Perkins NJ Series Troubleshooting Manual page 224

224
Index Section
E
E172 High Air Filter Restriction ............................ 110
E194 High Exhaust Temperature.......................... 110
E2143 Low Engine Coolant Level ........................ 117
E232 High Fuel/Water Separator Water Level ..... 111
E360 Low Engine Oil Pressure............................. 111
E361 High Engine Coolant Temperature .............. 113
E362 Engine Overspeed ...................................... 114
E396 High Fuel Rail Pressure .............................. 115
E398 Low Fuel Rail Pressure ............................... 115
E539 High Intake Manifold Air Temperature......... 116
ECM Harness Connector Terminals ...................... 29
Removal and Installation of the Harness Connector
Terminals.......................................................... 30
ECM Memory - Test............................................. 146
ECM Snapshot ...................................................... 31
Snapshot That is Triggered by a Diagnostic
Code................................................................. 32
Snapshot That is Triggered by the Operator...... 32
Use of Snapshot Data........................................ 32
ECM Will Not Accept Factory Passwords.............. 52
Probable Causes ............................................... 52
Recommended Actions...................................... 52
ECM Will Not Communicate with Other Systems or
Display Modules .................................................. 52
Probable Causes ............................................... 52
Recommended Actions...................................... 52
Electrical Connectors - Inspect............................ 147
Electronic Service Tool Will Not Communicate with
ECM..................................................................... 52
Probable Causes ............................................... 52
Recommended Actions...................................... 53
Electronic Service Tools ........................................ 12
Optional Service Tools ....................................... 12
Perkins Electronic Service Tool.......................... 13
Required Service Tools ...................................... 12
Electronic Troubleshooting ...................................... 5
Engine Cranks but Will Not Start ........................... 53
Probable Causes ............................................... 53
Recommended Actions...................................... 54
Engine Has Early Wear ......................................... 56
Probable Causes ............................................... 56
Recommended Actions...................................... 56
Engine Misfires, Runs Rough or Is Unstable......... 56
Probable Causes ............................................... 57
Recommended Actions...................................... 57
Engine Oil in Cooling System ................................ 58
Probable Causes ............................................... 58
Recommended Actions...................................... 58
Engine Pressure Sensor Open or Short Circuit -
Test .................................................................... 151
Engine Speed Does Not Change .......................... 59
Probable Causes ............................................... 59
Recommended Repairs ..................................... 59
Engine Speed/Timing Sensor Circuit - Test ......... 158
Engine Stalls at Low RPM ..................................... 60
Probable Causes ............................................... 60
Recommended Actions...................................... 60
Engine Temperature Sensor Open or Short Circuit -
Test .................................................................... 166
Engine Vibration .................................................... 61
Probable Causes ............................................... 61
Recommended Actions...................................... 61
Engine Will Not Crank ........................................... 62
Probable Causes ............................................... 62
Recommended Repairs ..................................... 62
Engine Wiring Information ..................................... 25
Harness Wire Identification ................................ 25
Schematic Diagrams.......................................... 27
Event Codes ......................................................... 110
Excessive Black Smoke ........................................ 63
Probable Causes ............................................... 63
Recommended Actions...................................... 63
Excessive Engine Oil Consumption....................... 65
Probable Causes ............................................... 65
Recommended Actions...................................... 65
Excessive Fuel Consumption ................................ 66
Probable Causes ............................................... 66
Recommended Actions...................................... 66
Excessive Valve Lash............................................ 68
Probable Causes ............................................... 68
Recommended Actions...................................... 68
Excessive White Smoke ........................................ 68
Probable Causes ............................................... 68
Recommended Actions...................................... 68
F
Factory Passwords ................................................ 32
Factory Passwords Worksheet.............................. 33
Flash Programming ............................................... 33
Flash Programming a Flash File ........................ 33
Fuel Rail Pump Solenoid - Test ........................... 171
G
Glossary .................................................................. 8
I
Idle Validation Switch Circuit - Test...................... 176
Ignition Keyswitch Circuit and Battery Supply Circuit -
Test .................................................................... 181
Important Safety Information ................................... 2
Indicator Lamp Circuit - Test................................ 187
Indicator Lamps ..................................................... 14
Color of Lamps................................................... 14
Flash Codes....................................................... 15
Functions of the Lamps...................................... 14
Indicator Lamps ................................................. 14
Operation of the Indicator Lamps....................... 15
Injector Data Incorrect - Test ............................... 190
Injector Solenoid Circuit - Test............................. 192
Injector Trim File.................................................... 34
Intake Air Temperature Is Too High ....................... 69
Probable Causes ............................................... 69
Recommended Actions...................................... 69
SENR9982-01