Hobart ecomax Use And Maintenance Manual page 23

9.
ROUTINE MAINTENANCE
9.5 PERIODIC INSPECTIONS
Cleaning the cooking compartment
Inside the cooking compartment there could be various
types of solid residue deposits. A visual inspection must be
performed at the end of the day to see if this occurred. If so,
manually remove these residues and, as needed, unscrew
the filter from the base of the cooking compartment (Fig. 7)
to free the drain of possible residues. When these opera-
tions are complete, replace the filter inside the cooking com-
partment.
As necessary, remove the tray holders from the
pin (Fig. 8) and remove them from the cooking
compartment.
FILTER CLEANING
If necessary, remove the filter (fig. 14), wash with potable wa-
ter and non-abrasive and/or corrosive material to eliminate
possible solid residues. • Dry carefully. When these opera-
tions are complete, install the filter.
"Filter Cleaning" message (Display 2): carry out
the routine maintenance of the filter.After cleaning
press PLUS for 5 seconds to clear the message.
Cleaning the condensate drain pan
Inside the condensation collection tray there could be resi-
due that obstruct the flow of liquids. A visual inspection is
required at the end of the day to see if this has occurred.
Manually remove these residues as needed to free the drai-
nage hole (Fig. 10).
Cleaning the interior and exterior glass
The equipment has a fixed, glass attached to the door, and
a mobile glass. If necessary and with the door completely
open, remove the glass retainers (fig. 9) and carefully clean
the glass from both sides. Before hooking it back to the door,
carefully clean the fixed internal glass.
Inspection and cleaning of the door ga-
sket
At the end of each washing of the cooking compartment and
at the end of the daily cycle, thorough cleaning of the door
gasket is needed for proper maintenance (Fig. 11).
Wash the gasket with non-abrasive and/or corrosive mate-
rial, dry it thoroughly and spread vaseline over the surface to
keep it soft and in good condition.
Checking the liquid detergent level
Appliances with automatic washing required a visual inspec-
tion at the end of the day to check the detergent in the spe-
cial container (Fig. 12). 12
Make sure there is liquid detergent in the container and re-
place and/or refill as necessary.If there is no liquid detergent,
the appliance does not report any anomaly and washing will
be performed without detergent.
Check and clean the drains
For correct disposal of the water in the drainage system,
make sure that there are no obstructions or blockages of
any kind along the entire line (Fig. 9-13).
THE PRESENT MANUAL IS PROPERT Y OF THE MANUFACTURER. ANY REPRODUCTION, EVEN PARTIAL, IS PROHIBITED.
Fig. 7
Fig. 9
- 23 - 23
Fig. 14
Fig. 8
Fig. 10
Fig. 12
Fig. 11
Fig. 13