Advertisement
Component Testing Procedures
To avoid risk of electrical shock, personal injury or death; disconnect power to oven before servicing, unless
testing requires power.
Illustration
0060691
31939901-Broil
31940001-Bake
0300664
0042303
0301361
H
R
G
A A
308607
−LH
31715201
−RH
31715202
Opening
0306654
Mylar Overlay
32061901-B
Black and Stainless Steel
˙
32061902-C
˙
Bisque
32061903-W
˙
White
November 2001
!
Component
Broil burner
Verify gas is supplied.
Proper orifice installed for Natural or
LP.
Check for damage to screen ................
Norton ignitor
Test for voltage at terminals.................
Test for the amount of amperage in the
circuit ...................................................
(Ignitor may glow but not have
sufficient amperage to open valve).
Dual thermal valve
Disconnect wiring to valve.
Measure resistance on bake circuit......
Measure resistance on broil circuit.......
Pressure regulator
Verify gas pressure (W.C.P.).
If on LP service verify proper gas
supply conversion.
Shut off valve
Check to verify gas supply is turned
on.
Venturi
Shutter settings
Nominal ............................................
Tol. ± ................................................
ERC cooling blower
Verify supply voltage............................
Check continuity of terminals, and
verify terminals are not shorted to
chassis.................................................
Hinge
Carefully open the hinge fully, and
insert a wooden dowel or screwdriver
bit into opening.
Remove top and bottom screws
securing hinge.
Slide hinge top towards rear of unit
and guide hinge out through frame
opening or storage drawer.
Power cord 3-wire
Verify resistance of wires to terminals.
WARNING
Test Procedure
OVEN
CANCEL
TIMER
STOP
COOK
CLOCK
ON/OFF
TIME
TIME
3
Results
L.P. orifice wired to inlet tubing.
Replace if punctured or torn.
120 VAC
3.2 − 3.6 Amps If not replace.
Continuity, If not replace.
Continuity, If not replace.
!
WARNING
Do not attempt to open valve with
120 VAC.
6" Natural
10" LP/propane
.125" 1/8"
.031" 1/32"
120 VAC
Continuity
!
CAUTION
Do not place hands in hinge area when
oven door is removed. Hinge can snap
closed and pinch hands or fingers.
Continuity
Time/Temp
CLEAN
BROIL
BAKE
RT2310015 Rev. 0
MORE
LESS
Advertisement
