This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 L 13942296513 u163 PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be u163 installed before shipment. Please be sure to follow this method especially if it is specified in this manual. PRS-A900/XS/UC http://www.xiaoyu163.com...
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. u163 PRS-A900/XS/UC http://www.xiaoyu163.com...
See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted L 13942296513 u163 PRS-A900/XS/UC http://www.xiaoyu163.com...
Applying to Chemical Capacitor etc. (*) Bond GYL1006 Applying to Thermistor (*) You can use GEM1017 even if the color is defferent from the original ones. 4. BLOCK DIAGRAM L 13942296513 There is no information to be shown in this chapter. u163 PRS-A900/XS/UC http://www.xiaoyu163.com...
Remove the eleven screws and then remove the Case. L 13942296513 Case Fig.1 Note) When removing the case, remove it from the positioning side. Removal from the opposite side may deform the positioning pin. (Fig.2) u163 Positioning pin Fig.2 PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 13
Remove the four screws and then remove the two Holders. Fig.3 L 13942296513 Removing the Amp Unit (Fig.4) Remove the six screws. Remove the ten screws. Remove the four screws and then remove the Amp Unit. Amp Unit u163 Fig.4 PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 14
L 13942296513 Hold here. 1 : You can use GYL1006 for the silicone adhesive. Press the thermistor against the transformer and apply an adhesive as the end of the thermistor touches the transformer. * TACK-FREE TIME 5 minutes u163 PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 15
BOND LOCK 12 pts <<Capacitor>> *Bond should be applied both of parts and PCB. *Be aware not to apply bond on contact point of connector, seat area of screw. * TACK-FREE TIME 10 minutes u163 PRS-A900/XS/UC http://www.xiaoyu163.com...
Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 9.1 PACKING L 13942296513 u163 PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 19
13-2 Warranty Card See Contrast table(2) Polyethylene Bag CEG-158 Polyethylene Bag CEG1116 Polyethylene Bag See Contrast table(2) (2) CONTRAST TABLE PRS-A900/XS/UC and PRS-A900/XS/EW5 are constructed the same except for the following: Mark Description PRS-A900/XS/UC PRS-A900/XS/EW5 Polyethylene Bag CEG1351 CEG1317 Unit Box...
Page 21
See Contrast table(2) Screw CBA2115 Screw YBA5002 Case CNB3453 Spacer CNN1954 Holder CND4269 (2) CONTRAST TABLE PRS-A900/XS/UC and PRS-A900/XS/EW5 are constructed the same except for the following: Mark Description PRS-A900/XS/UC PRS-A900/XS/EW5 Cover CNR1915 CNR1931 Heat Sink CNR1930 CNR1929 Badge Unit...
9.3 AMP UNIT 3 7 63 1515 0 L 13942296513 u163 PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 23
Auto Fuse Holder(CN602) CKR1021 Screw PPZ30P100FTB Terminal(CN604, 605, 606) VNF1084 Auto Fuse Holder(CN603) CKR1021 Panel CNB3454 (2) CONTRAST TABLE PRS-A900/XS/UC and PRS-A900/XS/EW5 are constructed the same except for the following: Mark Description PRS-A900/XS/UC PRS-A900/XS/EW5 Amp Unit CWH1386 CWH1384 L 13942296513 u163 PRS-A900/XS/UC...
Page 27
No differentiation is made between chip resistors and and capacitor fixed values Therefore, when replacing, be sure to use parts of discrete resistors. are expressed as : identical designation. Symbol indicates a capacitor. No differentiation is made between chip capacitors and 0.022 R022 discrete capacitors. PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 37
(B,287,63) RN1/10SE2201D D 804 (B,108,54) Diode RF101L2S D 805 (A,220,101) Diode HZS16L(1) R 219 (B,290,65) RN1/10SE2201D R 221 (B,293,48) RN1/10SE1000D R 301 (B,293,130) RN1/10SE4700D D 806 (A,220,98) Diode HZS16L(1) R 302 (B,278,130) RN1/10SE2202D D 1101 (A,279,188) Diode 1SS133 PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 38
(A,251,193) RD1/4PU103J R 644 (B,176,116) RS1/16S103J R 1116 (A,254,190) RD1/4PU182J R 647 (B,137,120) RS1/16S103J R 1117 (A,269,168) 100 ohm CCN1171 R 648 (B,174,122) RS1/16S683J R 1118 (A,239,168) 100 ohm CCN1171 R 649 (B,178,120) RS1/16S103J R 1119 (A,253,169) RD1/4PU821J PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 39
R 1306 (A,222,155) RD1/4PU151J R 1432 (A,24,57) RS1/2PMF100J R 1307 (A,177,163) RD1/4PU102J R 1441 (B,196,80) RN1/10SE5600D R 1308 (A,222,162) RD1/4PU102J R 1442 (B,207,81) RN1/10SE5600D R 1309 (A,194,153) RD1/4PU221J R 1310 (A,209,153) RD1/4PU221J CAPACITORS R 1311 (A,182,163) RD1/4PU221J PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 40
(A,157,126) CEANP221M10 C 1302 (B,208,146) CCSQCH221J50 C 621 (A,157,107) CEANP221M10 C 1303 (B,185,166) CCSQCH330J50 C 622 (B,77,137) CKSRYB103K50 C 1304 (B,189,166) CCSQCH330J50 C 623 (B,73,98) CKSRYB103K50 C 1305 (B,210,166) CCSQCH330J50 C 641 (B,99,91) CKSRYB104K50 C 1306 (B,214,166) CCSQCH330J50 PRS-A900/XS/UC http://www.xiaoyu163.com...
Page 41
C 1402 (B,181,84) CCSQCH221J50 C 1403 (B,185,67) CCSQCH330J50 C 1404 (B,189,67) CCSQCH330J50 C 1405 (B,209,67) CCSQCH330J50 C 1406 (B,213,67) CCSQCH330J50 C 1407 (A,201,69) 47 µF/25 V CCH1544 C 1408 (B,180,44) CKSQYB104K50 C 1409 (A,23,67) CFTNA273J50 L 13942296513 u163 PRS-A900/XS/UC http://www.xiaoyu163.com...