Table Of Contents - Quadra-Fire MTVERNINSAE-MBK Installation Manual

MT VERNON AE INSERT
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
WARNING! Indicates a hazardous situation which, if not avoided may result in death or serious injury.
•
• CAUTION! Indicates a hazardous situation which, if not avoided, may result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the appliance or to property.
Important Safety Information ............3
1
A. Appliance Certification ......................................................3
B. BTU & Efficiency Specifications........................................3
C. Glass Specifications .........................................................3
D. Electrical Rating................................................................3
E. Mobile Home Approved .................................................... 3
Getting Started ...................................4
2
A. Design, Installation & Location Considerations ..........................4
B. Thermostat Wall Control Location......................................5
C. Tools And Supplies Needed ..............................................5
D. Inspect Appliance and Components .................................5
E. Install Checklist ..................................................................6
Dimensions and Clearances .............7
3
A. Appliance Dimensions ......................................................7
B. Clearances to Combustibles (UL and ULC) .......................8
C. Minimum Opening for Masonry &
Zero Clearance Fireplaces .................................................9
D. Installation into a Factory-Built Fireplace...........................9
E. Installation into a Masonry Fireplace .................................11
F. Prefabricated Metal Chimney .............................................11
2
REV REVISIONS

TABLE OF CONTENTS

MULTI-FUEL IGNITER
THIS IGNITER IS REQUIRED FOR
BURNING FUELS OTHER THAN
WOOD PELLETS.
THIS IGNITER CAN ALSO BE USED AS A
BACKUP FOR WOOD PELLETS.
burning multi-grain fuels and is included in the compo-
nent pack. Multi-fuels include, corn, sunflower seeds,
and wheat.
UNLESS OTHERWISE SPECIFIED DIMS ARE INCHES[MM] & : TOLERANCES ARE: (2) PLACE DEC : ± 0.03
OUTSIDE MATERIAL. NORMAL DIM & INSIDE MATERIAL.
CONFIDENTIAL PROPERTY OF HEARTH & HOME TECHNOLOGIES INC.
ECO # DATE BY
Vent Information ...............................12
4
A. Venting Termination Minimum Requirements ...................12
B. Avoiding Smoke and Odors ...............................................13
C. Negative Pressure ............................................................14
D. Draft..... ............................................................................. 14
E. Chimney and Exhaust Connection ...................................14
F. Equivalent Feet of Pipe ....................................................15
G. Pipe Selection Chart ........................................................15
Venting Systems ..............................16
5
A. Full Reline With Outside Air - Horizontal ...........................16
B. Full Reline With Outside Air - Vertical ...............................17
Appliance Set-Up .............................18
6
A. Leveling System ...............................................................18
B. Outside Air Kit Instructions ................................................18
C. Hearth Support .................................................................19
D. Removal of Cast Sides ....................................................19
E. Surround and Trim Set - Cast ...........................................20
F. Surround & Trim Set, Basic ...............................................20
G. Optional Log Set Placement Instructions .........................21
H. Wall Control Thermostat Installation .................................21
Mobile Home Installation .................22
7
Accessory List .................................23
8
ITEM PART NUMBER PART NAME
A 300 Watt Igniter comes installed
in a brand new Mt. Vernon AE and
are for use with pellet fuel only.
The 380 Watt Igniter is required for
(3) PLACE DEC: ± 0.005 ANGLE: ± 2° FRACTION: ± 1/16
OUTSIDE APEX INSIDE APEX - DIMS ENCLOSED BY AN OVAL ARE CRITICAL DIMENSIONS
PART NAME:
7036-188J
DRAWN BY: SCALE: MATERIAL:
PART NUMBER:
THIS PRINT IS CHECKED AND CONTROLLED BY THE ENGINEERING SHEET:
DEPARTMENTS OF HEARTH & HOME TECHNOLOGIES INC.
QTY
October 3, 2017
REV: