Page 1
HT-RC630 Ref. No. 4471-R3 072014 AV RECEIVER HT-RC630(B) MODEL (European and Asian models) RC-879M Black model B MDC 120V AC, 60Hz B MMR 220-240V AC, 50/60Hz B MPP 230V AC, 50Hz...
TX-SR333/ HT-R393/ HT-RC630 DEBUG MODE-1 AUDIO DEBUG MODE-1/5 The operations of DSP and DIR etc are able to checked by the information displayed on FL in this debug mode. This information will help to analysing digital audio no sound trouble.
Page 7
TX-SR333/ HT-R393/ HT-RC630 DEBUG MODE-6 HDMI RESOLUTION DISPLAY-1/6 HDMI-related operations can be checked to some extent by displaying HDMI resolution display mode. To enter this mode Hold down DISPLAY button for 3 seconds. Information display will last for about 8 seconds.
Page 8
TX-SR333/ HT-R393/ HT-RC630 DEBUG MODE-7 HDMI RESOLUTION DISPLAY-2/6 Status Input Mode HDMI input 4 4 4 2 4 b i DVI input 4 4 4 2 4 b i 4 4 4 2 4 b i H 1 0 7...
Page 9
TX-SR333/ HT-R393/ HT-RC630 DEBUG MODE-8 HDMI RESOLUTION DISPLAY-3/6 9 10 11 12 13 3 8 4 0 x 2 1 6 0 p / Resolution display Press RETURN button Status display 4 2 0 2 4 b i Display list...
Page 10
TX-SR333/ HT-R393/ HT-RC630 DEBUG MODE-9 HDMI RESOLUTION DISPLAY-4/6 3D Display 10 11 12 13 Resolution display 1 0 8 0 p / 3 D ) Status display F r a m e P a c k i n g 3D format...
Page 11
TX-SR333/ HT-R393/ HT-RC630 DEBUG MODE-10 HDMI RESOLUTION DISPLAY-5/6 PC RESOLUTION 9 10 11 12 13 Input Resolution display 1 0 2 4 x 7 6 8 p / Press RETURN button Status display H 2 5 6 R G B...
Page 12
TX-SR333/ HT-R393/ HT-RC630 DEBUG MODE-11 HDMI RESOLUTION DISPLAY-6/6 21:9 (1680 x 720 / 2560 x 1080) 9 10 11 12 13 Input Resolution display 2 5 6 0 x 1 0 8 0 p / Press RETURN button Status display...
Page 13
TX-SR333/ HT-R393/ HT-RC630 DEBUG MODE-12 SERVICE INFORMATION MODE Displaying Service information This service information display system is helpful in analyze the status when the unit goes into Protect mode and is powered off. Pay attention that the status will change if a button is pushed.
Page 14
TX-SR333/ HT-R393/ HT-RC630 OPERATION CHECK-1 NOTATION ABOUT ENTERING TEST MODE BY PRESSING BUTTON In this procedure, the following notations are used to simplify explanation of how to press button. e.g.-1 [TV/CD] + [ON/STANDBY] → [BD/DVD] This means "While holding down TV/CD button, press ON/STANDBY button then release both buttons and then press BD/DVD button".
Page 15
TX-SR333/ HT-R393/ HT-RC630 OPERATION CHECK-2 CONFIRMATION OF MODEL NAME AND DESTINATION Model name and destination can be confirmed the following operation. [TV/CD] + [ON/STANDBY] → [DIMMER](RT/PTY/TP) → [TONE] *4 e.g. S R 3 3 3 D x 2 2 0 0...
TX-SR333/ HT-R393/ HT-RC630 OPERATION CHECK-3 CONFIRMATION OF VOLTAGE-DETECTION PROTECTORS. <NOTE> Don't connect load nor short speaker terminals. 1. Do the following operation. 1-1. set the volume level to 25. 1-2. [TV/CD] + [ON/STANDBY] → [BD/DVD] 1-3. [TONE +] to the following test mode.
Page 17
TX-SR333/ HT-R393/ HT-RC630 OPERATION CHECK-4 CONFIRMATION OF CURRENT DETECTION PROTECTORS 1. Do the following operation. 1-1. set the volume level to 25. 1-2. [TV/CD] + [ON/STANDBY] → [CBL/SAT] 1-3. [TONE - ] to the following test mode. TEST 1-09 2. Confirm that relay is not cut off even if you connect the following load A to the following channels one by one.
Page 18
TX-SR333/ HT-R393/ HT-RC630 OPERATION CHECK-5 CONFIRMATION OF FL TUBE AND LED 1. Do the following operation. [TV/CD] + [ON/STANDBY] → [DIMMER] 2. Confirm that all LEDs and all segments of FL tube are lit. CONFIRMATION OF HEAD PHONE OPERATION Confirm the Listening Mode is automatically switched to "STEREO" mode when headphones plug is inserted into the PHONES jack.
TX-SR333/ HT-R393/ HT-RC630 OPERATION CHECK-6 CONFIRMATION OF VIDEO SIGNAL-DETECTION 1. Do the following operation. 1-1. set the volume level to 25. 1-2. [TV/CD] + [ON/STANDBY] → [PC] 1-3. [TONE +] to the following test mode. TEST 5-01 2. Confirm the following indicator lights up on the FL TUBE when the following video signal is input.
Page 20
TX-SR333/ HT-R393/ HT-RC630 OPERATION CHECK-7 TEST Config. Master Speaker etc. Output Output Output SW/F/C/S Vol. Relay Frequency Voltage Analog Input Only 1-00 SELECTOR MUTING TIME REDUCTION MODE Y/L/L/L 64(Ref) 1-01 IDLING TIMER Timer start Y/L/L/L Min(Min) IDLING TIMER V Protect (FL)
Page 21
TX-SR333/ HT-R393/ HT-RC630 OPERATION CHECK-8 Auto Measurement Mode TEST DSP Output channel Config. Master Speaker etc. Output Output Vol. Relay Frequency Voltage DSP Gain 4-00 -20dBFS Y/L/L/L 64(Ref) F/CS 1kHz (SW:30Hz) DSP Freq.Response 4-01 -20dBFS Y/L/L/L 64(Ref) F/CS 30Hz (SW:1kHz)
Page 22
TX-SR333/ HT-R393/ HT-RC630 OPERATION CHECK-9 TEST-3-00 Following frequencies are automatically written in the preset memory, when the unit goes into "TEST 3-00". PRESET No. MP*,MG* MW*(10k) MW*(9k) 89.9MHz 89.90MHz 89.90MHz 76.0MHz 97.9MHz 97.90MHz 97.90MHz 82.0MHz 98.9MHz 98.90MHz 98.90MHz 83.0MHz 107.1MHz 107.10MHz...
TX-SR333/HT-RC630 ADJUSTMENT PROCEDURE ADJUSTMENT OF IDLING CURRENT Applied to the following model. (Model) TX-SR333/HT-RC630 Procedure a. Pre-adjustment Set the following registers to minimum position before POWER ON. Set the voltages at the following terminals to the following voltage by adjusting the following registers, under the condition of no input and no load, immediately after POWER ON.
Page 24
The contents of the “Firmware Update” is “Confidential Information” as defined in the applicable “Service Center Agreement”. It is for the exclusive use of Onkyo/Integra Authorized Independent Service Centers. Dissemination or posting of this Firmware Update to any non-authorized individual or company is strictly prohibited.
Page 25
TX-SR333 / HT-R393 / HT-RC630 FIRMWARE UPDATE-2/2 USB Update (service mode) [Procedure] Overwriting is also possible. 1. Turn on the unit. It takes some time to start after you switch on the unit. 2. Select the USB input source. 3. Connect the USB storage device to USB port (rear panel) on the unit. Wait until Initializing of USB/NET finishes.
Page 26
HT-RC630 HT-RC630 EXPLODED VIEW OVERALL <NOTE> A401 No description screw is 3TTB+8B(3BC). 3TTB+8B(BC) Unit : mm WiFi & Bluetooth Module has already been certificated by FCC and IC. Information to the user. Indicate "Contains FCC ID: TX2-RTL8723AS", "Contains IC: 6317A- RTL8723AS" and following information to the 3P+6FN(3BC) host device installed.
Page 35
TX-SR333/HT-RC630/HT-R393 TX-SR333/HT-RC630/HT-R393 SCHEMATIC DIAGRAMS-09 POWER SUPPLY SECTION MODEL NO. TX-SR333/HT-R393/HT-RC630 SCHEMATIC DIAGRAM (PART-13) PS SECTION THE COMPONENTS IDENTIFIED MARK ARE CRITICAL FOR SAFETY, REPLACE ONLY WITH PART NUMBER SPECFIED. CAUTION VOLTAGE (MEASURED WITH VOLTMETER) IS DC VOLTAGE. (NO INPUT SIGNAL)
1/38 PAGE HT-RC630(B)MDC <Note> Parts marked by "NSP" are generally unavailable because <Notes> they are not in our Master Spare Parts List. (B) : Black color model <MDC> : 120V NOTE : THE COMPONENTS IDENTIFIED BY THE MARK Canadian/USA/(Mexico) model ! ARE CRITICAL FOR RISK OF FIRE AND ELECTRIC SHOCK.
Page 47
6/38 PAGE C4014 CHIP TYPE CERAMIC CAPACITOR CC725CH1H-221J1 342102214R1 C4015 CHIP TYPE CERAMIC CAPACITOR CC725CH1H-221J1 342102214R1 C4016 CHIP TYPE CERAMIC CAPACITOR CC725CH1H-221J1 342102214R1 C4017 CHIP TYPE CERAMIC CAPACITOR CC725CH1H-221J1 342102214R1 C4018 CHIP TYPE CERAMIC CAPACITOR CC725CH1H-221J1 342102214R1 C4019 UPZ TYPE PLASTIC FILM CAPACITOR 2AUPZTF221JE 376332214T C4020...
Page 48
7/38 PAGE C6051 TF TYPE PLASTIC FILM CAPACITOR ECQ-V50V-103J 374721034T C6052 TF TYPE PLASTIC FILM CAPACITOR ECQ-V50V-103J 374721034T C6053 TF TYPE PLASTIC FILM CAPACITOR ECQ-V50V-103J 374721034T C6054 TF TYPE PLASTIC FILM CAPACITOR ECQ-V50V-103J 374721034T C6250 TF TYPE PLASTIC FILM CAPACITOR ECQ-V50V-473J 374724734T C6251...
Page 49
8/38 PAGE R4056 CHIP TYPE CARBON RESISTOR RN72K1J-224JE 435032244R1 R4057 CHIP TYPE CARBON RESISTOR RN72K1J-224JE 435032244R1 R4058 CHIP TYPE CARBON RESISTOR RN72K1J-224JE 435032244R1 R4059 CHIP TYPE CARBON RESISTOR RN72K1J-224JE 435032244R1 R4060 CHIP TYPE CARBON RESISTOR RN72K1J-224JE 435032244R1 R4077 CHIP TYPE CARBON RESISTOR RN72K1J-223JE 435032234R1 R4078...
Page 50
9/38 PAGE R4305 CHIP TYPE CARBON RESISTOR RN72K1J-101JE 435031014R1 R4306 CHIP TYPE CARBON RESISTOR RN72K1J-222JE 435032224R1 R4307 CHIP TYPE CARBON RESISTOR RN72K1J-222JE 435032224R1 R4308 CHIP TYPE CARBON RESISTOR RN72K1J-222JE 435032224R1 R4309 CHIP TYPE CARBON RESISTOR RN72K1J-222JE 435032224R1 R4400 CHIP TYPE CARBON RESISTOR RN72K1J-102JE 435031024R1 R4401...
Page 51
10/38 PAGE R6200 CHIP TYPE CARBON RESISTOR RN72K1J-562JE 435035624R1 R6201 CHIP TYPE CARBON RESISTOR RN72K1J-562JE 435035624R1 R6202 CHIP TYPE CARBON RESISTOR RN72K1J-562JE 435035624R1 R6203 CHIP TYPE CARBON RESISTOR RN72K1J-104FE 435031042R1 R6204 CHIP TYPE CARBON RESISTOR RN72K1J-104FE 435031042R1 R6210 CHIP TYPE CARBON RESISTOR RN72K1J-472JE 435034724R1 R6211...