Table of Contents
Advertisement
D I S S O L U T I O N
Depending on the input water pressure you may have to wait several minutes to verify the water does
not rise above the Mid-Level Sensor. Fill in the Dry Acid Batch Production Record Form (GranuFlo® Form
1, page 32,or Citrasate Dry Form 2, page 34 ).
B
CAUTION!
E CERTAIN THE SAME
U
CAUTION!
SING EYE PROTECTION
. I
MINUTES
F CONTACT WITH SKIN
P
FOR FURTHER
ERSONAL
.
USED
D
WARNING!
O NOT USE
IMPORTANT THAT THE ENTIRE CONTENTS OF EACH
D
U
. B
ISSOLUTION
NIT
WARNING!
IN ABSENCE OF SIGNIFICANT CLUMPING
CONCENTRATE INTO THE MIXER
.
INHALATION INJURY
G
F
® D
NOTE:
RANU
LO
P
RODUCT CONTAINS
GRANULES O
PERATION
NOTE: I
NPUT WATER
MAXIMUM
INPUT WATER PRESSURE IS
Remove the Dry Acid Dissolution Unit Small Access Lid
9.
and add granules as seen in the adjacent picture. This
minimizes the amount of particulates launched into
the air while adding granules to the tank. If clumping
in Dry Acid Product is present, then the Large Access
Lid can be used to load the Tank. However, If you have
large sized clumps, then it would be best to break the
clumps into a smaller size before adding granules into
the tank. Large clumps have the ability to break the
Mid-Level Sensor. (See Appendix A for Dry Acid Mixing
information, page 43).
After adding all bags of Dry Acid, reinstall Large and
10.
Small Access Lids, then press the Dissoluton START
button. The Dry Acid Dissolution Unit will proceed to
the MIX Operation.
During the MIX Operation, the solution is mixed for a period of thirty-five (35)
11.
minutes allowing the granules to dissolve. The Dry Acid Dissolution Unit will
then automatically step to the DEAERATION Operation.
The DEAERATION Operation is two (2) minutes during which the entrapped air
12.
is allowed to separate out of the solution. Upon completion, the Dry Acid
Dissolution Unit will automatically step into the FINAL FILL Operation and the
Final Fill Light will illuminate.
P/N 460017 Rev. D
Continued
C Y C L E
C
N
ATALOG
UMBER IS ON ALL CASES
,
AND GLOVES IS RECOMMENDED
,
FLUSH WITH PLENTY OF SOAP AND WATER
P
E
ROTECTIVE
QUIPMENT OR EMERGENCY INSTRUCTIONS FOR THE DRY ACID PRODUCT BEING
C
D
A
ASE OF
RY
CID
C
E CERTAIN ALL BAGS PER
ASE HAVE BEEN ADDED
.
USE OF THE LARGE ACCESS LID WHEN POURING ACID CONCENTRATE MAY RESULT IN
A
P
RY
CID
RODUCT CONTAINS
4
. C
BAGS PER BOX
ONTENTS OF ALL SIX BOXES MUST BE POURED INTO THE TANK DURING THE
.
P
A
RESSURE DIRECTLY
FFECTS HOW FAST
60 PSI AND
.
. I
F CONTACT WITH EYES
. S
EE
C
ONCENTRATE THAT HAS BEEN OPENED OR TAMPERED WITH
C
D
A
C
ASE OF
RY
CID
ONCENTRATE IS EMPTIED INTO THE
.
,
ONLY USE THE SMALL ACCESS LID WHEN POURING ACID
3
C
BAGS PER BOX AND
ITRASATE
T
D
A
HE
RY
CID
½
A MINIMUM
GALLON PER
,
RINSE IMMEDIATELY FOR
M
S
D
S
ATERIAL
AFETY
ATA
HEET
® DRY
A
WITH
CETATE
D
U
ISSOLUTION
NIT WILL FILL
MINUTE FLOWRATE.
Small Access
15
(MSDS)
. I
T IS
D
A
RY
CID
D
A
RY
CID
ADD
. THE
15
Advertisement
Table of Contents
