Lighting The Smoker - Weber 41995 Owner's Manual

Lighting the Smoker Burner
WARNING: Check hose before each use of grill for
nicks, cracking, abrasions or cuts. If the hose is
found to be damaged in any way, do not use the
grill. Replace using only Weber
replacement hose Contact the Customer Service
Representative in your region using the contact
information sheet provided with your manual.
1) Open the grill lid.
Failure to open the lid while igniting the grill, or not
waiting 5 minutes to allow the gas to clear if the grill
does not light, may result in an explosive flare-up
which can cause serious bodily injury or death.
2) Open smoker box lid
3) Fill smoker with water soaked wood chunks or chips.
4) Make sure all burner control knobs are turned OFF.
(Push control knob down and turn clockwise to ensure
that it is in the OFF position.)
WARNING: The burner control knobs must be in the
OFF position before turning on the liquid propane
cylinder tank valve. If they are not in the OFF position,
when you turn on the LP cylinder valve, the "excess
gas flow control" feature will activate, limiting the flow
of gas from the LP cylinder. If this should occur, turn
OFF the LP cylinder valve and burner control knobs.
Then start over.
When the "excess gas flow control" feature is
activated, a small amount of gas is still flowing to the
burners. After turning OFF the cylinder and burner
control knobs, wait at least 5 minutes for the gas to
clear before attempting to light the grill. Failure to do
so may result in an explosive flare-up, which can
cause serious bodily injury or death.
1
2,3,9
6
4
7
Operating Instructions
® authorized
DANGER:
DANGER:
8
5
4
1
2,3,9
6
4
7
4
*The grill illustrated may have slight differences than the
model purchased.
5) Turn the cylinder on by turning the cylinder valve
counterclockwise.
WARNING: Do not lean over the open grill while
lighting.
6) Push smoker burner control knob down and turn to
START/HI.
7) Push and hold down the Igniter button until burner
ignites. You will hear the igniter sparking.
8) Check that the burner is lit by looking through the
cooking grate.
If the smoker burner does not light, turn the burner
control knob to OFF and wait 5 minutes to let the gas
clear before you try again or try to light with a match.
9) Close smoker cover after wood starts to smolder and
turn control knob to LOW.
To Extinguish
Push down and turn each burner control knob clockwise
to OFF position. Turn gas supply OFF at the source.
D-7
8
DANGER:
5