Toshiba MMY-MAP0806HT8P Service Manual page 3

6-2-7. External master ON/OFF Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
6-2-8. Night operation (sound reduction) Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. .101
6-2-9. Operation Mode Selection Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
6-2-10. Error/Operation Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..103
6-2-11. Compressor Operation Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104
6-2-12. Operating Rate Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .105
7 TEST OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106
Procedure and Summary of Test Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
7-1.
Check Items before Test Operation (before powering-on) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107
7-2.
Check at Main Power-on . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 111
7-3.
Address Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
7-4.
7-4-1. Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
7-4-2. Address Setup and Check Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
7-4-3. Address Setup Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
7-4-4. Check after Address Setup when Central Control System Is Connected . . . . . . . . . . 126
Troubleshooting in Test Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
7-5.
7-5-1. A Check Code is Displayed on the Remote Controller . . . . . . . . . . . . . . . . . . . . . . . . 127
7-5-2. Operation from the indoor remote controller is not accepted, and a check code is
displayed on the 7-segment display of the interface PC board of the header unit. . . . 128
7-5-3. There is no display of a check code on the 7-segment display on the interface
PC board of the header unit, although there is indoor unit that is not accepting
operation from the indoor remote controller. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
7-5-4. In checking the number of connected outdoor units and connected indoor units
after address setup, a lower number of connected units is displayed. (There are
outdoor/indoor units that do not operate in a test operation.) . . . . . . . . . . . . . . . . . . . 129
Test Operation Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . 131
7-6.
7-6-1. Fan Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
7-6-2. Single cooling/Single heating Test Operation Check . . . . . . . . . . . . . . . . . . . . . . . . . . 132
Service Support Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 135
7-7.
7-7-1. Check Function for Connecting of Refrigerant and Control Lines . . . . . . . . . . . . . . . . 135
7-7-2. Function to Start/Stop (ON/OFF) Indoor Unit from Outdoor Unit . . . . . . . . . . . . . . . . . 138
7-7-3. Check Code Clearing Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144
7-7-4. Remote Controller Distinction Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
7-7-5. Pulse Motor Valve (PMV) Forced Open/Close Function in Indoor Unit . . . . . . . . . .. . 147
7-7-6. Pulse Motor Valve (PMV) Forced Open Fully/Close fully Function in Outdoor Unit . . 147
7-7-7. Solenoid Valve Forced Open/Close Function in Outdoor Unit . . . . . . . . . . . . . . . . . . . 148
7-7-8. Fan Operation Check in Outdoor Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 149
7-7-9. Abnormal Outdoor Unit Discrimination Method By Fan Operating Function . . . . . . . . 150
7-7-10. Manual Adjustment Function of Outside Temperature (TO) Sensor . . . . . . . . . . . . . . 151
7-7-11. Refrigerant leakage detection . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . 153
7-7-12. Monitor Function of Remote Controller Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 154
SMMS WAVE TOOL FOR SMARTPHONE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 156
7-8.
7-8-1. Prohibition/Permission of the NFC Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . 156
7-8-2. Confirmation for the generation of the error of the NFC. . . . . . . . . . . . . . . . . . . . . . . . . . 157
DRED (Demand response enabling device) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158
7-9.
− 2 −