Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Hyundai DHY12500SE
Summary of Contents for Hyundai DHY12500SE
-
Page 1: User Manual
DIESEL GENERATOR Model DHY12500SE User Manual... - Page 2 Page 2 First issue - 22nd November 2016...
-
Page 3: Table Of Contents
CONTENTS o’s Section Description Page N 1. SAFETY 4 - 7 8 - 10 2. CHECKS BEFORE USE 3. OPERATION 4. MAINTENANCE 12 - 13 5. TROUBLESHOOTING 6. SPECIFICATIONS 7. WIRING DIAGRAM 8. STORAGE & TRANSPORTATION 9. PART LOCATIONS 18 - 19 10. -
Page 4: Safety
Appropriate Personal Protective Equipment SAFETY (PPE), MUST be worn at all times when machine is in use or being repaired. 1.1. General safety notes. 1.1.1. The operator of the machine is responsible for, and has a duty of care in making sure that the machine is operated safely and in accordance with the instructions in this user manual. -
Page 5: Safety
1.4.3. When fuelling/de-fuelling ALWAYS avoid inhaling fumes 1.4.4. When de-fuelling ALWAYS use a propriety fuel retriever. 1.4.5. ALWAYS carry fuel in the correct and clearly marked container. 1.5. Electrical safety. 1.3. General fuel safety (where applicable). ALL FUELS ARE FLAMMABLE 1.3.1. - Page 6 1.6.2. Should you come into contact with and other diseases that affect blood vessels electrolyte you should; and blood circulation as well as large and long- lasting impact of shocks are considered factors 1.6.2.1. Remove all clothing contaminated in the formation of white finger. Note the with electrolyte.
- Page 7 1.9.3. Keep children and animals away from 1.9.9. Make sure there are no naked flames, running generator set to prevent injuries. cigarettes, fires and sparks where the generator is re-fuelled or fuel is stored. 1.9.4. Make sure that all operator of this machine are fully trained in the safe use and 1.9.10.
-
Page 8: Checks Before Use
CHECKS BEFORE USE 2.1. Oil level. Running the engine with no oil will cause engine damage which will not be covered under warranty 2.1.1. You MUST check the oil level before each use. 2.1.2. To access oil filler cap and dipstick. You must open the left hand access door as viewed form control panel end. - Page 9 2.2. Fuel – This machine uses Diesel fuel only. You MUST stop the machine and allow it to cool down before filling with fuel. You must refuel in a well ventilated place and always from any sources of ignition, such as naked flames, sparks form grinders etc.
- Page 10 2.3. Battery - Sealed lead acid. Batteries present a risk if they become damaged by the possible leaking of electrolyte. This electrolyte is an acid and can cause serious burn injuries. Care should be taken when working on or near them. 2.3.1.
-
Page 11: Operation
OPERATION 3.1. Starting the generator. Before starting you MUST disconnect all appliances. All circuit breakers are to be turned OFF. You MUST earth the generator before use. 3.1.1. Key start. 3.1.2. Turn the starter key clockwise to the ON positon and allow the control panel to self-test, then turn the keyswitch against spring tension to START position until machine starts. -
Page 12: Maintenance
MAINTENANCE 4.1. Maintenance schedule. Proper maintenance is not only the basis of safe, economical and easy way of generator operation, but also helpful to reduce the air pollution. If these maintenance instructions are not followed properly, it may cause serious personal injury. Maintenance period After 1 month or... - Page 13 4.3. Air filter. DO NOT operate the machine with the air filter missing – damage can occur which will not be covered under warranty 4.3.1. Access to the air filter – the air filter can be accessed from either side of the machine. 4.3.2.
-
Page 14: Troubleshooting
TROUBLESHOOTING MACHINE WILL NOT START CAUSE REMEDY Check all connections including Poor connections Check the control system all plugs and sockets power Low battery Charge/replace the battery No Fuel Fill with diesel fuel Check fuel and oil No Oil Fill with oil Poor quality fuel Replace old/stale fuel Piston ring worn or rings in... -
Page 15: Specifications
SPECIFICATIONS DHY12500SE Engine model HY290F Type 2 cylinder - Air cooled four stroke Speed - RPM 3000 Maximum output – HP Starting method Electric Oil sump capacity – L 2.25 Type Brushed AC single phase Frequency – hz Voltage – v Rated output –... -
Page 16: Wiring Diagram
WIRING DIAGRAM Page 16 First issue - 22nd November 2016... -
Page 17: Storage & Transportation
STORAGE & TRANSPORTATION 8.1. Storage. DO NOT touch the exhaust or the engine during use or for at least two hours after use. To prevent fire hazard DO NOT move the generator into the storage area until it has fully cooled. 8.1.1. -
Page 18: Part Locations
PART LOCATIONS 9.1. Main unit. ITEM DESCRIPTION ITEM DESCRIPTION Control panel door Exhaust assembly - 2 Control panel Shock absorbers Battery boards Battery Front cover Inner cover Left door Air cover Upper plate Back cover Rubber cover Bottom seat Alternator mounting board Fuel tank Alternator Wheel... - Page 19 9.2. Control panel layout. Page 19 First issue - 22nd November 2016...
-
Page 20: Declarations Of Conformity
10. DECLARATIONS of CONFORMITY. 10.1. Genpower Ltd confirms that these Hyundai products conform to the following CE Directives; 2006/42/EC Machinery Directive. 2004/108/EC EMC Directive. 2000/14/EC Noise Emissions Directive. 97/68/EC NRMM Emissions Directive. 2006/95/EC Low Voltage Directive. Page 20 First issue - 22nd November 2016... -
Page 21: Recycling & Product Disposal
11.9. You can also get more advice and 11. RECYCLING & PRODUCT guidance about recycling at the following DISPOSAL website http://www.recycle-more.co.uk 11.10. Should you pass this product onto another user either sold or loaned you MUST 11.1. We do not offer a takeback scheme pass on this user manual. - Page 22 Page 22 First issue - 22nd November 2016...
- Page 23 Page 23 First issue - 22nd November 2016...
- Page 24 GENPOWER LTD Isaac Way, London Road Pembroke Dock, UNITED KINGDOM, SA72 4RW T: +44 (0) 1646 687 880 F: +44 (0) 1646 686 198 E: info@hyundaipowerequipment.co.uk www.hyundaipowerequipment.co.uk...