Page 2
A_ Do not use a flame to check 1 A_ Combustible materials should Weber ® gas barbecue. A_ Do not put a barbecue cover A_ Your Weber _ gas barbecue should be very hot. Keep young childre_ A_ You should exercise reasonz cooking...
Page 3
Cleaning ....................Assembly Instructions ....Gas Instructions ..................Leak Checking ..................Operating ............... ringMetho s ......iiii::i::::::::::!:!! Lighting ........Manual Lighting ........iiiiiiii Lighting the Side Burner ....iiiiiiiiiiiiiiii!iii!!i! !ii!ii Troubleshooting ............. Side Burner Troubleshooting ..............Mai ntenance ..................Replacing Main Burners...
Page 4
Customer service representative in your region using the contact information sheet provided with your manual. If Weber _ confirms the defect and approves the claim, Weber _ will elect to replace such parts without charge. If you are required to...
Page 5
_no local codes, y oumustconform to thelatest e c National FuelGasCode: A NSI • This Weber _ gas barbecue is desigr (piped in city) gas only. Do not use lic bottled gas. The valves, orifices and vehicle natural gas only.
Page 6
If burners go out during cooking, open lid, turn off burners and wait five minutes before relighting. Preheating - Your Weber _ gas barbecue is an energy- efficient appliance. It operates at an economical low B rate. To preheat: after lighting, close lid and turn all burners to h_gh (HH).
Place corregated from each side of the Cookbox under the Caster and Wheel Frame Assembly to level the frames for Frame Rail Assembly. /k CAUTION: Before proceeding to the next step check that frame rail (2) is on the side with the swing tables (3).
Page 16
® A_ ATTENTION! Only start these bolts. Do not tighten yet.
Ax ATTENTION! Completely remove both partially started bolts from top rear frame rail Ax ATTENTION! Reinstall both bolts through rear panel and into rear frame rail,...
Page 31
If they do not turn, This is a typical installation they are off. Proceed to the next step. If they do turn of a Weber® natural gas continue turning them clockwise until they stop, then they barbecue. Local codes may require different are off.
Page 32
pressure(I). S lide thecollar closed(2). If itdoesnot barbecue was dealer or store assembled. engage or lock,repeat p rocedure. Turn on gas supply. Gaswillnotflowunless thequickdisconnect is properly Check for leaks by wetting the connections with the soap engaged. and water solution and watching for bubbles. If bubbles form or if a bubble grows, there is a leak.
Page 33
Part required: PhillipS Screwdriver. SUMMIT_ S ILVER lithe screws need tobe removed from the control panel (3)before the control, panel is removed from the grill: I SUMMIT SILVER I SUMMIT ® GOLD...
Page 34
Note - All factory-made connections have been thoroughly checked for gas leaks. The burners have been flame- tested. As a safety precaution however, you should recheck all fittings for leaks before using your Weber° gas barbecue. Shipping and handling may loosen or damage a gas fitting.
Page 35
OPERATE THEGRILL Contact t heCustomerService Representative in your regionusing the contact i SUMMIT+ GOLD I informationsheetprovidedwithyour manual. When leak checks are complete, turn gas supply OFF at the source and rinse connections with water. Gas line to manifold connections. I SUMMIT _ SILVER...
If burners go out during cooking, turn off all burners Direct cooking is also necessary to sear meats, Searing and wait 5 minutes before relighting. creates that wonderfu! crisp, caramelized texture wher,e _WARNING: Check the bottom tray and catch pan for the food hits the gratei It also adds great co!or,and flavor to the entire surface.
Page 38
cook the food evenly on all sides, much like a convection weather and ittle orno wind, Allow more cooking time ovenl so there's no need to turn the food. on c01dor Windy daysl or at higher alt tudes: A !oWless Use the Indirect method for foods that require 25 minutes cooking time in extremely hot weather,...
*The grill illustrated may have slight differences than the the hose is found to be damaged in any way, do not model purchased. use the barbecue, Replace using only Weber ® authorized replacement hose, Contact the Customer Service Representative in your region Open the lid.
Page 40
SUMMIT ÷ GOLD which can cause serious bodily injury or death. Make sure all burner control knobs are turned OFE (Push each burner control knob down and turn clockwise to ensure they are in the off position.) Turn the gas supply valve on. Put match in the match holder and strike match.
Page 41
cause serious bodily injury Lighting only the side burner. 1) Open the side burner lid. Check that the side burner valve is turned OFE (Push each knob down and turn clockwise to ensure they are in the off position.), and all main burner control valves are OFF (push down and turn clockwise).
Page 42
Problem St_ighten fdel hose. f you can ght _he _eft buiner _ith a match, then check the Cros_ove_ ignition system. burners on high _ 10 to i 5 minutes for preheating. Clean the,r, oughl_ (Se SectiOn " .,leaning ) glean b_to_...
Page 43
iiiiii Problem iiiiiiii Side Burner does not light. iiiiiiiii Flame is low in HIGH pOsition. Push button ignition does not Does burn_ work. Side Burner maintenance 2) Venturi, should be in the OFF position. 3) 1/8 to Make sure wire is connected between igniter and electrode.
Page 44
for the correct air and gas mixture. The Correct flame The Webe_ gas barbecue burners have been factory set pattern is shownl Burnertube Tips occasionally flicker yellow Light blue Dark blue The burner tube air shutter is fitted with a stainless steel screen(1 ) to prevent spiders and other insects access...
Page 45
To remove contl le control paner, under ,,check f0r GaS LeakSi!' DisconneCt all ignition wires from the Ignition Module; , .] a = Yellow Tab with Black Wire a = Yellow Tab with Black Wire b = White Tab with Black Wire b = White Tab with Black Wire c = Solid White Wire c = Green Tab with Black Wire...
Page 47
Remove the Crossover 4_ tube. Pull the selected burner(s) tube(s) from manifold frame and replace with a new burner tube. Check proper assembly before fastening manifold in place. A_WARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the grill.