Btu & Efficiency Specifications; Mobile Home Approved; Glass Specifications - Quadra-Fire Pioneer-III-ABK Owner's Manual

2
Listing and Code Approvals
A. Appliance Certification
Model: Pioneer III
Laboratory:
Underwriters Laboratories, Inc.
Report No:
Project 4788732172
Type:
Wood Fireplace
Standard: UL 127 - 2011 and CAN/ULC S610-
2018 (A1998) and (UM) 84-HUD,
Manufactured Home Approved.
B. BTU & Efficiency Specifications
EPA Certified Emissions: 2.0 grams per hour
*LHV Tested Efficiency: 74.3%
**HHV Tested Efficiency: 69.1%
***EPA BTU Output: 14,700-72,800
Vent Size: 8 inches
Firebox Size:
Recommended Log Length: 24 inches
*Weighted average LHV (Low Heating Value) efficiency using
cord wood and data collected during EPA emission test. LHV
assumes the moisture is already in a vapor state so there is no
loss in energy to vaporize.
**Weighted average HHV (High Heating Value) efficiency using
cord wood and data collected during EPA emission test. HHV
includes the energy required to vaporize the water in the fuel.
***A range of BTU outputs based on HHV and the burn rates
from the low and high EPA tests, using cord wood.
The Pioneer III is Certified to
comply with 2020 particulate
emission standards.
The PIONEER III Wood Appliance meets the U.S. ENVI-
RONMENTAL PROTECTION AGENCY Certified to comply
with 2020 particulate emission standards using cord wood.
This wood heater needs periodic inspection and repair for
proper operation. It is against federal regulations to operate
this wood heater in a manner inconsistent with operating
instructions in this manual.
6
4.07 cubic feet
Fuel Seasoned Cord Wood less
than 20% moisture
Quadra-Fire • Pioneer III Owner's Manual • 4182-900 • Rev D • 08/19
C. Mobile Home Approved
• This appliance is approved for mobile home installa-
tions when not installed in a sleeping room and when
an outside combustion air inlet is provided.
• The structural integrity of the mobile home floor, ceil-
ing, and walls must be maintained.
• The appliance must be properly grounded to the
frame of the mobile home with #8 copper ground
wire.
• Outside Air Kit must be installed in a mobile home
installation.
D. Glass Specifications
This fireplace is equipped with 5mm ceramic glass.
Replace glass only with 5mm ceramic glass. Please con-
tact your dealer for replacement glass.
WARNING
Fire Risk.
Hearth & Home Technologies disclaims any
responsibility for, and the warranty will be voided by,
the following actions:
• Installation and use of any damaged appliance.
• Modification of the appliance.
• Installation other than as instructed by Hearth & Home
Technologies.
• Installation and/or use of any component part not approved
by Hearth & Home Technologies.
• Operating appliance without fully assembling all components.
• Do NOT Overfire - If appliance or chimney connector glows,
you are overfiring.
Any such action that may cause a fire hazard.
Improper installation, adjustment, alteration, service or
maintenance can cause injury or property damage.
For assistance or additional information, consult a qualified
installer, service agency or your dealer.
NOTE: Hearth & Home Technologies, manufacturer of
this appliance, reserves the right to alter its products,
their specifications and/or price without notice.
Quadra-Fire is a registered trademark of Hearth & Home
Technologies.