This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 L 13942296513 u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be u163 installed before shipment. Please be sure to follow this method especially if it is specified in this manual. PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Applying to Chemical Capacitor etc. (*) Bond GYL1006 Applying to Thermistor (*) You can use GEM1017 even if the color is defferent from the original ones. 4. BLOCK DIAGRAM There is not information to be shown in this chapter. u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
5. DIAGNOSIS 3 7 63 1515 0 5.1 CONNECTOR FUNCTION DESCRIPTION PRE OUT POWER GROUND SYSTEM SPEAKER OUT SPEAKER OUT INPUT CONTROL L 13942296513 6. SERVICE MODE There is not information to be shown in this chapter. u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Removing the Case (Fig.1) Case Remove the five screws and then remove the Case. Fig.1 Removing the Amp Unit (Fig.2) Remove the six screws. Remove the nine screws and then remove the Amp Unit. L 13942296513 Amp Unit Fig.2 u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 14
*Be aware not to apply bond on contact point of connector, * TACK-FREE TIME 5 minutes seat area of screw. * TACK-FREE TIME 10 minutes [Important control item] No foreign objects should remain in a parts box. u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
8. EACH SETTING AND ADJUSTMENT 3 7 63 1515 0 There is not information to be shown in this chapter. L 13942296513 u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 9.1 PACKING L 13942296513 u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 17
12-1 Warranty Card See Contrast table(2) Shaft YLP5003 12-2 Owner's Manual See Contrast table(2) Shaft YLP5004 (2) CONTRAST TABLE PRS-D4200F/XS/UC, PRS-D420/XS/EW5, PRS-D4200F/XS/ES and PRS-D4200F/XS/CN5 are constructed the same except for the following: PRS-D4200F/XS/ Mark Description PRS-D4200F/XS/UC PRS-D420/XS/EW5 PRS-D4200F/XS/ES Polyethylene Bag YEG5004 YEG5003...
Page 19
VNF1084 Spacer YNN5009 Plate See Contrast table(2) Terminal(CN821) VNF1084 Terminal(CN822) VNF1084 L 13942296513 (2) CONTRAST TABLE PRS-D4200F/XS/UC, PRS-D420/XS/EW5, PRS-D4200F/XS/ES and PRS-D4200F/XS/CN5 are constructed the same except for the following: PRS-D4200F/XS/ Mark Description PRS-D4200F/XS/UC PRS-D420/XS/EW5 PRS-D4200F/XS/ES Badge YAH5063 YAH5064 YAH5064 YAH5064...
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". Large size SCH diagram LPF/HPF PCB Guide page Detailed page L 13942296513 LPF/HPF PCB BFC SW 320uH 320uH u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 21
L 13942296513 BFC SW > 50uH CEK1330 > CEK1330 u163 The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Capacitor Connector several destination. AMP PCB For further information for SIDE A respective destinations, be sure to check with the schematic dia- gram. SIDE B P.C.Board Chip Part L 13942296513 BFC SW POWER TERMINAL SPEAKER OUTPUT u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 27
3 7 63 1515 0 SIDE A >FU 101 (A,40,13) Fuse 30 A CEK1330 >FU 102 (A,55,13) Fuse 30 A CEK1330 CN860 CN861 L 13942296513 R OUTPUT SPEAKER OUTPUT u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Q 632 (A,90,176) Transistor 2SD2395 IC 854 (B,282,45) IC NJM5532MD Q 633 (A,77,176) Transistor 2SB1566 IC 902 (B,108,151) Regulator IC NJM78M05DL1A Q 634 (A,104,176) Transistor 2SD2395 IC 903 (B,91,150) Regulator IC NJM79M05DL1A Q 650 (B,252,56) Chip Transistor DTC124EUA PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 33
L 854 (A,258,20) Ferri-Inductor CTF1007 R 204 (B,271,91) RS1/16S472J T 601 (A,55,91) Transformer YTT5007 R 211 (B,137,59) RS1/16S103J RY501 (A,138,46) Relay YSR5002 R 212 (B,136,61) RS1/16S102J RY502 (A,199,45) Relay YSR5002 R 213 (B,137,64) RS1/16S224J TH601 (A,212,174) Thermistor CCX1013 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 34
(B,185,104) RS1/16S102J R 516 (A,285,147) RD1/4PU100J R 357 (B,237,96) RS1/16S102J R 541 (B,178,97) RS1/16S103J R 358 (B,242,104) RS1/16S102J R 542 (B,187,104) RS1/16S103J R 359 (B,182,104) RS1/16S682J R 543 (B,235,97) RS1/16S103J R 360 (B,239,104) RS1/16S682J R 544 (B,244,104) RS1/16S103J PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 35
R 658 (A,29,66) RS1/2PMF100J R 967 (B,133,84) RS1/16S223J R 659 (A,25,91) RS1/2PMF100J R 969 (B,133,74) RS1/16S472J R 660 (A,59,123) RS1/2PMF220J CAPACITORS R 661 (A,44,120) RS1/2PMF220J R 662 (A,78,119) RS1/2PMF220J C 101 (B,25,54) CCSRCH470J50 R 665 (A,83,169) RS1/2PMF100J PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 36
(B,268,92) CKSRYB104K50 C 526 (B,184,162) CKSQYF105Z50 C 335 (A,203,89) CEAT4R7M50 C 527 (B,242,168) CKSQYF105Z50 C 336 (A,260,89) CEAT4R7M50 C 528 (B,254,162) CKSQYF105Z50 C 337 (A,211,94) CEAT4R7M50 C 535 (B,166,164) CKSQYF105Z50 C 338 (A,268,94) CEAT4R7M50 C 536 (B,177,170) CKSQYF105Z50 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 37
(A,107,56) CEAT220M25 C 686 (A,120,159) CEAT220M50 C 611 (A,116,46) CEAT471M16 C 691 (B,195,160) CKSRYB104K16 C 612 (B,93,49) CKSRYB103K50 C 692 (B,149,159) CKSRYB104K16 C 613 (A,101,57) CEAT220M25 C 693 (B,264,160) CKSRYB104K16 C 614 (B,148,86) CKSRYB104K50 C 694 (B,219,159) CKSRYB104K16 PRS-D4200F/XS/UC http://www.xiaoyu163.com...
Page 38
CKSRYB103K50 C 882 (B,221,67) CKSRYB103K50 C 883 (B,261,45) CKSRYB103K50 C 884 (B,278,46) CKSRYB103K50 C 885 (B,173,57) CKSRYB103K50 C 886 (B,214,58) CKSRYB103K50 C 887 (B,270,48) CKSRYB103K50 C 888 (B,288,49) CKSRYB103K50 C 951 (A,136,95) CEANP471M16 C 953 (B,130,78) CKSRYB473K50 u163 PRS-D4200F/XS/UC http://www.xiaoyu163.com...