Table of Contents
Advertisement
Quick Links
OPERATING
INSTRUCTIONS
PROOFER/HEATER CABINETS
PHU SERIES
Thermometer
PH-1826 SERIES
PH-BBC SERIES
Air Temperature "HEAT" Control Dial
ETC-1826-PH SERIES
ETC-UA-PH SERIES
Air Temperature Cycling Light
Air Moisture Cycling Light
Air Moisture "PROOF"
Control Dial with "P" to
Indicate Proof Position
Main Power Switch
Heat Basin
Water Pan
Advertisement
Table of Contents
Related Manuals for FWE PHU Series
Summary of Contents for FWE PHU Series
- Page 1 OPERATING INSTRUCTIONS PROOFER/HEATER CABINETS PHU SERIES Thermometer PH-1826 SERIES PH-BBC SERIES Air Temperature “HEAT” Control Dial ETC-1826-PH SERIES ETC-UA-PH SERIES Air Temperature Cycling Light Air Moisture Cycling Light Air Moisture “PROOF” Control Dial with “P” to Indicate Proof Position Main Power Switch...
- Page 2 Serial Tag Parts List Control Panel Uprights and tray slides remove and adjust easily without tools Heat System Moisture Tunnel Drip Trough With 12" x 20" Water Pan Removable and Heat Basin Drain Plug FWE PROOFER/HEATER...
-
Page 3: Registration Card
FWE PROOFER/HEATER CABINETS REGISTRATION CARD CONGRATULATIONS..and thank you for purchasing an FWE Mobile PROOFER/HEATER cabinet. Your unit has been designed and manufactured under rigid controls to assure you the most efficient service. It is a full time unit, and may be used continuously. -
Page 4: Installation
ELECTRICAL REQUIREMENTS AND GROUNDING FWE Proofer/Heater models operate on 110/120 volt, 60 Hz, 1 ph, A.C. (unless ordered otherwise), and are equipped with a three prong grounding cord plug for your protection against possible shock hazards. - Page 5 GENERAL OPERATING INSTRUCTIONS CONTROL PANEL AND CABINET CLEANING CONTROLS When ready for operation, and the cabinet has been plugged into an outlet, an ON-OFF rocker switch activates power to the cabinet. Your Proofer/Heater is equipped with two (2) heating elements and two (2) separate controls which regulate these elements.
- Page 6 NOTE: You may desire to create a high saturation of moisture in your cabinet. A DRIP TROUGH has been provided to collect excess cabinet moisture / run-off and is located below the door. Remove the plug to drain water from trough, then wipe clean. Drain as often as required. FWE PROOFER/HEATER...
- Page 7 GENERAL OPERATING INSTRUCTIONS 12" x 20" HUMIDIFIER PAN ADD HOT WATER TO 12" x 20" PAN 12" x 20" Shown Positioned Into Heat Basin Amount of water required in pan is determined by: 1. Start-up time (Less Water = Faster Start-up) 2.
- Page 8 HOT WATER Tunnel 12" x 20" Heat Tunnel Stand 12" x 20" Positioned Into Heat Basin Amount of water required in pan is determined by: 1. Start-up time 2. Length of proofing time 3. Level of humidity desired FWE PROOFER/HEATER...
-
Page 9: Troubleshooting Chart
* * NOTE: CALIBRATION IS EXCLUDED FROM FWE WARRANTY. Thermostats on all units are calibrated at the factory prior to shipping. Due to conditions in transit, beyond our control, occasionally units will need to be re-calibrated prior to use. -
Page 10: Service Record
FWE PROOFER/HEATER CABINETS SERVICE RECORD Model Number ______________________ Serial Number ______________________ Date of Purchase ____________________ Notes: ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________... -
Page 11: Limited Two-Year Warranty
FWE PROOFER/HEATER CABINETS LIMITED TWO YEAR WARRANTY FWE / Food Warming Equipment Company, Inc. (Seller) warrants to the original purchaser, subject to the exceptions and conditions below, that FWE manufactured equipment shall be free from defects in material or factory workmanship, under ordinary use for the purpose for which it is designed. - Page 12 FWE Parts Department: www.FWEparts.com Phone: 815 459 7500 FAX: 815 459 7989 WE OFFER SALES AND SERVICE WORLDWIDE Food Warming Equipment Company, Inc. P.O. Box 1001 • Crystal Lake, IL 60039-1001 Manufacturing Facilities: 5599 Highway 31 West • Portland, TN 37148 sales@fweco.net...