Electrical System; Dash Panel - Cushman Turf Truckster Parts & Maintenance Manual

6 MAINTENANCE

6.26 ELECTRICAL SYSTEM _____________________________________________________

!
CAUTION
Always turn the ignition switch off and remove the
negative battery cable (Black) before inspecting or
working on the electrical system.
General precautions that can be taken to reduce
electrical problems are listed below.
1. Make certain all terminals and connections are clean
and properly secured.
2. Check the Interlock system, and fuses regularly.
If the Interlock does not function properly and the
problem cannot be corrected, contact an authorized
Jacobsen Dealer.
3. Keep the wire harness and all individual wires away
from moving parts to prevent damage.
4. Check the battery and battery charging circuit.
5. Do not wash or pressure spray around electrical
connections and components.
6. Circuits are protected by fuses located under the
front cowl and a fuse located near the cooling fan.

6.27 DASH PANEL _____________________________________________________________

The dash panel contains gauges and instrument lights to
display unit functions. Maintenance of the panel is limited
to replacing bulbs and setting the DIP switches. Remove
the four screws securing the instrument panel to the
dash.
Pull panel out, tilt panel forward and disconnect electrical
connector for easier access to rear of panel.
Light Bulb Replacement:
1. Determine which bulb needs to be replaced.
2. Rotate bulb holder 1/4 turn counter-clockwise and
pull up and away from dash panel.
3. Replace old bulb with a new bulb of equal type.
Location ........................... Replacement Bulb
A Voltmeter ............................C658
B Temperature Gauge............C658
C Fuel Gage...........................C658
D Hour Meter..........................C658
E Tachometer.........................C161
F Left Turn Signal ..................C161
G Oil Pressure........................C161
H Glow Plug ...........................C161
J Brake Fluid .........................C161
GB-28
Diesel Engine
Power Port 15 A
Brake Light,
5th Wheel Brake
10 A
10 A
Flashers &
Horn
Headlights 15 A
Gas Engine
Accessary 10 A
Power Port 15 A
Headlights 15 A
Brake Light,
5th Wheel Brake
10 A
10 A
Flashers &
Horn
Heater 10 A
Accessary
K Right Turn........................... C161
L Parking Brake..................... C161
M High Beam.......................... C658
N Alternator / Battery ............. C161
4. Place bulb and holder back into panel. Turn holder
1/4 turn clockwise to secure into panel. Ensure base
of holder is properly seated in panel.
20 A Dash Panel,
Fuel Pump
& Ignition
10 A Accessary
10 A Heater
Accessary
10 A Wiper,
Dome Light &
Back-Up Alarm
Dash Panel,
ECU, Fuel
20 A
& Engine Coils
25 A Radiator
Fan
15 A ECU, Main Relay,
Injectors
10 A Backup Alarm
Shift Switch
10 A ECU
10 A Wiper,
Dome Light &
Back-Up Alarm
Figure 6S