Page 3 Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice. Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.
Page 4 WCDMA networks and cause problems to 3G cellular phone communication in a wide area. • During testing never activate the GSM or WCDMA transmitter without a proper antenna load, otherwise GSM or WCDMA PA may be damaged. Page iv COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 5 Use only approved accessories and batteries. Do not connect incompatible products. CONNECTING TO OTHER DEVICES When connecting to any other device, read its user’s guide for detailed safety instructions. Do not connect incompatible products. Issue 1 COMPANY CONFIDENTIAL Page v Copyright © 2011 Nokia. All rights reserved.
Page 6 RM-609 ESD protection ESD protection Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone. Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use.
Page 8 Our policy is of continuous development; details of all technical modifications will be included with service bulletins. While every endeavour has been made to ensure the accuracy of this document, some errors may exist. If any errors are found by the reader, NOKIA MOBILE PHONES Business Group should be notified in writing/e- mail. Please state: •...
Page 9: Battery Information
Batteries' performance is particularly limited in temperatures well below freezing. Do not dispose of batteries in a fire! Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste. Issue 1 COMPANY CONFIDENTIAL Page ix Copyright © 2011 Nokia. All rights reserved.
Page 11 1 General Information 2 Service Tools and Service Concepts 3 BB Troubleshooting and Manual Tuning Guide 4 Cellular RF troubleshooting 5 Camera Module Troubleshooting 6 System Module Glossary Issue 1 COMPANY CONFIDENTIAL Page xi Copyright © 2011 Nokia. All rights reserved.
Page 15: Table Of Contents
1–10 Table 3 Data ................................ 1–11 Table 4 Messaging .............................. 1–11 Table 5 Power ..............................1–11 List of Figures Figure 1 View of RM-609............................1–5 Issue 1 COMPANY CONFIDENTIAL Page 1 – 3 Copyright © 2011 Nokia. All rights reserved.
Page 17: Product Selection
CS speech or CS video (max. 64 kbit/s). The HSDPA peak is 3.6 Mbit/s downlink (with limited use cases). In PS/CS mode, RM-609 supports DTM Class with multi slot class 11 (max. 4 RX + 3TX, sum 5). With EGPRS this means maximum download speed of up to 236.8 kbit/s simultaneously with speech.
Page 18: Product Features And Sales Package
• Colour tone: normal, sepia, B&W, vivid, negative • Zoom (digital): up to 4x Edit • On device Photo editor and Video editor (manual & automatic) Page 1 – 6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 19 • Nokia XpressPrint – direct printing via USB (PictBridge), Bluetooth (BPP), and WLAN (UPnP), from memory card or via online printing Store • 8 GB internal user memory • Nokia XpressTransfer – easy to transfer and organize photos and video between your device and a compatible PC • Nokia Lifeblog (mobile & PC) Music •...
Page 20 • Nokia 3.5 mm AV connector • 2.0 mm DC connector Add-on software framework • Symbian 9.2 OS • Nokia Series 60, 5th edition, feature pack 2 • Java: MIDP2.1 • C++ and Java SDKs • Flash Lite 4.0 Additional technical specifications •...
Page 21: Product And Module List
Type Music headset WH-207 Nokia Wireless Stereo Gateway AD-42W Mini speakers MD-8 MD-9 Hearing aids HDA-12 LPS-5 Wired headsets WH-205 WH-502 WH-700 WH-701 WH-800 WH-900 Issue 1 COMPANY CONFIDENTIAL Page 1 – 9 Copyright © 2011 Nokia. All rights reserved.
Page 22: Table 2 Car
Table 2 Car Enhancement Type Nokia Universal Mobile Holder CR-99 Speakerphone HF-310 HF-510 Car kit CK-100 Display car kit CK-600 Mobile charger DC-9 DC-10 DC-11 Page 1 – 10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 23: Technical Specifications
Main RF characteristics for GSM850/900/1800/1900 and WCDMA VIII/V/IV/II/I phones Parameter Unit Cellular system GSM850, EGSM900, GSM1800/1900, WCDMA VIII (900), WCDMA V (850), WCDMA IV (1700/2100), WCDMA II (1900) and WCDMA I (2100) Issue 1 COMPANY CONFIDENTIAL Page 1 – 11 Copyright © 2011 Nokia. All rights reserved.
Page 24 EDGE900: +5 … +27 dBm/3.2 mW … 501 mW EDGE1800: +0 … +26 dBm/1.0 mW … 398 mW EDGE1900:+0 … +26 dBm/1.0 mW … 398 mW Page 1 – 12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 25: Battery Endurance
Temperature conditions Environmental condition Ambient temperature Notes (Operational for short periods only) Normal operation Specifications fulfilled C...+55 Reduced performance Operational for shorts periods C...-15 only C...+70 Issue 1 COMPANY CONFIDENTIAL Page 1 – 13 Copyright © 2011 Nokia. All rights reserved.
Page 26 The standard for electrostatic discharge is IEC 61000-4-2, and this device fulfils level 4 requirements. RoHS This device uses RoHS compliant components and lead-free soldering process. Page 1 – 14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 29: Table Of Contents
Figure 6 BB5 Extended MJ-300 universal module jig concept ............... 2–19 Figure 7 Bluetooth testing concept with SB-6 ....................2–21 Figure 8 WLAN functionality testing concept with SB-7................. 2–22 Issue 1 COMPANY CONFIDENTIAL Page 2 – 3 Copyright © 2011 Nokia. All rights reserved.
Page 31: Service Tools
The table below gives a short overview of service devices that can be used for testing, error analysis, and repair of product RM-609. For the correct use of the service devices, and the best effort of workbench setup, please refer to various concepts.
Page 32: General Tools
The table below gives a short overview of service devices that can be used for testing, error analysis, and repair of product RM-609. For the correct use of the service devices, and the best effort of workbench setup, please refer to various concepts.
Page 33 4 Connect an FBUS cable (if necessary). 5 Start Phoenix service software. Note: Phoenix enables CU-4 regulators via USB when it is started. Reconnecting the power supply requires a Phoenix restart. Issue 1 COMPANY CONFIDENTIAL Page 2 – 7 Copyright © 2011 Nokia. All rights reserved.
Page 34: Fps-21
In order to access the SD memory card slots inside FPS-21, the prommer needs to be opened by removing the front panel, rear panel and heatsink from the prommer body. Page 2 – 8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 35 • Installation and warranty information SB-7 WLAN test box WLAN test requires defined position for the device. Place the phone on coordinates "E-1" for testing. Issue 1 COMPANY CONFIDENTIAL Page 2 – 9 Copyright © 2011 Nokia. All rights reserved.
Page 36 Nokia battery types BL-5K, BV-4D, BL-4D, BP-4L. SRT-6 Opening tool SRT-6 is used to open phone covers. Note: The SRT-6 is included in the Nokia Standard Toolkit. SS-210 Camera removal tool The camera removal tool SS-210 is used to remove/attach the camera module from/to the socket.
Page 37: Removing A Camera With The Removal Tool
1. Insert the camera tool on top of the camera, do not press the metal sheets down. 2. Press the camera down a little bit with the camera tool black plastic part. 3. Press the metal sheets down. Issue 1 COMPANY CONFIDENTIAL Page 2 – 11 Copyright © 2011 Nokia. All rights reserved.
Page 38: Cables
The table below gives a short overview of service devices that can be used for testing, error analysis, and repair of product RM-609. For the correct use of the service devices, and the best effort of workbench setup, please refer to various concepts.
Page 39: Ca-128Rs
Product-specific adapter cable for RF tuning. CA-31D USB cable The CA-31D USB cable is used to connect FPS-21 to a PC. It is included in the FPS-21 sales package. Issue 1 COMPANY CONFIDENTIAL Page 2 – 13 Copyright © 2011 Nokia. All rights reserved.
Page 40: Ca-89Ds
Power cable The PCS-1 power cable (DC) is used with a docking station, a module jig or a control unit to supply a controlled voltage. Page 2 – 14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 41: Service Concepts
• WCDMA/WLAN: 0.6+-0.1dB Service concepts POS (Point of Sale) flash concept Figure 2 POS flash concept Type Description Product specific tools SD-77 Care dummy battery Issue 1 COMPANY CONFIDENTIAL Page 2 – 15 Copyright © 2011 Nokia. All rights reserved.
Page 42: Bb5 Usb Only - Basic Flash Concept L3
Figure 3 BB5 USB only – Basic flash concept L3 Type Description Product specific devices SD-77 Care dummy battery Other devices PK-1 SW security device Page 2 – 16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 43: Table 5 Power
FPS-21 Flash prommer box AC-35 Power supply PK-1 SW security device SX-4 Smart card (for DCT-4 generation mobile device programming) PC with Phoenix service software Issue 1 COMPANY CONFIDENTIAL Page 2 – 17 Copyright © 2011 Nokia. All rights reserved.
Page 44: Bb5 Mj-300 Universal Module Jig Concept
Figure 5 BB5 MJ-300 universal module jig concept Type Description Product specific tools MJ-300 Module jig Other tools FPS-21 Flash prommer box PK-1 SW security device SX-4 Smart card Page 2 – 18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 45: Bb5 Extended Mj-300 Universal Module Jig Concept
BB5 Extended MJ-300 universal module jig concept Figure 6 BB5 Extended MJ-300 universal module jig concept Type Description Phone specific devices MJ-300 Module jig Other devices Issue 1 COMPANY CONFIDENTIAL Page 2 – 19 Copyright © 2011 Nokia. All rights reserved.
Page 46 Measurement equipment Cables CA-101 Micro USB cable PCS-1 DC power cable XRS-6 RF cable USB cable GPIB control cable CA-128RS Product specific RF adapter cable Page 2 – 20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 47: Bluetooth Testing Concept With
SW security device SX-4 Smart card SB-6 Bluetooth test and interface box Smart card reader PC with Phoenix service software Cables CA-101 Micro USB cable Issue 1 COMPANY CONFIDENTIAL Page 2 – 21 Copyright © 2011 Nokia. All rights reserved.
Page 48: Wlan Functionality Testing Concept With Sb-7
Product specific tools BP-4L Battery Other tools SX-4 Smart card PK-1 SW Security device Note: PK-1 can be used instead of PKD-1. Cables CA-101 Micro USB cable Page 2 – 22 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 51 3–43 Introduction to Bluetooth/FM radio troubleshooting ................3–43 Bluetooth BER test............................3–45 Bluetooth and FM radio self tests in Phoenix..................... 3–46 Bluetooth troubleshooting .......................... 3–47 Issue 1 COMPANY CONFIDENTIAL Page 3 – 3 Copyright © 2011 Nokia. All rights reserved.
Page 52 Figure 18 Bluetooth and FM radio self tests in Phoenix................. 3–46 Figure 19 GPS Quick Test window ........................3–50 Figure 20 GPS Control dialogue box ......................... 3–51 Page 3 – 4 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 53: Baseband Main Troubleshooting
Always start the troubleshooting procedure by running the Phoenix self tests. If a test fails, please follow the Dead or jammed device diagrams below. If the phone is dead and you cannot perform the self tests, go to troubleshooting . Issue 1 COMPANY CONFIDENTIAL Page 3 – 5 Copyright © 2011 Nokia. All rights reserved.
Page 57: Power And Charging Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Power and charging troubleshooting Backup battery troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 9 Copyright © 2011 Nokia. All rights reserved.
Page 58: Battery Current Measuring Fault Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Battery current measuring fault troubleshooting Troubleshooting flow Page 3 – 10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 59: General Power Checking Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide General power checking troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 11 Copyright © 2011 Nokia. All rights reserved.
Page 60: Dead Or Jammed Device Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Dead or jammed device troubleshooting Troubleshooting flow Page 3 – 12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 61: Dynamo Charging Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Dynamo charging troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 13 Copyright © 2011 Nokia. All rights reserved.
Page 62: Clocking Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Clocking troubleshooting Troubleshooting flow Page 3 – 14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 63: Usb Charging Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide USB charging troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 15 Copyright © 2011 Nokia. All rights reserved.
Page 64: Interface Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Interface troubleshooting USB data interface troubleshooting Troubleshooting flow Page 3 – 16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 65: Sim Card Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide SIM card troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 17 Copyright © 2011 Nokia. All rights reserved.
Page 66 RM-609 BB Troubleshooting and Manual Tuning Guide Figure 9 SIM power-on sequence on X2700. Sequence is first done at 1.8V and then changed to 3.0V. Page 3 – 18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 67: Microsd Card Troubleshooting
The IVE engine is a next generation imaging and video engine based on BCM2727B. The BCM2727B acts as imaging, video, display, and HDTV and SDTV hardware accelerator. Issue 1 COMPANY CONFIDENTIAL Page 3 – 19 Copyright © 2011 Nokia. All rights reserved.
Page 68 L1407 VBAT supply to BCM2727B J1413 Enable signal to IVE. This needs to be High for IVE to be Up. C1448 19.2MHz clock to IVE Page 3 – 20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 69: Ive Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide IVE troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 21 Copyright © 2011 Nokia. All rights reserved.
Page 70: Tv Out Troubleshooting
The following test points on the PWB help in the effective debugging and troubleshooting. Sr No Signal name Measuring point Description CVBS Gold pad E2003 SDTV signal Page 3 – 22 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 71: Sdtv Out Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide SDTV out troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 23 Copyright © 2011 Nokia. All rights reserved.
Page 72 RM-609 BB Troubleshooting and Manual Tuning Guide Figure 11 Expected SDTV CVBS PAL signal on Oscilloscope Figure 12 Expected SDTV CVBS NTSC signal on Oscilloscope Page 3 – 24 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 73: Display Module Troubleshooting
Table 7 Pixel defects Bright sub-pixels (sometimes called on-pixels or stuck-on) are characterized by the appearance of bright/colored pixels in, for example, black full screen picture. Issue 1 COMPANY CONFIDENTIAL Page 3 – 25 Copyright © 2011 Nokia. All rights reserved.
Page 74: Introduction To Display Troubleshooting
The following test points on the PWB help in the effective debugging and troubleshooting. Sr. No Signal name Measuring point Description L2473 1.8V supply to display VAUX1 L2472 2.78V supply to display Page 3 – 26 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 75: Display Fault Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Display fault troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 27 Copyright © 2011 Nokia. All rights reserved.
Page 76: Touch Panel Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Touch panel troubleshooting Troubleshooting flow Page 3 – 28 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 77: Illumination Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Illumination troubleshooting Charging illumination troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 29 Copyright © 2011 Nokia. All rights reserved.
Page 78: Menu Key Backlight Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Menu key backlight troubleshooting Troubleshooting flow Page 3 – 30 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 79: Keyboard Troubleshooting
Check for mechanical damage to the outer button, stuck or misplaced gaskets, broken switch, liquid contamination or broken solder pads or joints. Repair if possible. Electrical tests, measure: Issue 1 COMPANY CONFIDENTIAL Page 3 – 31 Copyright © 2011 Nokia. All rights reserved.
Page 80: Sensors Troubleshooting
• V2400 for short circuit. • R2400 for open circuit. • S2401 for short circuit. • N2200 main power ASIC may be broken. Sensors troubleshooting Accelerometer troubleshooting Troubleshooting flow Page 3 – 32 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 81: Magnetometer Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Magnetometer troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 33 Copyright © 2011 Nokia. All rights reserved.
Page 82: Proximity Sensor Troubleshooting
The input signal for each loop test can be either single-ended or differential. Exception to this is a digital microphone which needs input signal from an external sound source (laptop speaker) to playback, eg. 1 kHz sine wave from 5 cm distance. Page 3 – 34 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 83 HS_MIC & L2158 headset L2159 mic to IHF mono Internal Acoustica E2006 94 dBSPL digital l Input, E2007 micropho 1kHz sine ne to wave headset Issue 1 COMPANY CONFIDENTIAL Page 3 – 35 Copyright © 2011 Nokia. All rights reserved.
Page 84: External Earpiece Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide External earpiece troubleshooting Troubleshooting flow Page 3 – 36 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 85: External Microphone Troubleshooting
Clean, fix or replace if required. Electrical tests using the Phoenix audio sweep, measure: • D.C. voltage plus audio at J2100 • Same D.C. voltage plus inverse audio at J2101 Issue 1 COMPANY CONFIDENTIAL Page 3 – 37 Copyright © 2011 Nokia. All rights reserved.
Page 86 RM-609 BB Troubleshooting and Manual Tuning Guide Figure 13 Phoenix audio sweep Figure 14 Earpiece audio signals Page 3 – 38 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 87 • Gold Pads J2100 and J2101 maybe worn • L2103 maybe open circuit • L2104 maybe open circuit • N2200 audio ASIC may be broken Issue 1 COMPANY CONFIDENTIAL Page 3 – 39 Copyright © 2011 Nokia. All rights reserved.
Page 88: Internal Handsfree (Ihf) Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Internal handsfree (IHF) troubleshooting Troubleshooting flow Page 3 – 40 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 89: Internal Microphone Troubleshooting
Check for mechanical jamming by foreign object, sticky vibra shaft or obvious damage. Electrical tests using normal touchscreen haptics screenpress operation, ensure the option is activated and measure: Issue 1 COMPANY CONFIDENTIAL Page 3 – 41 Copyright © 2011 Nokia. All rights reserved.
Page 90: Als Technical Description And Troubleshooting
LED V1100 and is used to turn the display off when in-call to save power. Check for the display changing brightness in different lighting, with the phone user setting adjusted appropriately. Perform Dipro Self Test. Page 3 – 42 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 91: Re-Tuning Als
The BT RF signal is routed from BTFMRDS2.2 through the WLAN module to the shared WLAN/BT antenna in the phone's B-cover. Check the antenna pin contacts with Bluetooth/WLAN antenna. Figure 17 Bluetooth/WLAN antenna Issue 1 COMPANY CONFIDENTIAL Page 3 – 43 Copyright © 2011 Nokia. All rights reserved.
Page 92 The tests listed in the table below should be performed to verify whether the Bluetooth and FM receiver and BT and FM Self Tests in Phoenix transmitter are functional. The use of Self Tests are described in section Page 3 – 44 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 93: Bluetooth Ber Test
4. Choose Testing → Bluetooth LOCALS . 5. Locate the BT-box serial number (12 digits) found in the type label on the back of the JBT-9, or SB-6 Bluetooth test box. Issue 1 COMPANY CONFIDENTIAL Page 3 – 45 Copyright © 2011 Nokia. All rights reserved.
Page 94: Bluetooth And Fm Radio Self Tests In Phoenix
• ST_LPRF_IF_TEST • ST_LPRF_AUDIO_LINES_TEST • ST_BT_WAKEUP_TEST • ST_RADIO_TEST 7. To run the tests, click Start. Phoenix Figure 18 Bluetooth and FM radio self tests in Page 3 – 46 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 95: Bluetooth Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide Bluetooth troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 3 – 47 Copyright © 2011 Nokia. All rights reserved.
Page 96: Fm Radio Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide FM radio troubleshooting Troubleshooting flow Page 3 – 48 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 97: Fm Radio Testing
Note: You may alternatively use a known good FM radio broadcast as a test signal. 2. Attach the Nokia headset to the phone’s AV connector. 3. Use Scroll button to autotune to the radio frequency. 4. Set volume to suitable level.
Page 98: Gps Control
1. Place phone to Flash Adaptor. 2. Start Phoenix service software. 3. From the File menu, select Scan Product and check that the correct product version is displayed. Page 3 – 50 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 99 GPS_En_Reset & SleepX should be high, and Vdd_Dig, Vcc_TCXO & Vcc_PLL/VCO will be present. Receiver On turns on all RF sections of the ASIC and so all LDOs will be on. Issue 1 COMPANY CONFIDENTIAL Page 3 – 51 Copyright © 2011 Nokia. All rights reserved.
Page 100: Gps Troubleshooting
CWS antenna through a diplexer. The Bob software is downloaded from the host engine when the phone is powered on through the dedicated SPI interface. The Bob 38.4MHz clock is supplied from the Linko engine. Page 3 – 52 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 101: Wlan Settings For Phoenix
Host. The result column will change to Passed after a few seconds if operating properly. In addition, a test of the Bluetooth interface can be done by selecting the ST_BT_WAKEUP_TEST. This test verifies the interface to Bluetooth. Issue 1 COMPANY CONFIDENTIAL Page 3 – 53 Copyright © 2011 Nokia. All rights reserved.
Page 102: Wlan Functional Tests
The difference between the currents in (1) and (2) should be between 190 to 220mA. When WLAN is ON, the firmware has been downloaded and the WLAN module is in the receive state. When OFF WLAN is powered down. Page 3 – 54 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 103 2 To finish the test select the Finish option button. The difference between the two readings should be approximately 150mA and measures the transmit current in 11MBPS, 802.11b mode of operation. Issue 1 COMPANY CONFIDENTIAL Page 3 – 55 Copyright © 2011 Nokia. All rights reserved.
Page 104 WLAN network. From the testing toolbar select WLAN Rx Test option shown below. This test can be used to verify Rx configuration and functionality. Page 3 – 56 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 105: Wlan Auto Tuning
RF cable. Start Phoenix WLAN autotune window. Check the settings and verify your PC communicates with CMU200 via GBIP. Auto tuning procedure 1 Open the Tuning → WLAN_TX_TUNING menu and click Start Power Calibration. Issue 1 COMPANY CONFIDENTIAL Page 3 – 57 Copyright © 2011 Nokia. All rights reserved.
Page 106: Wlan Troubleshooting
RM-609 BB Troubleshooting and Manual Tuning Guide 2 To save the tune data, open the Extended Tuning menu and click Write. WLAN troubleshooting Troubleshooting flow Page 3 – 58 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 107: Baseband Manual Tuning Guide
• When certificate restoring for BB 5 products or IMEI rebuild for DCT-4 products is performed, existing data from Nokia System is programmed in the phone. The phone will be in the same condition as it was when it left the factory for the first time.
Page 108 5. Product code shown on the UI does not matter, because during restoring it will be replaced by the product code which is the latest one stored in Nokia system. 6. It is recommended to perform "Restore"-function without selecting "Flash Product"-option to avoid possible SW downgrade which causes the phone to die.
Page 109 RM-609 BB Troubleshooting and Manual Tuning Guide 7. Information from phone and Smart Card are read and connection to Tucson server is established. 8. Information from Nokia system is retreived and programmed in the phone. Issue 1 COMPANY CONFIDENTIAL Page 3 – 61...
Page 110: Product Code Change
Nokia System, and programmed in the phone. • After successful change, phone specific information in Nokia systems will match the new variant, and it can be used for e.g. certificate restoring. If you perform several product code changes, Nokia system will always be up to date with the latest successful event.
Page 111 Select product code of new variant from list. If the product code you want is not shown, please install correct data package including the variant. Select “OK” and “SWAP”. Issue 1 COMPANY CONFIDENTIAL Page 3 – 63 Copyright © 2011 Nokia. All rights reserved.
Page 112 BB Troubleshooting and Manual Tuning Guide Information from phone is read and connection to Tucson server is established. If “Flash Product” – option was selected, phone SW is programmed. Page 3 – 64 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 113 RM-609 BB Troubleshooting and Manual Tuning Guide New data retrieved from Nokia system is programmed in the phone. Confirmation about successful event is sent to Nokia system. Issue 1 COMPANY CONFIDENTIAL Page 3 – 65 Copyright © 2011 Nokia. All rights reserved.
Page 114: Energy Management Calibration
Energy Management (EM) calibration is performed to calibrate the setting (gain and offset) of AD converters in several channels (that is, battery voltage, BSI, battery current) to get an accurate AD conversion result. Hardware setup: Page 3 – 66 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 115 Write and/or repeat the procedure again. Energy Management Calibration window. 10. To end the procedure, close the Issue 1 COMPANY CONFIDENTIAL Page 3 – 67 Copyright © 2011 Nokia. All rights reserved.
Page 119 4–17 VDCDCA (Vlow) level ..........................4–18 level..............................4–18 RF tuning and testing ............................4–20 RF auto tuning and testing with Nokia Care Suite..................4–20 RF auto tuning procedure ..........................4–20 Automatic RF testing with Nokia Care Suite....................4–25 Troubleshooting with Testing And Tuning Tool ..................
Page 121: General Instructions For Cellular Rf Troubleshooting
RF components have been changed or memory (D3000) is corrupted. RF shield cans Once a peel-off type RF shield can is opened, a repair lid (Nokia code 9501325) should always be installed. RF shielding does not work at all if RF shield cans are left open.
Page 122: Cellular Rf Key Components
Linko RF has separate RF shielding cans for: • Älli N7512 + surroundings (Shield C) • QuBBE Z7513 + Ukko PA N7510 (Shield B) • Aura N7509 + surroundings (Shield A) Page 4 – 6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 123: Cellular Rf Main Troubleshooting
The maximum height of the shields is 1.70 mm. Cellular RF main troubleshooting Cellular RF main troubleshooting Context Always start the cellular RF related troubleshooting procedure by following the diagram below. Issue 1 COMPANY CONFIDENTIAL Page 4 – 7 Copyright © 2011 Nokia. All rights reserved.
Page 126: Self Test Troubleshooting
• Tests the basic functionality of the WCDMA transmitter. To get the best out of these instructions you need to have the valid schematics at hand. Page 4 – 10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 128: Rf-Bb Interface Self Test Troubleshooting
RM-609 Cellular RF troubleshooting RF-BB interface self test troubleshooting Troubleshooting flow Page 4 – 12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 129: Rf Supply Self Test Troubleshooting
RM-609 Cellular RF troubleshooting RF supply self test troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 4 – 13 Copyright © 2011 Nokia. All rights reserved.
Page 130: Vbat Level
Cellular RF troubleshooting VBAT level Check the VBAT level at the L7504. The level should be the same as the battery voltage and always on. Page 4 – 14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 131: Vxo Level
Check the VXO level (2.5V) at C2222. The signal is always on when the phone is in local mode. VIO level Check the VIO level (1.8V) at C2806. The signal is always on when the phone is in local mode. Issue 1 COMPANY CONFIDENTIAL Page 4 – 15 Copyright © 2011 Nokia. All rights reserved.
Page 132: Vref Level
The GSM or WCDMA transmitter (or receiver) has to be activated before the Vref supply voltage can be measured. Follow the instructions given in chapter 'Manual transmitter (TX) testing with Phoenix → GSM transmitter activation' or 'WCDMA transmitter activation'. Page 4 – 16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 133: Vhia (Vhi) Level
The GSM or WCDMA transmitter (or receiver) has to be activated before the VPA supply voltage can be measured. Follow the instructions given in chapter 'Manual transmitter (TX) testing with Phoenix → GSM transmitter activation' or 'WCDMA transmitter activation'. Issue 1 COMPANY CONFIDENTIAL Page 4 – 17 Copyright © 2011 Nokia. All rights reserved.
Page 134: Vdcdca (Vlow) Level
'Manual transmitter (TX) testing with Phoenix → GSM transmitter activation' or 'WCDMA transmitter activation'. Check the VPA voltage level at C7514. Page 4 – 18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 135 The VPA signal is continuously on when WCDMA TX is activated, but has a pulsed nature in GSM TX mode (the signal is on only when a GSM TX burst is transmitted). Note: The VPA signal is not tested by ST_CDSP_RF_SUPPLY_TEST. Issue 1 COMPANY CONFIDENTIAL Page 4 – 19 Copyright © 2011 Nokia. All rights reserved.
Page 136: Rf Tuning And Testing
RF components are changed or memory (D3000) is corrupted. RM-609 can be tuned automatically. Auto tuning is designed to align the phone's RF part easily and faster. It performs calibrations, tunings and measurements of RX and TX. The results are displayed and logged in a result file, if initiated.
Page 137 RM-609 Cellular RF troubleshooting Nokia Care Suite application. The following window opens: Start Nokia Care Suite version. Note: The window appearance may differ depending on the Fuse, Multi Software Updater, Product Support Tool For Store and Testing And Tuning Tool Note: are Care Suite add-on applications.
Page 138 RM-609 Cellular RF troubleshooting If the application is able to find a connected phone, the following view will open: Nokia Care Suite and Testing And Tuning Note: The window appearance may differ depending on the Tool versions Click on the RF Tuning button. The following view opens:...
Page 139 Select Cellular RF Tunings and Tests from the drop-down menu. Select the RF cable used (and possible RF splitter / RF shield box) from the drop-down menu. CA-128RS attenuation values are always taken automatically into account when RM-609 product is connected to Nokia Care Suite tool.
Page 140 14 If errors do happen, failed tuning/testing steps are marked with a red color and more detailed results are shown on the screen. An example fail case is shown below: Page 4 – 24 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 141: Automatic Rf Testing With Nokia Care Suite
RM-609 Cellular RF troubleshooting Nokia Care Suite and Testing And Tuning Note: The window appearance may differ depending on the Tool versions Automatic RF testing with Nokia Care Suite Testing And Tuning Tool add-on application can be used also for non-signalling RF tests. The automatic RF...
Page 142: Troubleshooting With Testing And Tuning Tool
RM-609 Cellular RF troubleshooting Nokia Care Suite and Testing And Tuning Note: The window appearance may differ depending on the Tool versions. RF Testing selection does all the same measurements as RF Tuning , but does not perform any tunings.
Page 145: Manual Transmitter (Tx) Testing With Phoenix
GSM transmitter activation Steps 1. Set the phone to local mode. 2. Activate the RF controls tool in Phoenix ( Testing → GSM → RF Controls ). Issue 1 COMPANY CONFIDENTIAL Page 4 – 29 Copyright © 2011 Nokia. All rights reserved.
Page 146 (for example CMU–200). Change power level (in “RF Controls” tool) and make sure the power reading follows accordingly. Page 4 – 30 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 148: Wcdma Transmitter Activation
Optional step (not needed if WCDMA TX activation only required): Check the basic TX parameters using a communication analyzer (for example CMU–200). Note: RM-609 WCDMA TX power classes: WCDMA I, IV, V and VIII class 3 (maximum output power +24 dBm), WCDMA II class 4 (maximum output power +21 dBm). Page 4 – 32...
Page 149: Manual Receiver (Rx) Testing With Phoenix
For GSM RSSI measurements, see chapter measurements/GSM RSSI measurement . For a similar test in WCDMA mode, see chapter WCDMA RSSI measurement . Issue 1 COMPANY CONFIDENTIAL Page 4 – 33 Copyright © 2011 Nokia. All rights reserved.
Page 150: Gsm Rx Chain Activation For Manual Measurements/Gsm Rssi Measurement
1. Set the phone to local mode. RX Control tool in Phoenix (Testing —> WCDMA —> RX Control) . 2. Activate 3. In the RX Control window, make the following settings: Page 4 – 34 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 151: Wcdma Rssi Measurement
RX frequency 2140.0 MHz 1960.0 MHz 2132.4 MHz 881.6 MHz 942.4 MHz Signal generator 2141.0 MHz 1961.0 MHz 2133.4 MHz 882.6 MHz 943.4 MHz frequency Issue 1 COMPANY CONFIDENTIAL Page 4 – 35 Copyright © 2011 Nokia. All rights reserved.
Page 152: Antenna
Check that the BT/WLAN and GPS antenna pads take proper contact to the C-clips on the PWB and the C-clips are clearly open. Figure 22 Antenna contacts Page 4 – 36 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 157: List Of Figures
Figure 38 Enlargement of a hot pixel....................... 5–14 Figure 39 Light from the flash has reflected on particles in front of the camera ........5–14 Issue 1 COMPANY CONFIDENTIAL Page 5 – 3 Copyright © 2011 Nokia. All rights reserved.
Page 160: The Effect Of Image Taking Conditions On Image Quality
The movement of camera or object sometimes cause blurring indoors or in dim lighting conditions because of long exposure time. This is normal; do not change the camera module. Page 5 – 6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 161 In practice, this means that when taking an image indoors and having, for example, a window behind the object, the result is usually poor. This is normal behaviour; do not change the camera module. Issue 1 COMPANY CONFIDENTIAL Page 5 – 7 Copyright © 2011 Nokia. All rights reserved.
Page 162 Generally this kind of reflections are common in all optical systems. This is normal behaviour; do not change the camera module. Page 5 – 8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 163 Figure 30 A lens reflection effect caused by sunshine Examples of good quality images Figure 31 Good image taken indoors Figure 32 Good image taken outdoors Issue 1 COMPANY CONFIDENTIAL Page 5 – 9 Copyright © 2011 Nokia. All rights reserved.
Page 164: Image Quality Analysis
However, it is possible that a larger particle disturbs the user, causing need for service. Figure 33 Effects of dust on optical path Page 5 – 10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 165: Testing Camera Image Sharpness
Any particles inside the cavity between the protection window and lens have most probably been trapped there in the assembly phase at a Nokia factory. Unauthorized disassembling of the product can also be the root of the problem. However, in most cases it should be possible to remove the particle(s) by using clean compressed air.
Page 166 A smeared fingerprint may be hard to see on the protective window but if will affect the image quality. These flares can be avoided by cleaning the window with a suitable cloth. Page 5 – 12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 167: Faulty Pixels In Images
When examining an image for defect pixels, test images should be viewed as 100% enlargements on a PC monitor. Issue 1 COMPANY CONFIDENTIAL Page 5 – 13 Copyright © 2011 Nokia. All rights reserved.
Page 168: Flash Photography Problems
• Dust reflections. Dust or water drops in front of the flash unit may reflect strongly to the camera sensor. See the following figure. Figure 39 Light from the flash has reflected on particles in front of the camera Page 5 – 14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 169: Main (Back) Camera Troubleshooting Flowcharts
RM-609 Camera Module Troubleshooting Main (back) camera troubleshooting flowcharts No recognizable viewfinder image Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 5 – 15 Copyright © 2011 Nokia. All rights reserved.
Page 170: Bad Image Quality Troubleshooting
RM-609 Camera Module Troubleshooting Bad image quality troubleshooting Troubleshooting flow Page 5 – 16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 171: Main Camera Troubleshooting
High for the regulator to be On. PRI_CAM_CLK R1430/C1471 External clock signal to primary camera PRI_CAM_I2C(1:0) R1477, R1478 I2C signals for primary camera Issue 1 COMPANY CONFIDENTIAL Page 5 – 17 Copyright © 2011 Nokia. All rights reserved.
Page 172: Secondary Camera Troubleshooting
Sr. No Reference Description H1450 Secondary camera on UI flex R1487, R1488 Pull-up resistors on the secondary camera I2C lines. Resistor value 4.7 KOHMS. Page 5 – 18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 173 High for the regulator to be On. SEC_CAM_CLK R1429/C1470 External clock signal to secondary camera SEC_CAM_I2C(1:0) R1487, R1488 I2C signals for secondary camera Issue 1 COMPANY CONFIDENTIAL Page 5 – 19 Copyright © 2011 Nokia. All rights reserved.
Page 174: Flash Troubleshooting
RM-609 Camera Module Troubleshooting Troubleshooting flow Flash troubleshooting Context The following references on the PWB help in the effective debugging and troubleshooting of the flash. Page 5 – 20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 175 Measuring point Description VBAT L1408/L1409 VBAT supply to flash driver FLASH_TRIGGER J1425 Flash trigger signal FLASH_ENABLE J1499 Flash enable signal TORCH_EN J1498 Torch mode enable signal Issue 1 COMPANY CONFIDENTIAL Page 5 – 21 Copyright © 2011 Nokia. All rights reserved.
Page 179 6–34 EGSM900 frequencies ............................ 6–34 GSM1800 frequencies............................ 6–35 GSM1900 frequencies............................ 6–37 WCDMA I (2100) Rx frequencies ........................6–38 WCDMA I (2100) Tx frequencies ........................6–39 Issue 1 COMPANY CONFIDENTIAL Page 6 – 3 Copyright © 2011 Nokia. All rights reserved.
Page 180 Figure 61 Internal microphones diagram......................6–30 Figure 62 Vibra diagram ............................ 6–30 Figure 63 AV connector............................6–31 Figure 64 Linko RF block diagram ........................6–31 Page 6 – 4 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 181: Introduction
USB transceiver ISP1707 HS USB transceiver D3300 MicroSD connector X3200 eMMC 8GB internal mass memory D3200 Touch module connector X2403 Imaging processor D1400 AV connector Issue 1 COMPANY CONFIDENTIAL Page 6 – 5 Copyright © 2011 Nokia. All rights reserved.
Page 182 Mean Vibra SMD type vibra M2100 Accelerometer 3-axis accelerometer Ahti N1102 Magnetometer 3-axis magnetic sensor N1103 Combined Proximity DiPro N1100 Sensor and Ambient Light Sensor Page 6 – 6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 187: Energy Management
Figure 41 Blade battery connector Charging The phone is charged through the 2 mm Nokia standard interface charger plug. Charging is controlled by dynamo charging IC BQ24156 (N3323). Dynamo charger detection is handled by EM ASIC (N2200) and external components are needed to protect the baseband module against EMC, reverse polarity and transient frequency deviation.
Page 188: Power Key And System Power Up
SLEEP mode is entered only from PWR_ON mode with the aid of SW when the system’s activity is low. FLASHING FLASHING mode is for SW downloading. Page 6 – 12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 191: Sim Interface
The combined switch signal is connected through an inverter to Gazoo/Pearl SimDetX input. The following figure shows the principle of SIM circuitry with the Puzzle. Issue 1 COMPANY CONFIDENTIAL Page 6 – 15 Copyright © 2011 Nokia. All rights reserved.
Page 192: Device Memory
O interface. It is a dual supply device which requires VCC of 2.9V for the NAND core and VCCQ of 1.8V for the MMC I/O interface. BOB1.0M-b module The BOB1.0M-b module provides full 802.11b,g & n WLAN, BT 2.1 + EDR, FM RDS and FM TX connectivity. Page 6 – 16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 193 The internal SMPS supplies the whole BOB1.0M-b solution from the phone battery supply, VBAT, apart from VIO, which is needed for interface signal reference levels. Issue 1 COMPANY CONFIDENTIAL Page 6 – 17 Copyright © 2011 Nokia. All rights reserved.
Page 194: Gps Interface
D operates in Multi-master mode and the REF clock is requested via AGPS_CLK_REQ signal connected to RAPU genio46. REFOUT_EXT2 single ended 38.4 MHz analog clock from Linko RF is provided to GPSCost4.1D. Figure 46 GPS interface Page 6 – 18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 195: Usb
Hot swap is supported, which means that USB devices may be plugged in and out at any time. MicroUSB connector This phone is provided with a specific connector for microUSB. Figure 48 MicroUSB connector Issue 1 COMPANY CONFIDENTIAL Page 6 – 19 Copyright © 2011 Nokia. All rights reserved.
Page 196: Charger Interface
The ambient light sensor detects the level of ambient light and adjusts the display and key brightness accordingly whenever the display is active. Covering this sensor results in dimmed display and key lights. Page 6 – 20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 197: Imaging And Video
• nHD OLED DSI display • NTSC/PAL analog TV-out MeSSI-16 and CCP2-Tx are the key interfaces between RapuYama and BCM2727B. BCM2727B has in-build 256Mb stacked SDRAM. Issue 1 COMPANY CONFIDENTIAL Page 6 – 21 Copyright © 2011 Nokia. All rights reserved.
Page 198: Display Module
For the Analog TV-out, video data is passed from the host to the BCM2727B over MeSSI-16 interface and BCM2727B sends it to the AV connector. Audio is routed separately by the host to the AV connector. Page 6 – 22 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 199: Cameras
The secondary camera is a VGA fixed focus camera module. It is SMIA compliant and is configured by the BCM2727B using I2C control bus. Image data is transferred to the BCM2727B for further processing over a CCP based bus (SEC_CAM_CCP). Issue 1 COMPANY CONFIDENTIAL Page 6 – 23 Copyright © 2011 Nokia. All rights reserved.
Page 200: Illumination
A single white LED is used for charging indication. The LED is connected to EM ASIC “ChInd” pin and blinks only during dead battery USB charging in intervals of 1.5s. When under SW control, this LED provides a fixed light level. Page 6 – 24 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 201: Keyboard Interface
All the keys with the exception of the power key are on a key matrix connected through a small type IO Expander (25 bump) to RAPU. Figure 55 Keyboard interface Issue 1 COMPANY CONFIDENTIAL Page 6 – 25 Copyright © 2011 Nokia. All rights reserved.
Page 202: Accelerometer
The operating temperature is -20°C to +85°C. The operating supply voltages are: • Analogue supply +2.4V to +3.6V • Digital interface supply +1.70V to analogue supply voltage. Page 6 – 26 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 203: Audio Concept
Audio HW architecture TPA6140 (N2000), BoostMono (N2150) along with mixed-signal ASIC Gazoo/Pearl provides the analogue audio output interfaces and RAPU provides the digital audio output interface support. Issue 1 COMPANY CONFIDENTIAL Page 6 – 27 Copyright © 2011 Nokia. All rights reserved.
Page 205: Internal Earpiece
Digital microphones used are Knopfler and are connected to Rapu. DigiMic CLK is connected to RAPU Genio72 and DigiMic DATA is connected to Rapu Genio39. Issue 1 COMPANY CONFIDENTIAL Page 6 – 29 Copyright © 2011 Nokia. All rights reserved.
Page 206: External Earpiece And Microphone
The AV connector handles both audio and video signals output. It has audio left and right signals separately (pins 4 and 5) and the microphone signal wired to pin 3. Page 6 – 30 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 207: Cellular Rf Technical Description
The front end module called QuBBE contains the needed front end filters and the switches. QuBBE contains: • 3 duplexers (Band II, V, VIII) • 1 triplexer (Band I, IV) Issue 1 COMPANY CONFIDENTIAL Page 6 – 31 Copyright © 2011 Nokia. All rights reserved.
Page 208: Receiver (Rx)
• Common regulators for GSM and WCDMA • Boost and SMPS regulators in Aura • Feeding the supply voltage to PA • Operation frequency varies depending on the used system Page 6 – 32 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 209 In WCDMA and EDGE mode, the output power is tuned by output level of Älli. The supply voltage in WCDMA mode is adjusted in power levels to optimize the current consumption. Issue 1 COMPANY CONFIDENTIAL Page 6 – 33 Copyright © 2011 Nokia. All rights reserved.
Page 219 3732 2741 888,2 3552,8 2966 933,2 3732,8 2742 888,4 3553,6 2967 933,4 3733,6 2743 888,6 3554,4 2968 933,6 3734,4 2744 888,8 3555,2 2969 933,8 3735,2 Issue 1 COMPANY CONFIDENTIAL Page 6 – 43 Copyright © 2011 Nokia. All rights reserved.
Page 220 3760 2776 895,2 3580,8 3001 940,2 3760,8 2777 895,4 3581,6 3002 940,4 3761,6 2778 895,6 3582,4 3003 940,6 3762,4 2779 895,8 3583,2 3004 940,8 3763,2 Page 6 – 44 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 221 3788 2811 902,2 3608,8 3036 947,2 3788,8 2812 902,4 3609,6 3037 947,4 3789,6 2813 902,6 3610,4 3038 947,6 3790,4 2814 902,8 3611,2 3039 947,8 3791,2 Issue 1 COMPANY CONFIDENTIAL Page 6 – 45 Copyright © 2011 Nokia. All rights reserved.
Page 222 3816 2846 909,2 3636,8 3071 954,2 3816,8 2847 909,4 3637,6 3072 954,4 3817,6 2848 909,6 3638,4 3073 954,6 3818,4 2849 909,8 3639,2 3074 954,8 3819,2 Page 6 – 46 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 223 3084 956,8 3827,2 2860 3648 3085 3828 2861 912,2 3648,8 3086 957,2 3828,8 2862 912,4 3649,6 3087 957,4 3829,6 2863 912,6 3650,4 3088 957,6 3830,4 Issue 1 COMPANY CONFIDENTIAL Page 6 – 47 Copyright © 2011 Nokia. All rights reserved.
Page 227 Clock Timing Sleep and interrupt block of Tiku Continuous wave D/A-converter Digital-to-analogue converter Digital-to-analogue converter Digital Battery Interface DBus DSP controlled serial bus connected between UPP_WD2 and Helgo Issue 1 COMPANY CONFIDENTIAL Page Glossary– 3 Copyright © 2011 Nokia. All rights reserved.
Page 228 High speed circuit switched data (data transmission connection faster than GSM) Hardware Input/Output IBAT Battery current Integrated circuit ICHAR Charger current Interface Integrated hands free IMEI International Mobile Equipment Identity Page Glossary– 4 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 229 Software tool of DCT4.x and BB5 Personal Information Management Phase locked loop (Phone) Permanent memory General Purpose IO (PIO), USARTS and Pulse Width Modulators PURX Power-up reset Printed Wiring Board Issue 1 COMPANY CONFIDENTIAL Page Glossary– 5 Copyright © 2011 Nokia. All rights reserved.
Page 230 Universal Energy Management chip (Enhanced version) UEMEK See UEME User Interface UPnP Universal Plug and Play Universal Phone Processor UPP_WD2 Communicator version of DCT4 system ASIC Page Glossary– 6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2011 Nokia. All rights reserved.
Page 231: Issue
Wideband code division multiple access Watchdog WLAN Wireless local area network XHTML Extensible hypertext markup language Zocus Current sensor (used to monitor the current flow to and from the battery) Issue 1 COMPANY CONFIDENTIAL Page Glossary– 7 Copyright © 2011 Nokia. All rights reserved.

Nokia RM-609 Service Manual

Table of Contents

Service Tools/Service Concepts

Table of Contents

Table of Contents

List of Figures

Table of Contents

Quick Links

Chapters

Troubleshooting

Related Manuals for Nokia RM-609

Summary of Contents for Nokia RM-609

Table of Contents