the access hole in the
interior back panel of the warming drawer
1. Loosen screw and turn shutter. Close the shutter if the flame is lifting or blow-
ing or not carrying over; Open the shutter if it is too yellow. (See Figure 8).
Tighten screw.
Shutter
More Open:
Less Yellow Flame
Screw
Air
Shutter
Figure 2: Broil Burner Air Shutter
Less Open:
Less Blue Flame
More Carryover
Less Lifting or Blowing
Figure 2: Broil Burner Air Shutter