Door Replacement - Electrolux FGMO205KFA Service Manual

6. Secure the screws with washers firmly.
7. Check all of the switches operation. If any switch
has not activated with the door closed, loosen screw
and adjust the latch hook position.
After adjustment, check the following.
1. In and out play of door remains less than 0.5mm
when in the latched position. First check upper
position of latch hook, pushing and pulling upper
portion of door toward the oven face. Then check
lower portion of latch hook, pushing and pulling
lower portion of the door toward the oven face. Both
results (play in the door) should be less than 0.5mm.
2. The door sensing switch, and secondary interlock
switch interrupt the circuit before the door can be
opened.
3. Monitor switch contacts close when door is opened.
4. Re-install outer case and check for microwave
leakage around door with an approved microwave
survey meter. (Refer to Microwave Measurement
Procedure.)
Door
Switch Lever
Figure 4-6. Latch Switch Adjustments
Latch Heads
Door Sensing
Switch
Monitor Switch
Primary Interlock
Switch
Section 4 Component Teardown

Door Replacement

REMOVAL
1. Disconnect the power supply cord.
2. Push the open button and open the door slightly.
3. Insert a putty knife (thickness of about 0.5mm) into
the gap between the choke cover and door frame as
shown in Figure 4-7 to free engaging parts.
4. Pry the choke cover by inserting a putty knife as
shown Figure 4-7.
5. Release choke cover from door panel.
6. Now choke cover is free.
7. Release two (2) pins of door panel from two (2)
holes of upper and lower oven hinges by lifting up.
8. Now, door panel with door frame is free from oven
cavity.
Figure 4-7. Door Disassembly
9. Release the door panel from twelve (12) tabs of
door frame.
10. Remove the door panel from the door frame.
11. Now, door panel with sealer film is free.
12. Tear sealer film from door panel.
13. Now, door panel is free.
14. Slide latch head upward and remove it from door
frame with releasing latch spring from door frame
and latch head.
15. Now, latch head and latch spring are free.
16. Remove door screen from door frame
17. Now, door frame is free.
4-9