Page 1
SERVICE MANUAL DVD VIDEO RECORDER XA020 2004 DR-M10SEF, DR-M10SEK DR-M10SE, DR-M10SER DR-M10BE Area Suffix EK ------------------------ U.K. EF --------------------- France ER ---- Russian Federation E ------- Continental Europe Northern Europe CABLE/DBS STANDBY/ON MUTING VIDEO TV/CBL/DBS TV VOLUME PQRS WXYZ CANCEL...
Page 2
SPECIFICATION GENERAL Power requirement AC 220 V - 240 Vd, 50 Hz/60 Hz Power consumption Power on : 33 W Power off : 17.6 W Temperature Operating : 5°C to 40°C Storage : -20°C to 60°C Operating position Horizontal only Dimensions (W ×...
Page 3
Important for laser products 5.CAUTION : If safety switches malfunction, the laser is able 1.CLASS 1 LASER PRODUCT to function. 2.DANGER : Invisible laser radiation when open and inter 6.CAUTION : Use of controls, adjustments or performance of lock failed or defeated. Avoid direct exposure to beam. procedures other than those specified here in may result in 3.CAUTION : There are no serviceable parts inside the hazardous radiation exposure.
Page 4
SECTION 3 DISASSEMBLY Main body section 3.1.1 Remove the top cover (See figure 1) (1) Remove the four screws A attaching the top cover on both sides of the main body. (2) Remove the five screws B attaching the top cover on the TOP COVER TOP COVER TOP COVER...
Page 5
3.1.3 Remove the mechanism assembly (See figure 5) Mechanism assembly • Prior to performing the following procedure, remove the top Module board cover. • There is no need to remove the front panel assembly. (1) Disconnect the socket wire from connector CN5303 on the power supply board.
Page 6
3.1.5 Remove the power supply board (See figure 8) CN5302 Fastener • Prior to performing the following procedure, remove the top cover. (1) Disconnect the card wire from connector CN5301 on the Power supply power supply board. board (2) Disconnect the socket wire from connector CN5302, Fastener CN5303, CN5305...
Page 7
SECTION 4 ADJUSTMENT Timer clock adjustment (for only ver.E) If an error comes to arise for a clock, the following procedure will adjust. Signal (A1) No signal Mode Equipment Frequency counter Measuring point (D1) IC3001 pin 61 (D2) IC3001 pin 17 (D3) C3026 + and - Adjustment part...
Page 8
*This product has remote control codes of 1, 2, 3, and 4. *The remote control codes "DVD 1, 2, 3, and 4" of product are the same as the remote control codes "A, B, C, and D" of video cassette recorders manufactured in JVC. CABLE/DBS "(2) a-c"...
Page 9
5.1.1 Setting JIG mode To display SYSTEM INFO or to upgrade firmware, the main body needs to be set to JIG mode. (1) Turn the main body ON. (2) Press the buttons of the remote control unit attached to product in the following order : "SET UP" → "2" → "8" → "ENTER" (3) When a colon ":"...
Page 10
5.1.3 Displaying SYSTEM INFO SYSTEM INFO contains information on firmware version of the main body and the mechanism drive, and an initialize execution menu. (1) Set the main body to JIG mode. (2) Transmit "43-8B" to the main body by using JIG remote control unit. (3) SYSTEM INFO menu is displayed in the television screen.
Page 11
The setting method of a region code A region code should be set after a DVD recorder mechanism unit is replaced. While a DVD recorder mechanism unit is in a warehouse as a stock, a region code of the drive unit is not determined. Only replacement of a DVD recorder mechanism unit may cause abnormal playback of Disc.
Page 12
VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY OPTICAL DISC CATEGORY 1644, Shimotsuruma, Yamato, Kanagawa 242-8514, Japan (No.XA020) Printed in Japan...
SCHEMATIC DIAGRAMS DVD VIDEO RECORDER DR-M10SEF, DR-M10SEK DR-M10SE, DR-M10SER DR-M10BE CD-ROM No.SML200404 Area Suffix EK ------------------------ U.K. EF --------------------- France ER ---- Russian Federation E ------- Continental Europe Northern Europe CABLE/DBS STANDBY/ON MUTING VIDEO TV/CBL/DBS TV VOLUME PQRS WXYZ CANCEL...
Page 16
MAIN 0 3 Audio signal control section (SHEET 8) J7308 J7307 L-1 SCART Terminal TO SHEET 11 S-VIDEO AUDIO OUT AUDIO_OUT1[L/R] J7301 Muting A_MUTE2[H] RAPID_SW BIAS/RGB_CTL Q7310 to Q8201,Q8202 DEC_OUT[L/R] Q7312 LINE_OUT[L/R] IC8301 IC8202 IC8302 4_3[H] P50_I/O AV_YC_IN[H] TV[H] TO SHEET 11 DAC_SDA AOUTL DAC_SCL...
Page 17
SW.REG 0 1 D2.5V 2.5V REG. IC5305 TO CN5102 AC-DC SHEET 10 AC IN D1.8V D5001 1.8V REG. P.SAVE[L] IC5302 TO CN5101 Switching 3.3V REG. V3.3V Power SHEET 10 regurator IC5303 transformer IC5101 D5.0V T5001 5V REG. IC5304 3.3V REG. IC5308 1.8V REG.
Page 18
Standard schematic diagrams Power supply section CN5301 B5501 DC3.9[+] D5201 CP5301 R5310 DC3.9[-] 10ERB20 1.5A /125 Q5310 ERA18-02 2SD2144S/UV/ -29V C5201 2SC3576 AL-12V /6.3 Parts are safety assurance parts. FAN_CTL AL12V When replacing those parts make R5314 D5207 P.CTL[H] sure to use the specified one. AU01Z 1/4W ERA18-02...
Page 19
IEEE1394 section D3.3V B1802 B1801 OPEN C1806 L1802 L1801 C1804 C1803 /6.3 /6.3 OPEN C1814 C1813 OPEN OPEN C1805 R1820 C1810 OPEN K1801 X1801 NAX0551-001X SHORT NAX0666-001X IC1801 TSB41AB2PAP D3.3V PHY_RESET[L] PHY_LREQ LREQ AGND R1801 0‘ PHY_CLK SYSCLK R1802 0‘ PHY_CNA TO SHEET 4 PHY_CTL[0]...
Page 29
System controller section TO SHEET 9 443[H] TO SHEET 11 SCR_ID SEPA_IN[H] TO SHEET 9 SECAM_DET[H] 4_3[L] TV[L] RGB_TH[H] AV1_YC_IN[H] BIAS/RGB_CTL AV1_L AV1_L SHEET 11 AV2_H AV2_H P.MUTE[H] ADC_RST[L] RAPID_SW A_MUTE1[H] SHEET 8 V_MUTE[L] I2C_DATA2 I2C_CLK2 I2C_DATA_A/V TO SHEET 9 I2C_CLK_A/V SVss DVD_REC_LED...
Page 30
Tuner section K6708 TU6001 L6002 OPEN RF5V SW5V TO SHEET 10 L6005 µ SW12V L6701 µ C6751 C6752 /6.3 OPEN TU_AUDIO[L] TO SHEET 8 TU_AUDIO[R] K6706 C6718 OPEN C6715 C6717 R6716 R6714 R6712 L6702 µ R6720 5.6k R6711 470k C6719 C6713 0.22 CAPL_M...
Page 31
FL Display and operation switch section CN7102 R7152 R7151 FRONT C IN C7150 0.01 FRONT Y IN J7001 TO CN4001 J7002 R7153 FRONT VIDEO SHEET 9 F_AUDIO[R] C7151 C7152 F_AUDIO[L] 100p OPEN S7001 R7156 R7154 OPERATION 1SS133 1SS270A C7153 C7154 100p OPEN IC7002...
Page 36
It sticks so that there may be no wrinkles using a tool. DRAWING FROM DIRECTION DRAWING FROM DIRECTION FIG.2 FIG.6 (ONLY DR-M10SEF) When the REAR COVER is dirty, REAR COVER Clean the REAR COVER in alcohol before sticking GASKET. S/RCA OUT BOARD ASSY<29>...
Page 37
Block No.M1MM DVD UNIT REAR SIDE. SPACER is stuck on DVD UNIT. NEUTRAL (WHITE LINE) CN5001 CN5305 Match the position. MAIN BOARD ASSY REGULATOR BOARD ASSY SHILED PLATE is fixed by WIRE currently attached to SHILED PLATE. so that TAPE may be put. TAPE DIGITAL BOARD ASSY...
Page 38
General assembly Block No. [M][1][M][M] Symbol No. Part No. Part Name Description Local 1 LP10533-015A FRONT PANEL ASSY M10BE 1 LP10533-004A FRONT PANEL ASSY M10SEK 1 LP10533-001A FRONT PANEL ASSY M10SE,M10SEF,M10SER LP21252-002A DOOR M10BE LP21252-001A DOOR M10SE,M10SEF,M10SEK,M10SER PU60109 CATCHER...
MTZJ11C-T2 Z DIODE Q5304 or RT1N141C-X DIGI TRANSISTOR D5303 or RD11ES/B3/-T2 Z DIODE Q5305 2SD2144S/UV/-T TRANSISTOR D5304 MTZJ5.6C-T2 Z DIODE Q5305 or 2SC3576-JVC-T TRANSISTOR D5304 or RD5.6ES/B3/-T2 Z DIODE Q5308 2SD1858/QR/-T TRANSISTOR D5305 RL2Z-LFB2 Q5310 2SD2144S/UV/-T TRANSISTOR D5306 1SS133-T2 DIODE...
Page 40
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C5304 QETN1AM-107Z E CAPACITOR 100uF 10V M LP31414-001A PROTECT SHEET C5305 QETN1AM-107Z E CAPACITOR 100uF 10V M PU59391 STYLE PIN C5306 QETN1CM-107Z E CAPACITOR 100uF 16V M C5307 QETN1AM-107Z E CAPACITOR...
Page 41
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C1007 NCB31CK-104X C CAPACITOR 0.1uF 16V K C1428 NCB31CK-104X C CAPACITOR 0.1uF 16V K C1008 NCB31CK-104X C CAPACITOR 0.1uF 16V K C1429 NCB31CK-104X C CAPACITOR 0.1uF 16V K...
Page 42
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C1811 NCB31CK-104X C CAPACITOR 0.1uF 16V K R1230 NRSA63J-472X MG RESISTOR 4.7kΩ 1/16W J C1812 NCB31CK-104X C CAPACITOR 0.1uF 16V K R1231 NRSA63J-472X MG RESISTOR 4.7kΩ...
Page 43
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R1615 NRSA63J-0R0X MG RESISTOR 0Ω 1/16W J RA1403 NRZ0040-101X NET RESISTOR 100Ω 1/16W J x4 R1616 NRSA63J-0R0X MG RESISTOR 0Ω 1/16W J RA1404 NRZ0040-101X NET RESISTOR 100Ω...
Page 45
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local Q7315 or RT1N140C-X DIGI TRANSISTOR C3051 NCB31HK-272X C CAPACITOR 2700pF 50V K Q7315 or UN2215-X TRANSISTOR C3054 NCB31EK-103X C CAPACITOR 0.01uF 25V K Q7316 2SB709A/QR/-X TRANSISTOR...
Page 46
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C6709 NDC21HJ-8R0X C CAPACITOR 8pF 50V J C8208 NDC31HJ-471X C CAPACITOR 470pF 50V J C6713 NCF21CZ-224X C CAPACITOR 0.22uF 16V Z C8209 NCB31CK-104X C CAPACITOR 0.1uF 16V K...
Page 47
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R3097 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R6021 NRSA02J-102X MG RESISTOR 1kΩ 1/10W J R3213 NRSA63J-474X MG RESISTOR 470kΩ 1/16W J R6030 NRSA02J-332X MG RESISTOR 3.3kΩ...
Page 48
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R8024 NRSA63D-473X MG RESISTOR 47kΩ 1/16W D L4006 QQL29BJ-100Z P COIL 0.40Ω 10uH J R8026 NRSA63J-203X MG RESISTOR 20kΩ 1/16W J L4007 QQL071J-8R2Y COIL 1.30Ω...
Page 49
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local NRSA63J-0R0X MG RESISTOR 0Ω 1/16W J CN7102 QGF1208F1-11 CONNECTOR FFC/FPC (1-11) NRSA63J-0R0X MG RESISTOR 0Ω 1/16W J J7001 QND0084-001 S JACK S-VIDEO IN NRSA63J-0R0X MG RESISTOR 0Ω...
Page 50
S/RCA Out board Block No. [2][9] Symbol No. Part No. Part Name Description Local LPA10239-01A5 S/RCA OUT BOARD ASSY C7326 NCB31EK-103X C CAPACITOR 0.01uF 25V K C7365 NCB31HK-102X C CAPACITOR 1000pF 50V K C7367 NCB31HK-102X C CAPACITOR 1000pF 50V K R7327 NRSA63D-750X MG RESISTOR...
Page 51
Packing materials and accessories parts list Block No.M2MM ADHESIVE TAPE FINAL ASSY<M1> SPEC OF BARCODE (No.XA020)3-17...
Page 52
Packing and accessories Block No. [M][2][M][M] Symbol No. Part No. Part Name Description Local LP31384-019A PACKING CASE M10BE LP31384-003A PACKING CASE M10SE LP31384-004A PACKING CASE M10SEF LP31384-005A PACKING CASE M10SEK LP31384-022A PACKING CASE M10SER LP31387-001B CUSHION ASSY PQM30021-93 POLY BAG QAM0525-002 RF CABLE ------------...